operators_manual
Table Of Contents
- Safety
- Emergency
- Roadside Assistance
- Low Air Alarm
- Stop Engine Light
- Low Oil Pressure
- Engine is Overheating
- How to Inspect and Replace a Fuse
- How to Jump Start a Battery
- Where are the fuses located?
- How to Recover a Vehicle
- Manually Release the Parking Brake
- Recovery Hitch
- How to use a Recovery Hitch
- How to Prepare the Axles for Towing
- How to Manually Lock a Differential
- Recovery Hitch Capacities
- Best Practices for Recovery Rigging
- Returning to Service After Recovering
- What to do if the Vehicle is Stuck in Sand, Mud, Snow or Ice
- Towing the Vehicle
- Controls
- Instrument Cluster
- Bulb Check
- Warning Lights
- Guide to the Warning Symbols
- Axle, Traction Control
- Axle, Stability Control (Option)
- Axle, Front Driven
- Axle, Oil Temperature (Forward or Rear)
- Brakes, Antilock Brake System
- Brake, Park Brake
- Brakes, Trailer Antilock Brake System
- Emissions, High Exhaust System Temperature
- Emissions, Malfunction Indicator Light
- Emissions, Engine Derate
- Diesel Particulate Filter (DPF) Warning Light
- Diesel Exhaust Fluid (DEF) Lamp
- Fifth Wheel Slide Unlocked
- Fifth Wheel Locked
- Fifth Wheel Unlocked
- Engine, Check Engine
- Engine, Low Coolant Level
- Engine, Coolant Temperature
- Engine, Oil Temperature
- Engine, Oil Pressure
- Voltmeter
- Engine, Overspeed Air Shutdown
- Engine, Retarder (Brake)
- Engine, Stop Engine
- Engine Wait-to-Start Light
- Engine, Air Filter Restriction
- Fuel Filter Restriction
- Lights, High Beam
- Seat Belt Fasten
- Tire Inflation (TPMS)
- Transmission, Check
- Transmission, Neutral
- Turn Signal, Left
- Turn Signal, Right
- Gauges
- Peterbilt Digital Display
- Display Notifications
- Views
- Menu
- Post Trip
- Menu Control Switch
- Ignition Key Switch
- Secondary Ignition Switch
- Exterior Lighting Self-Test (ELST)
- Steering Column Controls
- Rear Suspension Controls
- How to Use the Turn Signal
- How to Turn on High Beams
- How to Momentarily Flash High Beams
- How to Flash Marker and Clearance Lights
- Operate the Windshield Wipers
- How to Spray Windshield Washer Fluid
- Trailer Brake Hand Valve
- Dash Switches
- Axle, Diff-Lock - Dual
- Axle, Diff-Lock - Forward Rear
- Axle, Diff-Lock - Steer
- Axle, Diff-Lock - Rear Rear
- Axle, Diff-Lock - Single Rear
- Axle, Inter-Axle Differential Locked (Tandem)
- Axle, Differential Lock - Tridrive
- Axle, Two Speed
- Batteries, Low Voltage Disconnect (LVD)
- Brakes, ABS Off-Road
- Brakes, Parking Brake Valve
- Cab Dimmer Switch
- Dump Truck Gate
- Engine, Brake On/Off
- Engine, Cruise Control On/Off
- Engine, Cruise Control Set/Resume
- Engine, Fan Override
- Engine, Heater
- Engine, Remote Throttle
- Engine, Overspeed Air Shutdown (Manual)
- Engine, Overspeed Air Shutdown (Test)
- Exhaust, Diesel Particulate Filter (DPF) Regeneration
- Fifth Wheel Slide
- Fuel Heater
- Generic Air, Accessory
- Generic, Spare SPARE
- Ignition Key Switch
- Lights, Auxiliary
- Lights, Beacon
- Lights, Daytime Running (Override)
- Lights, Dome
- Lights, Flood
- Lights, Flood (Spare)
- Lights, Fog
- Lights, Hazard
- Lights, Headlight
- Lights, Marker/Clearance
- Lights, Marker/Clearance/Trailer
- Lights, Park Light
- Lights, Spot
- Mud and Snow Traction Control
- Pintle Hook
- Power Take-off (PTO)
- Power Take-off (PTO), Forward
- Power Take-off (PTO), Rear
- Suspension, Axle, Pusher
- Suspension, Axle, Tag
- Suspension, Dump
- Suspension, Air Retention
- Suspension, Third Axle Lift
- Trailer Air Supply
- Trailer, Axle (3rd Axle) Lift
- Trailer, Axle Lift Forward
- Trailer, Axle Lift Rear
- Trailer, Belly Dump
- Trailer, Dump Gate
- Trailer, Belly Dump Gate Center
- Trailer, Belly Dump Gate Front
- Trailer, Belly Dump Gate Rear
- Trailer, Hotline
- Trailer, Suspension Air Dump
- Transmission, Transfer Case
- Transmission, Transfer Case Two-Speed
- Winch Clutch
- Heating and Air Conditioning
- Air Conditioner Control Panel
- How to Manually Control the Cab Air Conditioner
- Left Hand Accessories Overhead
- Right Hand Accessories Overhead for Dual Sit Steer Applications
- Radio Stereo System (option)
- Driving
- Starting and Operating
- Starting and Warming Up
- Engine Operations
- Transmission
- Brakes
- Axle and Suspension
- Trailer Operation
- Engine Aftertreatment System
- Driving Tips and Techniques
- Stopping the Vehicle
- Maintenance
- New Vehicle Maintenance Schedule
