User's Manual

6.3.1 Before you connect any wires, separate the tail section from the engine group and place it out of
the way.
6.3.2 Connect the two ring terminals labeled STARTER B+ with Red wires to the large battery terminal
on the starter solenoid.
6.3.3 Locate the three large ring terminals with Black and Blk/Wht wires and ground them to the engine.
6.3.4 Using Figure 6.11-6.25, and the specific connections indicated in Table 6.2A or 6.2B, connect the
wiring as directed.
NOTE: The air pump, air bleed solenoid, canister purge solenoid and canister vent
solenoid connectors are rolled up in the dash section and must be routed out to the engine
compartment if these items are to be used.
6.3.5 Engine Section Connections
WIRE COLOR # OF POSITIONS LABELED CONNECT TO:
IN CONNECTOR
11
TABLE 6.2A 60506-7 Engine Section Connections
Black, Brown, Lt.Blue, Gray (2)
Blue, Lt.Blue
Tan/White, Purple/White, Black, Pink
Tan, Purple, Black, Pink
Orange/Black, Lt.Green, Gray
Brown/White, Red, Pink/Black
Yellow, Yellow/Black, Lt.Green
Pink, Black
Pink, Lt.Green/Black
Pink, Pink/Black
Pink, Lt.Blue/Black
Pink, Black/White
Pink, Yellow/Black
Pink, Red/Black
Pink, Blue/White
Blue, Black, Gray
Yellow, Black/White, Pink
Brown, Yellow, Green
Purple, Tan
Lt.Green/Black, Lt.Blue/Black,
Lt.Blue/White, Lt.Green/White
Purple, Red, Green, Lt.Blue, Brown,
Black, Pink
Red/White, Purple/White, Lt.Blue/White,
Green/White, Brown/White, Black, Pink
Black (4), Black/White (2)
Red (2)
5
2
4
4
3
3
3
2
2
2
2
2
2
2
2
3
3
3
2
4
7
7
EGR
Knock
Drvr Side Oxy
Pass Side Oxy
MAP
CMP
CKP
Inj #1
Inj #2
Inj #3
Inj #4
Inj #5
Inj #6
Inj #7
Inj #8
TPS
MAF
ECT
IAT
IAC
Drvr Coils
Pass Coils
Ground
Starter B+
EGR Valve
Knock Sensor Connector
Driver Side Oxygen Sensor
Passenger Side Oxygen Sensor
MAP Sensor
Cam Position Sensor
Crankshaft Position Sensor
Driver Side Front Injector
Passenger Side Front Injector
Driver Side 2
nd
Injector
Passenger Side 2
nd
Injector
Driver Side 3
rd
Injector
Passenger Side 3
rd
Injector
Driver Side Rear Injector
Passenger Side Rear Injector
Throttle Position Sensor
Mass Airflow Sensor
Engine Coolant Temp Sensor
Intake Air Temp Sensor
Idle Air Control Motor
Driver Side Coil Connector
Passenger Side Coil Connector
Engine Ground
Starter Solenoid Batt. Terminal