® DF5 Series DF5S Series Fixed-Mount Domes Maintenance/ Service Manual C1458SM-A (10/98) Pelco • 300 W. Pontiac Way, Clovis • CA 93612-5699 USA • Pelco Online @ http://www.pelco.
CONTENTS Section Page 1.0 GENERAL ............................................................................................ 3 1.1 IMPORTANT SAFEGUARDS AND WARNINGS ....................... 3 2.0 DESCRIPTION .................................................................................... 4 2.1 MODELS .................................................................................... 4 3.0 MAINTENANCE ................................................................................... 5 4.
1.0 GENERAL 1.1 IMPORTANT SAFEGUARDS AND WARNINGS Prior to installation and use of this product, the following WARNINGS should be observed. 1. Installation and servicing should only be done by qualified service personnel and conform to all local codes. 2. Unless the unit is specifically marked as a NEMA Type 3, 3R, 3S, 4, 4X, 6, or 6P enclosure, it is designed for indoor use only and it must not be installed where exposed to rain and moisture. 3. Only use replacement parts recommended by Pelco. 4.
2.0 DESCRIPTION DF5 Series domes are discreet surveillance domes that are designed for indoor or outdoor use. Models include pendant and in-ceiling versions. The DF5S Series domes are similar to the DF5 Series. The basic difference is that the back box for the DF5 Series is 5.25 inches (13.34 cm) in height while the DF5S Series back box is 2.75 inches (7 cm) in height. The DF5S Series domes are designed for indoor use where there is very little space above the ceiling. 2.
3.0 MAINTENANCE Clean the acrylic dome as necessary to maintain a clear picture. Be careful not the scratch the surfaces of the dome. Exterior Surface - Clean the dome’s exterior surface with a nonabrasive cleaning cloth and cleaning agent that is safe for acrylic plastic. Either liquid or spray cleaner/ wax suitable for fine furniture is acceptable. Interior Surface (Except Chrome or Gold) - Clean the same as the exterior surface.
4.0 EXPLODED ASSEMBLY DIAGRAMS 6 16 3 15 12 9 1 14 11 4 18 8 5 13 17 2 10 7 Figure 1. Exploded Assembly Diagram–DF5 In-Ceiling Models Table A.
Figure 2.
Table B.
5 12 9 3 10 6 11 13 1 4 8 2 14 7 Figure 3. Exploded Assembly Diagram–DF5-0F and DF5-1F Flat Disk Models Table C.
Figure 4.
5 6 19 9 1 11 18 10 13 14 17 7 3 12 15 16 8 2 4 Figure 5.
Table D.
3 1 6 15 11 19 8 22 20 9 27 13 18 24 23 32 29 21 28 10 31 25 26 30 7 33 12 17 14 5 2 4 16 Figure 6.
Table F.
1 7 3 2 8 10 5 9 6 4 Figure 7. Exploded Assembly Diagram–Heater Segment in Pendant Back Box Table G.
3 2 1 Figure 8. Exploded Assembly Diagram–Heater Segment in Pendant Lower Dome Table H. Exploded Assembly Parts List–Heater Segment in Pendant Lower Dome Item Quantity 1 2 1 1 3 1 Description Part Number Heater bracket Thermostat On at 40° F (4° C) Off at 60° F (16° C) Heater pad, 30 W, 24 VAC 7064041COMP EH5510049A HT01-0621-20.5 4 Figure 9. Exploded Assembly Diagram–Sun Shield Table I.
Figure 10. Exploded Assembly Diagram–DF5S Table J.
5.0 WARRANTY AND RETURN INFORMATION WARRANTY Pelco will repair or replace, without charge, any merchandise proved defective in material or workmanship for a period of one year after the date of shipment. Exceptions to this warranty are as noted below: • • • • • • Three years on Genex™ Series (multiplexers, keyboard and server). Two years on all standard motorized and fixed focal length lenses.
