Full Product Manual
15
14
HTTP://WWWNUMAXTOOLSCOM 1-888-669-5672
..
HTTP://WWWNUMAXTOOLSCOM 1-888-669-5672
..
MODEL: S50LSDH MODEL: S50LSDH
Tighten screws.
Install overhaul kit.
Lack of power.
Slow to cycle.
Tool is too dry.
Air pressure too low.
Exhaust blocked.
Add about 2-3 drops of
lubrication into the air
connector.
Make sure the air compressor
is set between 70 psi and
115 psi.
Clean exhaust channel.
Drive channel is worn.
Piston is broken or worn.
Bent fasteners.
Dirty magazine.
Loose magazine.
Wrong fasteners.
Fasteners are
jammed in the tool
frequently.
Fix the drive channel.
Replace the piston.
Remove the bent fasteners
Clean magazine.
Tighten screws.
Verify that fasteners are the
correct size.
Damaged pusher spring.
Wrong size of fasteners.
Replace spring.
Use 16 gauge L cleat nails
15.5 gauge staples.
or
1.
2.
3.
1.
2.
1.
2.
3.
4.
5.
6.
1.
2.
1.
2.
3.
1.
2.
1.
2.
3.
4.
5.
6.
Not shooting
fasteners.
Loose screw.
Worn or damaged o-rings or
seals.
1.
2.
Air leaking in head
cap.
TROUBLESHOOTING
Stop using tool immediately if any of the following problems occur. Serious personal injury
could result. Any repairs or replacements must be done by a qualified service person or an
authorized service center.
WARNING:
!
PROBLEMS POSSIBLE CAUSE(S) CORRECTIVE ACTION
Only use Numax Authorized Repair Parts. For questions please call 1-888-669-5672 or visit
our website at http://www.numaxtools.com
WARNING:
!
NUMAX PNEUMATIC NAIL GUNS WARRANTIES
The air compressor must be able to
maintain a minimum of 70 psi when the
tool is being used. An inadequate air
supply can cause a loss of power and
inconsistent driving.
CAUTION:
Do not connect with an air compressor
which can potentially exceed 200 psi. As
tool may burst, possibly causing injury.
WARNING:
!
NUMAX Pneumatic Nail Guns Warranties
1 Year Professional Tool Warranty
30 Day Wearable Parts Warranty
The Tool limited warranty extends exclusively to the original purchaser of theProduct, begins
on the date of purchase and excludes wearable parts. During the warranty period Prime Global Products,
Inc. (PGP) expressly warrants that the Product is free from defect in materials and workmanship
subject to the exceptions and limitations contained herein. PGP shall at its option, repair, replace, or offer a
full refund for a Product that has a defect in materials or workmanship.
The wearable parts limited warranty extends exclusively to the original purchaser of the
Product and begins on the date of purchase, and includes driver blades, bumpers, O-rings, pistons, piston
rings, and gaskets. During the warranty period PGP expressly warrants that the Product is free from
defect in materials and workmanship subject to the exceptions and limitations contained herein. PGP shall at
its option, repair, replace, or offer a full refund for a Product that has a defect in materials or
workmanship.
NumaxNumax
Numax
Numax
NumaxNumax
Numax
Numax
http://numaxtools.com
Numax
A DATED SALES RECEIPT OR PROOF OF PURCHASE FROM THE ORIGINAL RETAIL PURCHASER
IS REQUIRED TO MAKE A WARRANTY CLAIM. Warranty registration is also required and can be
accomplished through On-Line Product Registration at, select SUPPORT, select
PRODUCT REGISTRATION. To make a warranty claim, the original purchaser must return the Nail
Gun, postage prepaid and insured, with proof of purchase to PGP or any of its authorized service centers.
For questions please call 1-888-669-5672. Other than the postage and insurance requirement, no charge
will be made for repairs covered by this warranty.
These Warranties do not apply where:
Warranty Exclusions
Repairs or alterations have been made, or attempted, by others, and/or the unauthorized use of non-
conforming parts or accessories.
Repairs are required due to normal wear and tear.
The Nail Gun has been abused, misused, improperly maintained or operated, including: the failure to
use clean, dry, regulated compressed air at the recommended pressure; accidents caused by use of the
Product after partial failure.
The Product is used commercially in assembly lines or production lines. The Product is
intended for use by individuals and these warranties do not extend to such commercial uses.
Numax
NumaxNumax
NO WARRANTY, ORAL OR WRITTEN, EXPRESSED OR IMPLIED, OTHER THAN THE ABOVE
WARRANTIES IS MADE WITH REGARD TO THIS PRODUCT. ANY IMPLIED WARRANTIES
WILL BE LIMITED IN DURATION TO THE APPLICABLE WARRANTY PERIOD SPECIFIED ABOVE.
SOME STATES DO NOT ALLOW LIMITATIONS ON HOW LONG AN IMPLIED WARRANTY LASTS,
SO THE ABOVE MAY NOT APPLY TO YOU. YOUR REMEDIES ARE SOLELY AND EXCLUSIVELY AS
STATED ABOVE. PGP SHALL IN NO EVENT BE LIABLE FOR INCIDENTAL, CONSEQUENTIAL,
INDIRECT, OR SPECIAL DAMAGES. SOME STATES DO NOT ALLOW THE EXCLUSION OR
LIMITATION OF INCIDENTAL OR CONSEQUENTIAL DAMAGES, SO THE ABOVE LIMITATION OR
NUMAX
EXCLUSION MAY NOT APPLY TO YOU. IN NO EVENT, WHETHER AS A RESULT OF A BREACH OF
CONTRACT, WARRANTY, TORT (INCLUDING NEGLIGENCE) OR OTHERWISE, SHALL PGP’S
LIABILITY EXCEED THE PRICE OF THE PRODUCT WHICH HAS GIVEN RISE TO THE CLAIM OR
LIABILITY. ANY LIABILITY CONNECTED WITH THE WARRANTY PERIOD SPECIFIED ABOVE. NO
EMPLOYEE OR REPRESENTATION OF PGP, OR ANY DISTRIBUTOR OR DEALER IS AUTHORIZED
TO MAKE ANY CHANGE OR MODIFICATION OF THIS WARRANTY.
These warranties give you specific legal rights. you may also have other rights which vary from
state to state.
THIS WARRANTIES ARE SUBJECT TO CHANGE WITHOUT NOTICE.