Operation and maintenance manual

130 SEBU8601-01
Index Section
Index
A
After Starti
ng Engine ............................................. 60
After Stopping Engine............................................ 66
Aftercooler Core - Clean/Test (Air-To-Air
Aftercoole
r) .......................................................... 89
Aftercooler Core - Inspect...................................... 89
Alternator - Inspect ................................................ 90
Alternator
and Fan Belts - Replace ....................... 90
ARD Spark Plug - Clean/Inspect/Replace ............. 89
B
Battery - R
eplace................................................... 90
Battery Electrolyte Level - Check .......................... 91
Battery or Battery Cable - Disconnect ................... 91
Before St
arting Engine .................................... 15, 58
Belt - Inspect.......................................................... 92
Belt Tensioner - Inspect ......................................... 92
Burn Pre
vention..................................................... 10
Batteries.............................................................. 11
Coolant................................................................ 11
Inducti
on System ................................................ 11
Oils...................................................................... 11
C
Califo
rnia Emissio n Control Warranty
Statement .......................................................... 126
Emissions Warranty ......................................... 126
Cold W
eather Operation........................................ 68
Hints for Cold Weather Operation...................... 68
Idling the Engine ................................................ 69
Recom
mendations for Coolant W arm Up .......... 69
Recommendations for the Coolant .................... 68
Viscosity of the Engine Lubrication Oil............... 68
Cold
Weather Starting ........................................... 58
Configuration Parameters...................................... 53
Customer Specified Parameters ........................ 54
Syst
em Config uration Parameters ..................... 53
Cooling System Coolant (Commercial Heavy-Duty) -
Change ................................................................ 93
Dra
in .................................................................. 93
Fill ...................................................................... 94
Flush .................................................................. 94
Coo
ling System Coolant (ELC) - Change.............. 95
Drain .................................................................. 95
Fill ...................................................................... 96
Fl
ush .................................................................. 96
Cooling System Coolant Level - Check ................. 97
Engines With a Coolant Recovery Tank............. 97
En
gines Without a Coolant Recovery Tank........ 97
Cooling System Supplemental Coolant Additive
(SCA) - Test/Add.................................................. 98
A
dd the SCA, If Necessary ................................ 98
Test for SCA Concentration ............................... 98
Cooling System Water Temperature Regulator -
Replace................................................................ 99
Crankshaft V
ibration Damper - Inspect ................. 99
Viscous Damper................................................. 99
Crushing Prevention and Cutting Prevention ........ 13
D
Diagnostic Flash Code Retrieval ........................... 46
Diagnostic Lamp.................................................... 46
Diesel Par
ticulate Filter - Clean........................... 100
Diesel Particulate Filter Regeneration................... 61
Lamps ................................................................ 62
Modes of Re
generation...................................... 62
Regeneration ..................................................... 61
Regeneration Switch.......................................... 63
Soot Leve
l Monitoring and Indicator Lamps....... 63
Driven Equipment - Check................................... 100
E
Electri
cal System ................................................... 16
Grounding Practices .......................................... 16
Emergency Stopping ............................................. 66
Emissi
ons Certification Film .................................. 29
Label for compliant engines ............................... 29
Emissions Warranty Information.......................... 127
Mainte
nance Recommendations ..................... 128
Engine - Clean..................................................... 101
Aftertreatment .................................................. 101
Engin
e Air Cleaner Element (Dual Element) -
Clean/Replace ................................................... 101
Cleaning the Primary Air Cleaner Elements .... 102
Servi
cing the Air Cleaner Elements ................. 101
Engine Air Cleaner Element (Single Element) -
Inspect/Replace ................................................. 103
Engi
ne Air Cleaner Service Indicator - Inspect.... 104
Test the Service Indicator................................. 104
Engine Air Precleaner - Check/Clean.................. 104
Engi
ne Crankcase Breather Element - Replace.. 105
Bottom Service................................................. 106
Check the System............................................ 107
To
p
Se
rvice ...................................................... 105
Engine Description ................................................ 25
Aftermarket Products and Perkins Engines ....... 26
Ele
ctronic Engine Features.................. .............. 25
Engine Cooling and Lubrication ......................... 26
Engine Diagnostics ............................................ 26
En
gine Service Life ............................................ 26
Engine Specifications......................................... 25
Engine Diagnostics................................................ 46
En
gine Electronics................................................. 17
Engine Mounts - Inspect...................................... 107