SDS

ManualsBrandsPermatex ManualsAutomotivePermatex 22058 Dielectric Tune-Up Grease, 3 oz. Tube

Material Safety Data Sheet

1. PRODUCT IDENTIFICATION

Product Name: DIELECTRIC TUNE-UP GREASE 3 OZ

Item No: 22058

Product Type: Lubricant

2. COMPOSITION/INFORMATION ON INGREDIENTS

Component Weight% ACGIH; TLV-TWA OSHA PEL

POLYDIMETHYLSILOXANE

63148-62-9

>70 Not listed Not listed

MODIFIED SILICON DIOXIDE

68611-44-9

<10 Not listed Not listed

OXIRANE, METHYL-, POLYMER

52624-57-4

0.5-5.0 Not listed Not listed

3. HAZARDS IDENTIFICATION

Toxicity:

May cause eye and skin irritation. Note: This product does not contain microcyrstalline silica.

Primary Routes of Entry:

Eye and skin contact, ingestion, inhalation

Signs and Symptoms of Exposure:

Overexposure may cause eye and skin redness.

Aggravated Medical Condition:

None known.

4. FIRST AID MEASURES

Ingestion:

If swallowed, do not induce vomiting - seek medical advice. Never give anything by mouth to an

unconscious person.

Inhalation:

Move to fresh air in case of accidental inhalation of vapours.

Skin Contact:

Wash off with soap and water If skin irritation persists, call a physician

Eye Contact:

In case of contact, immediately flush eyes with plenty of water for at least 15 minutes and get medical

attention if irritation persists.

5. FIRE FIGHTING MEASURES

Flash Point °F(C°):

>200°F TCC

Recommended Extinguishing Media:

Carbon Dioxide, Dry Chemicals, Foam.

Special Fire-Fighting Procedures:

No special procedures.

Hazardous Products of Combustion:

Oxides of carbon, Oxides of silicon, Formaldehyde

Unusual Fire/Explosion Hazards:

None.

Lower Explosive Limit:

n/d

Upper Explosive Limit:

n/d

6. ACCIDENTAL RELEASE MEASURES

Spill Procedures:

Maintain good ventilation. Take up with an inert absorbent. Store in a closed waste container until disposal.

Clean up spills thoroughly as residue is slippery.

7. HANDLING AND STORAGE

Storage:

Store below 100°F.

Handling:

Avoid prolonged skin contact. Keep away from eyes. Wash hands before eating and smoking.

8. EXPOSURE CONTROLS/PERSONAL PROTECTION

Eyes:

Safety glasses.

Skin:

Neoprene or nitrile gloves recommended.

Ventilation:

Use only in well ventilated area.

1 of 3

ITW Permatex

10 Columbus Blvd.

Hartford, CT 06106 USA

Telephone: 1-87-Permatex

(877) 376-2839

Emergency: 800-255-3924 (ChemTel)

International Emergency: 00+ 1+ 813-248-0585

Summary of content (3 pages)

PAGE 1
ITW Permatex 10 Columbus Blvd. Hartford, CT 06106 USA Telephone: 1-87-Permatex (877) 376-2839 Emergency: 800-255-3924 (ChemTel) International Emergency: 00+ 1+ 813-248-0585 Material Safety Data Sheet 1. PRODUCT IDENTIFICATION Product Name: Item No: Product Type: DIELECTRIC TUNE-UP GREASE 3 OZ 22058 Lubricant 2.
PAGE 2
Product Name: DIELECTRIC TUNE-UP GREASE 3 OZ Item No. 22058 8. EXPOSURE CONTROLS/PERSONAL PROTECTION Respiratory Protection: Not required under normal use. An approved organic vapor respirator should be worn when exposures are expected to exceed the applicable limits. 9. PHYSICAL AND CHEMICAL PROPERTIES Appearance: Odor: Boiling Point: pH: Solubility in Water: Specific Gravity: VOC(Wt.%): Vapor Pressure: Vapor Density (Air=1): Evaporation Rate: White, translucent grease Mild n/d Does not apply Nil 1.
PAGE 3
Product Name: DIELECTRIC TUNE-UP GREASE 3 OZ Item No. 22058 16. OTHER INFORMATION HEALTH 1, FLAMMABILITY 1 , REACTIVITY 0. HEALTH 1, FLAMMABILITY 1, PHYSICAL HAZARD 0 (NFPA is a registered trademark of the National Fire Protection Association) (HMIS is a registered trademark of the National Paint and Coatings Association) Estimated NFPA Rating: Estimated HMIS Classification: Prepared By: Company: Telephone No.: Denise Boyd, Manager-Environmental, Health & Safety ITW Permatex 10 Columbus Blvd.