- First Day
- First 50-100 mi / 80-160 km
- First 500 mi / 800 km
- First 2,000 mi / 3,218 km
- First 3,000-5,000 mi / 4,800-8,000 km
- Maintenance Schedule
- At first 15,000 mi / 24,000 km or at first PM
- Component Specific Intervals
- Every 15,000 mi / 24,000 km / Monthly
- Every 25,000 mi / 40,000 km / 6 Months
- Every 30,000 mi / 48,000 km
- Every 60,000 mi / 96,000 km / 6 Months
- Every 120,000 mi / 192,000 km / Annually
- Every 240,000 mi / 384,000 km
- Every 300,000 mi / 480,000 km / 6,750 Hours / 3 Years
- Every 500,000 mi / 800,000 km / 5 years
- Every 750,000 mi / 1,200,000 km/ 24,000 Hours / 8 years
- Lubricants
- Checking Oil Level
- Inspect Power Steering Fluid
- Air System
- Dual Air System Function Test
- Air Dryer Maintenance
- Air Tanks
- Air Gauges and Air Leaks
- Air Compressor
- Brake System
- Cab Maintenance
- Cooling System Maintenance
- Safety Restraint System - Inspection
- Windshield Wiper/Washer
- Electrical System
- Engine Aftertreatment System Power Requirements
- Low Voltage Disconnect (LVD) (option)
- Vehicle Light Bulb Specifications
- Aiming Headlights
- Fuses, Circuit Breakers and Relays
- Altering the Electrical System
- Vehicle CAN Bus
- Batteries
- Cranking Battery Specification
- Removing Batteries
- Installing Batteries
- Slow Battery Charging
- Alternator
- Engine Maintenance
- Fuel System
- Frame
- Front Axle and Suspension
- Heater and Air Conditioner Maintenance
- Noise and Emission Control
- Rear Axle and Suspension
- Steering System
- Driveline
- Tires
- Wheels
- Transmission Maintenance
- Mechanical Clutch
- Specification Reference Charts
- Information
- Index
Every 500,000 mi / 800,000 km / 5 years..........................................................................................179
Every 750,000 mi / 1,200,000 km/ 24,000 Hours / 8 years...............................................................180
Lubricants..........................................................................................................................................181
Checking Oil Level............................................................................................................................ 182
Inspect Power Steering Fluid............................................................................................................ 183
Air System.........................................................................................................................................183
Dual Air System Function Test..........................................................................................................185
Air Dryer Maintenance...................................................................................................................... 185
Air Tanks........................................................................................................................................... 187
Air Gauges and Air Leaks................................................................................................................. 188
Air Compressor................................................................................................................................. 189
Brake System....................................................................................................................................190
Cab Maintenance..............................................................................................................................193
Cooling System Maintenance........................................................................................................... 198
Safety Restraint System - Inspection................................................................................................203
Windshield Wiper/Washer.................................................................................................................205
Electrical System...............................................................................................................................206
Engine Maintenance......................................................................................................................... 215
Fuel System...................................................................................................................................... 221
MAINTENANCE -
Y53-6096-1C1 (09/20) 141
5