N82 RM-313/RM-314 Service Manual Level 1&2 SERVICE MANUAL Level 1&2 RM-313 RM-314 Transceiver characteristics: Band: GSM: Quad-band 850/900/1800/1900MHz RM-313: WCDMA: 2100MHz Display: LCD: 6.096cm QVGA (2.4”) (240x320 pixel); 16.7M colors Camera: Camera: 5.0 Megapixel SMIA95, 6x digital zoom, Xenon Flash Operating System: Series 60 Connections: Wireless: Bluetooth, WLAN Connector: Micro USB Connector; AV Connector 3.
N82 RM-313/RM-314 Service Manual Level 1&2 TABLE OF CONTENTS Page 1. CHANGE HISTORY 2. COPYRIGHT 3. WARNINGS AND CAUTIONS 4. ESD PROTECTION 5. CARE AND MAINTENANCE 6. BATTERY INFORMATION 7. PRODUCT CONTORLS & OVERVIEW 8. EXPLODED VIEW 9. LEVEL 2 SOLDER COMPONENTS 10. SERVICE DEVICES 11. SW-UPDATE 12. DISASSEMBLY 13. ASSEMBLY HINTS Page 2 (22) CONFIDENTIAL Copyright © 2007 NOKIA. All rights reserved.
N82 RM-313/RM-314 Service Manual Level 1&2 1. CHANGE HISTORY Status Version No. Date Comments Draft 0.1 06.Nov.2007 Initial draft Approved 1.0 14.Nov.2007 Approval The purpose of this document is to help NOKIA service levels 1 and 2 workshop technicians to carry out service to NOKIA products. This Service Manual is to be used only by authorized NOKIA service suppliers, and the content of it is confidential. Please note that NOKIA provides also other guidance documents (e.g.
N82 RM-313/RM-314 Service Manual Level 1&2 3. WARNINGS AND CAUTIONS Warnings and Cautions Please refer to the phone’s user guide for instructions relating to operation, care and maintenance including important safety information. Note also the following: Warnings: 1. 2. 3. CARE MUST BE TAKEN ON INSTALLATION IN VEHICLES FITTED WITH ELECTRONIC ENGINE MANAGEMENT SYSTEMS AND ANTI–SKID BRAKING SYSTEMS. UNDER CERTAIN FAULT CONDITIONS, EMITTED RF ENERGY CAN AFFECT THEIR OPERATION.
N82 RM-313/RM-314 Service Manual Level 1&2 5. CARE AND MAINTENANCE This product is of superior design and craftsmanship and should be treated with care. The suggestions below will help you to fulfil any warranty obligations and to enjoy this product for many years. • Keep the phone and all its parts and accessories out of the reach of small children. • Keep the phone dry. Precipitation, humidity and all types of liquids or moisture can contain minerals that will corrode electronic circuits.
N82 RM-313/RM-314 Service Manual Level 1&2 7. PRODUCT CONTORLS & OVERVIEW N82 RM-313/ RM-314 Product Controls & Interfaces Nokia AV Connector (3.
N82 RM-313/RM-314 Service Manual Level 1&2 8. EXPLODED VIEW See corresponding ITEM/CIRCUIT REF in the Spare Parts Service Bulletins on NOL. N82 RM-313/ RM-314 EXPLODED VIEW KEYMAT COVER I0003 WINDOW ASSY I0001 LCD AM 240x320 16MCO BRIXTON I0002 A1=UI ASSY WT (I0004-I0005) MICROPHONE (A1) I0005 UI MODULE (A1) I0004 6xSCREW M1.
N82 RM-313/RM-314 Service Manual Level 1&2 9. LEVEL 2 SOLDER COMPONENTS N82 RM-313/ RM-314 Components overview Solder components only for LEVEL 2 X1420 X4402 X1400 X4401 F2000 G2200 S4416 J6213 J6212 S4401 S4403 V1154 V1153 S4402 S4400 V1156 V1155 Ver. 2.0 Page 8 (22) CONFIDENTIAL Copyright © 2007 NOKIA. All rights reserved.
N82 RM-313/RM-314 Service Manual Level 1&2 10. SERVICE DEVICES FLS-5 incl. ACF-8, Driver and User ACF-8 Travel Charger AC-4 Guide Universal Power Supply is used to Small and lightweight charger for Dongle and flash device incorporated power FLS-5. fast charging of your phone battery. into one package, developed specifically for POS use. CA-101 Service Cable to connect the PC with the Micro USB connector.
N82 RM-313/RM-314 Service Manual Level 1&2 11. SW-UPDATE Flash Concept – (Point of Sales) To use FLS-5 Flash Dongle you have to follow the user guide inside the sales package. Please check always for the latest version of flash software, which is available on NOKIA Online. Page 10 (22) CONFIDENTIAL Copyright © 2007 NOKIA. All rights reserved.
N82 RM-313/RM-314 Service Manual Level 1&2 12. DISASSEMBLY 1. Nokia N82 Disassembly. 2. You will need the Nokia Standard Toolkit version 2. Also refer to the General Mechanical Guideline Video. 3. Unlock and remove the C-COVER ASSY. Remove the battery if inserted. 4. Use the SS-93 to open the snaps of the WINDOW ASSY. 5. Move the opening tool to the shown place and open the next 6. Now, open the snaps on the top of the WINDOW ASSY. snap. 7. Continue on the other side. Page 11 (22) 8.
N82 RM-313/RM-314 Service Manual Level 1&2 9. Unlock all clips of the KEYMAT COVER. 10. Remove the KEYMAT COVER and discard it. 11. Unlock the bottom snaps of the UI Module. 12. Unlock both side snaps. Avoid damaging of the B-COVER. 13. Use the SS-93 as a lever and lift the UI MODULE from the MAIN FRAME ASSY. 14. Turn the UI MODULE to the shown side.. 15. ...and very carefully open the UI MODULE connector. 16. Remove the MICROPHONE and discard the UI MODULE.
