SDS

5. FIRE FIGHTING MEASURES
Lower Explosive Limit:
n/d
Upper Explosive Limit:
n/d
6. ACCIDENTAL RELEASE MEASURES
Spill Procedures:
Wipe or scrape up spill material. Maintain good ventilation for large spills. Place scrap material in a well-
ventilated area and allow to cure to rubber. Clean up spills thoroughly as residue is slippery.
7. HANDLING AND STORAGE
Storage:
Store in a dry area below 90 degrees F. Keep container closed when not in use.
Handling:
Avoid contact with skin and eyes. Do not wear contact lenses. Do not inhale vapors. Wash hands before
eating and smoking.
8. EXPOSURE CONTROLS/PERSONAL PROTECTION
Eyes:
Safety glasses.
Skin:
Neoprene or nitrile gloves recommended.
Ventilation:
General; local exhaust ventilation as necessary to control any air contaminants to within their exposure
limits (or to the lowest feasible levels when limits have not been established) during the use of this product.
Respiratory Protection:
An approved organic vapor respirator should be worn when exposures are expected to exceed the
applicable limits.
Comments:
When heated to temperatures above 300 degrees F. in the presence of air, this product can form
formaldehyde vapors. Formaldehyde is a potential cancer hazard and a known skin and respiratory
sensitizer. Safe handling conditions may be maintained by keeping vapor concentrations below the OSHA
permissible limit for formaldehyde
9. PHYSICAL AND CHEMICAL PROPERTIES
Appearance:
Copper-colored paste
Odor:
Mild
Boiling Point:
Not applicable, polymeric material
pH:
7-8
Solubility in Water:
Polymerized
Specific Gravity:
1.05
VOC(Wt.%):
<3%; <31 g/l
Vapor Pressure:
<5 mm Hg @ 80°F
Vapor Density (Air=1):
3.0
Evaporation Rate:
n/d
10. STABILITY AND REACTIVITY
Chemical Stability:
Stable at normal conditions
Hazardous Polymerization:
Will not occur
Incompatabilities:
Polymerized by contact with moisture, Strong oxidizers, Acids, Iron
Conditions to Avoid:
Exposure to moisture
Hazardous Products of Combustion:
Oxides of nitrogen, Oxides of carbon, Methyl ethyl ketone, possibly methyl
ethyl ketoxime, Silica fume, Formaldehyde
11. TOXICOLOGICAL INFORMATION
See Section 3
12. ECOLOGICAL INFORMATION
No data available
13. DISPOSAL CONSIDERATIONS
Recommended Method of Disposal:
Disposal should be made in accordance with federal, state and local regulations.
US EPA Waste Number:
NH - Not a RCRA Hazardous Waste Material
14. TRANSPORTATION INFORMATION
DOT (49CFR 172)
U.S. Department of Transportation - DOT - 49 CFR (Ground)
DOT Shipping Name:
Not regulated
Product Name: Item No. 81878
101BR SENSOR SAFE ULTRA COPPER
SILICONE HIGH TEMP RTV 3 OZ