Operating Instructions & Parts Manual Hydraulic Truck Jack Model 23221C 23222C (Low Profile) 23301 Models 23221C & 23222C Capacity 22 Ton 22 Ton 30 Ton Model 23301 U.S. Patent No's. 5,341,723 & 5,946,912 ! This is the safety alert symbol. It is used to alert you to potential personal injury hazards. Obey all safety messages that follow this symbol to avoid possible injury or death. SFA Companies http://www.omegalift.
SAFETY AND GENERAL INFORMATION Save these instructions. For your safety, read, understand, and follow the information provided with and on this device before using. The owner and/or operator shall have an understanding of the device, its operating characteristics and safety operating instructions before operating the equipment. The owner and/or operator shall be aware that use and repair of this product may require special skills and knowledge.
. Activate air motor to vent air. 4. Remove set screw (reference Figure 2, #40) and use a screw driver to hold down check ball while very slowly pumping air motor until oil exiting from screw hole is steady without bubbles. 5. Reinstall set screw approximately two turns into hole (do not fully tighten). 6. Activate air motor a few additional times to vent air, while slowly tightening set screw. Ram should start to raise as screw is fully tightened. 7.
! WARNING ! WARNING X • Study, understand, and follow all instructions before operating this device. • Do not exceed rated capacity. To avoid crushing and related injuries: • Never work on, under or around a load supported only by hydraulic jack. • Always use adequately rated matched jack stands. • Chock each unlifted tire in both directions. • Do not use this device to lift, level, lower, support nor move a house, mobile home, travel trailer, camper or any building structure.
MAINTENANCE NOTICE: Use only good quality hydraulic jack oil. Avoid mixing different types of fluid and NEVER use brake fluid, turbine oil, transmission fluid, motor oil or glycerin. Improper fluid can cause premature failure of the jack and the potential for sudden and immediate loss of load. Premium hydraulic jack oil is recommended. Adding/ Changing Oil For best performance and longest life, replace the complete fluid supply at least once per year. 1.
Replacement Parts for models 23221C & 23222C: Item Description Part No. Qty Item Description Part No.
Replacement Parts for model 23301: Item Description Part No. Qty Item Description Part No.
ONE YEAR LIMITED WARRANTY For a period of one (1) year from date of purchase, SFA COMPANIES, INC. will repair or replace, at its option, without charge, any of its products which fails due to a defect in material or workmanship under normal usage. This limited warranty is a consumer's exclusive remedy. Performance of any obligation under this warranty may be obtained by returning the warranted product, freight prepaid, to SFA COMPANIES, INC. Warranty Service Department, 10939 N. Pomona Ave.
