NCPIZOVN Portable Outdoor Pizza Oven Gas Fired, Fire & Stone Outdoor Pizza Oven
DANGER Never operate this appliance unattended. If a fire should occur, keep away from the appliance and immediately call your fire department. Do not attempt to extinguish an oil or a grease fire with water. If you smell gas: • Shut off gas to the appliance. • Extinguish any open flame. • If odor continues, keep away from the appliance and immediately call your gas supplier or your fire department.
WARNINGS Do not store gas cylinder in a building, garage or any other enclosed area and keep out of reach of children at all times. This appliance is not intended to be installed in or on recreational vehicles and/or boats. Check all gas supply fittings for leaks before each use. Do not use the appliance until all connections have been checked and do not leak. Do not smoke while leak testing. Never leak test with an open flame.
WARNINGS This appliance is not intended to be installed in or on a boat. This appliance is not intended to be installed in or on a recreational vehicle. Keep the fuel supply hose away from any heated surface(s). The appliance should not be located or used under overhead unprotected combustible construction materials or surfaces. For a pizza oven, the minimum clearance shall be at least 3m from any structure or combustible material. The appliance is not intended for commercial use.
SAFETY PRACTICES TO AVOID INJURY When properly cared for, your oven will provide safe, reliable service for many years. However, extreme care must be used as the oven produces intense heat that can increase the risk of accidents. When using this oven basic practices must be followed, including but not limited to following: • Do not repair or replace any part of the oven unless specifically recommended in this manual. All other service should be referred to a qualified technician.
PARTS LIST 1. Pizza Oven 2. Pizza baking stone 1 2 ASSEMBLY Before assembly, make sure all parts are present. If any part is missing or damaged, do not attempt to assemble the appliance. Contact customer service for replacement parts. 1. Unfold legs 2. Insert the pizza baking stone 6 www.NutrichefKitchen.
3. Connecting gas hose to Pizza Oven Please note the factory setting that the hose has been assembled to the Pizza Oven. 4. Connecting to gas tank WARNING • Please always keep the gas bottle in upright position. • The size for 20 lbs LP gas cylinder is 12.2 inches in diameter and 17.9 inches tall • If the appliance is not in use, the gas must be turned off at the supply cylinder. • The cylinder used must include a collar to protect the cylinder valve.
9. Turn the oven burner valve OFF and make sure the oven is cool. 10. Turn the liquid propane cylinder valve OFF by turning clockwise until it stops. 11. Detach the regulator assembly from the cylinder valve by turning the quick coupling nut counterclockwise. 12. Place dust cap for cylinder valve outlet whenever the cylinder is not in use. 13. The LP gas supply cylinder to be used must be constructed and marked in accordance with the specifications for LP gas cylinder, U.S.
OPERATING INSTRUCTIONS USING THE OVEN The burner is rated at 14,500BTU/Hr. To begin: 1. Make sure the oven has been leak tested and properly placed. 2. Remove any remaining packing material. 3. Light the burner using the LIGHTING INSTRUCTIONS below: LIGHTING AND ADJUST THE FIRE INSTRUCTION 1. Before use please make sure the control knob is in “OFF”position. Then push the control knob and slowly turn the knob anticlockwise to “HI” position for 5 seconds until you hear a click and the burner ignites (A). 2.
3. Insert a match into the matchstick holder, ignite the match and insert through the oven opening to the burner. 4. Push and turn the control knob to HI slowly, the burner should ignite immediately. 5. If the burner does not light within seconds, turn the control knob OFF and wait for 5 minutes and try again. CARE AND MAINTENANCE Store Pizza oven out of direct sunlight and indoors where possible and when storing for extended periods of time.
TROUBLESHOOTING PROBLEM Burner doesn't light Low flame or gas how dropped suddenly Flames blow out Flare-up Flaseback SOLUTION 1. Check if your propane tank is empty. 2. Turn the coupling nut about one half to three quarters additional turn until solid stop. Tighten by hand only, please do not use tools. 3. CIean the burner tube 4. Re-engage burner and valve 5. Check steps in assembly instructions. 1. Check your propane tank 2. Turn off gas control know, wait for 1 min and light oven.
Features: • Unique Design • Foldable Feet • Easy to Transport and Set-Up • Comes Complete with a Gas Burner • Gas-Fueled for Maximum Convenience • One-touch Gas Ignition to Turn on the Heat • Built-in Gas Ignition • Adjustable Heat Control Dial for Effortless Cooking • High-Grade Stainless Steel • Insulated Body • Rolling Flame and Dense Stone • Cooks Stone-baked Fresh 12” Pizza in 1 minute What's in the Box: • Pizza Oven • Pizza Stone • (1) Set Of Regulator with 39.
www.NutrichefKitchen.
Questions? Issues? We are here to help! Phone: (1) 718-535-1800 Email: support@pyleusa.
