User guide

ManualsBrandsPavement Ends ManualsCar51132 Replay

51132 pg 1

1206 Rev. C

Replay Top with Tinted

Side and Rear Windows

and Upper Door Skins

Installation Instructions

For: Jeep Wrangler (YJ)

1988 – 1995

Part Number: 51132

Table of Contents

REPLAY TOP PARTS LIST .................................... PAGE 2

EPLAY TOP TOOLS NEEDED .............................. PAGE 2

EPLAY TOP INSTALLATION .................................. PAGE 2

EPLAY TOP WARRANTY .................................... PAGE 9

Summary of content (6 pages)

PAGE 1
Replay Top with Tinted Side and Rear Windows and Upper Door Skins Installation Instructions For: Jeep Wrangler (YJ) 1988 – 1995 Part Number: 51132 Table of Contents REPLAY TOP PARTS LIST.................................... PAGE 2 REPLAY TOP TOOLS NEEDED .............................. PAGE 2 REPLAY TOP INSTALLATION.................................. PAGE 2 REPLAY TOP WARRANTY .................................... PAGE 9 51132 pg 1 1206 Rev.
PAGE 2
Parts List Fabric Top Side Curtain, Right Side Curtain, Left Rear Curtain Door Cover, Right Door Cover, Left Qty - 1 Qty - 1 Qty - 1 Qty - 1 Qty - 1 Qty - 1 Before beginning this installation, remove the old top and make sure all hardware is in place and that the Drip Rails are locked into the Windshield Frame. Step One PLACE TOP ON VEHICLE Locate the top and orient it on the vehicle. Snap it to the bows.
PAGE 3
Step Four Rear Corner Retainer INSTALL REAR CORNER Fabric Insert rear corners of top into rear corner retainer. Plastic Strip Plastic Reinforcement not caught under retainer Rear Corner Retainer Edge of Plastic Strip must line up with edge of retainer Plastic Strip under retainer Plastic Strip under retainer Rear Step Five SECURE REAR BOW Pull the bottom of the rear support bow back until it snaps into the notch in the side rail. Zippers must not be caught or folded behind rear support bow.
PAGE 4
Step Eight Step Seven Cross Section View Looking Down START ZIPPERS SECURE FRONT OF SIDE CURTAIN Start the zippers 2-3 inches on the top and rear of the side curtain. Pop the plastic strip on the front of the side curtain into the retainer channel on the front support bow.
PAGE 5
Step Eleven SNAP TOP Fasten snaps on top, above doors, to studs on vehicle. Studs will slide to match location of snaps on top. Snaps Front Step Twelve REMOVE OLD DOOR COVERS Unfasten the plastic retainer at the bottom of the fabric door and remove it from the vehicle. Use a razor knife to cut the stitches on the old door covers and remove them from the door frames. Windshield Tuck edge of fabric into drip rail.
PAGE 6
Care and Maintenance of your New Top Your top is made of the finest materials available. To keep it looking new and for the maximum possible wear, it will need periodic cleaning and maintenance. Washing: The fabric should be washed often using soap, warm water and a soft bristle brush. Rinse with clear water to remove all traces of soap. Zippers: Keeping the zipper cleaned and lubricated with a silicone lubricant will help prevent damage and keep the zippers in a smooth working condition.