N82 RM-313/RM-314 Service Manual Level 1&2 17. Carefully place the SS-93 between the LCD and the MAIN FRAME ASSY in the marked place. 18. Very carefully lift the LCD from the MAIN FRAME. 19. Gently open the LCD connector. 20. Undo the Torx PLUS size 6 screws in the order shown... 21. ... and remove them. 22. Unlock the MAIN FRAME ASSY starting at the shown side. 23. Open the next snap. 24. Open the snap on the other side. Page 13 (22) CONFIDENTIAL Copyright © 2007 NOKIA. All rights reserved.
N82 RM-313/RM-314 Service Manual Level 1&2 25. Remove the MAIN FRAME ASSY from the B-COVER. 26. Remove the EARPIECE. 27. Carefully open the FLASH MODULE CONNECTOR. 28. Gently lift the ENGINE MODULE from the B-COVER and remove it. 29. Carefully open the CAMERA connector. 30. Separate the CAMERA MODULE from the PWB. 31. Remove the DC-JACK with the DC-Plug. 32. Unlock the ANTENNA CELLULAR ASSY. Page 14 (22) CONFIDENTIAL Copyright © 2007 NOKIA. All rights reserved.
N82 RM-313/RM-314 Service Manual Level 1&2 33. Unlock the ANTENNA on the other side... 34. ...and remove it from the B-COVER. 35. Use a 3.5mm headset plug to unlock the AUDIO CONNECTOR. 36. AUDIO CONNECTOR drops out by turning the B-COVER. 37. Carefully remove the CAMERA GROUNDING SPRINGS. 38. Unlock the FLASH HOLDER... 39. ...and remove it. 40. Unlock and remove the ANTENNA GPS ASSY. Page 15 (22) CONFIDENTIAL Copyright © 2007 NOKIA. All rights reserved.
N82 RM-313/RM-314 Service Manual Level 1&2 41. Carefully remove the CAPACITOR with the SS-93. 42. Remove the FLASH from B-COVER. 43. Carefully remove the FLASH MODULE... 44. ...paying attention to the flex foil. 45. Remove the remaining adhesive. 46. Gently unlock the D-COVER ASSY with the SS-93. 47. Continue at the other side. 48. Move the D-COVER a bit to the left and remove it. Page 16 (22) CONFIDENTIAL Copyright © 2007 NOKIA. All rights reserved.
N82 RM-313/RM-314 Service Manual Level 1&2 13. ASSEMBLY HINTS 1. Nokia N82 assembly hints. 2. You will need the Nokia Standard Toolkit version 2. Also refer to the General Mechanical Guideline video. 3. Place the D-COVER ASSY onto the B-COVER as shown... 4. ...and secure it by pressing the parts together. 5. Ensure that the keys are in the correct position. 6. Check the other side. 7. Ensure that the SD BUNG is fitted correctly. 8.
N82 RM-313/RM-314 Service Manual Level 1&2 9. Check the condition of the adhesives. Replace if necessary. 10. Also check that no adhesive remains in the B-COVER. 11. Fit the FLASH MODULE by carefully pressing it into B-COVER. Ensure that the flex foil is not bend or squeezed. 12. Check the correct position of the flex connector. 13. Place the FLASH HOLDER onto the FLASH... 14. ...and secure it by pressing into place. 15. Place the AUDIO CONNECTOR into the B-COVER... 16. ...and secure it.
N82 RM-313/RM-314 Service Manual Level 1&2 17. Place the ANTENNA CELLULAR ASSY into the B-COVER. 18. Press on the ANTENNA to secure it into place. Do not touch the spring contacts. 19. Press the other side of the ANTENNA into place. 20. Carefully fit the CAMERA GROUNDING SPRINGS. 21. Check their correct positions. 22. Fit the DC- JACK before fitting the PWB. 23. Check the mechanical condition of the spring contacts on the ENGINE MODULE. 24. Carefully place the ENGINE MODULE onto the B-COVER.
N82 RM-313/RM-314 Service Manual Level 1&2 25. Take care to the FLASH connector when securing the PWB in 26. Press the ENGINE MODULE into place. Take special care to the to the B-COVER. electric components. 27. Close the FLASH connector. 28. Fit the CAMERA MODULE. 29. Gently close the CAMERA connector. 30. Place the marked side of the EARPIECE onto the MAIN FRAME but under the metal gasket. 31. Fit the MAIN FRAME ASSY into the B-COVER. 32. Tighten the screws with a torque of 30Ncm in the order shown.
N82 RM-313/RM-314 Service Manual Level 1&2 33. Close the LCD connector. 34. Place the LCD onto the MAIN FRAME paying attention to the LCD flex. 35. Close the UI MODULE connector. 36. Fit the UI ASSY into the B-COVER. 37. Place the KEYMAT COVER onto the UI MODULE... 38. ...and press it into place. Check that no gaps remain. 39. Check the mechanical condition of the WINDOW ASSY. 40. Check the other side. Page 21 (22) CONFIDENTIAL Copyright © 2007 NOKIA. All rights reserved.
N82 RM-313/RM-314 Service Manual Level 1&2 41. Pay attention to marked snaps of the WINDOW. They have to be placed exactly onto the shown hooks. 42. The hook on other side on the MAIN FRAME. 43. Fit the WINDOW ASSY starting at the shown side. 44. Press the parts together. 45. Close the snaps on the other side and the top side. Check that no gaps remain. Page 22 (22) CONFIDENTIAL Copyright © 2007 NOKIA. All rights reserved.
