Customer Care Solutions Schematics / Layouts Schematics (NH4_051) DCT-4 Common Baseband UEM, Bottom connector, SIM UPP, Flash, Bluetooth, Irda, Camera FLASH, SDRAM UI,- Display- connector, Vibra, Light driver BB-RF Connections overview RF GSM Signal Overview Component finder DCT-4 Common Baseband ACC_IF UEMRST RFAUX(1:0) SLOWAD(6:0) JTAG(6:0) UIDRV(5:0) CBUS(2:0) CHARGER(2:0) NHL-10 Page Table of Contents 1 2 3 4 5 6 7 8 9 DSP_MCUTEST(2:0) GENIO(28:0) MBUS FBUS(1:0) PUSL(2:0) IRIF(1:0) I_IR
Customer Care Solutions Schematics / Layouts NHL-10 UEM, Bottom connector, SIM Bottom Connector VBAT X381 1.
Customer Care Solutions Schematics / Layouts NHL-10 UPP, Flash, Bluetooth, Irda, Camera UPP, Flash, Bluethooth, Irda, Camera SCCE Training Group © 2003 NMP Only for training and service purposes NHL-10 (6600) 15.09.2003 (PWB) NH_051.v05a UPP D100 UPP_WD2_V2.
Customer Care Solutions Schematics / Layouts NHL-10 FLASH, SDRAM MEMADDA(16) MEMADDA(17) MEMADDA(18) MEMADDA(19) MEMADDA(20) MEMADDA(21) MEMCONT(6) MEMCONT(5) MEMCONT(9) J310 MEMCONT(3) MEMCONT(1) MEMCONT(0) J315 MEMCONT(8) MEMCONT(4) D315 AM29N643HT70MVAI D314 AM29N643HT70MVAI D316 AM29N643HT70MVAI FLASHM 4Mx16 FLASHM 4Mx16 FLASHM 4Mx16 B2 A9 B8 A8 B3 A2 A10 16 A4 B4 B9 B6 C10 A6 B7 A1 B5 CLK _AVD _CE _RESET _OE _WE _WP RDY NC MEMADDA(16) MEMADDA(17) MEMADDA(18) MEMADDA(19) MEMADDA(20) MEMA
Customer Care Solutions Schematics / Layouts NHL-10 UI, Dispaly connector, Vibra, Light driver, ESD UI Connector VKEYB ESD X140 Z140 EMIF10-1K010F1 COL5 ROCKER2 ROCKER4 UPP 1 ROCKER1 11 ROCKER5 IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 IN10 2 10 13 GENIO(28:0) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 COL5 COL3 COL1 ROW5 ROW3 COL0 ROCKER1 ROCKER3 ROCKER5 OUT1 OUT2 OUT3 OUT4 OUT5 OUT6 OUT7 OUT8 OUT9 OUT10 ROCKER3 GND GND VIO 30 34 ESD V140 EMIF02-MIC02F1 RSTX 4 8 12 13 IN1 OUT1
Customer Care Solutions Schematics / Layouts NHL-10 BB-RF Connections Overview RF schematic RXIINP RXIINN RXQINP RXQINN 0 1 2 3 BB schematic RFCONV_O(9:0) VREF1 9 RFICCNTRL_O(2:0) RFBUSEN1 RFBUSCLK RFBUSDA RESET 2 0 1 6 PUSL_O(2:0) RFAUXCONV_O(2:0) GENIO_O(28:0) TXC TXP TXIOUTP TXIOUTN TXQOUTP TXQOUTN RFAUX_O(1:0) 0 5 RFCLKGND_I RFCLK_I 4 5 6 7 RFCLK_I ISSUE 2 01/2004 Copyright © Nokia 2003. All rights reserved.
Customer Care Solutions Schematics / Layouts NHL-10 RF GSM CONFIDENTIAL nokia Customer Care Europa, Middle East & Africa SCCE Training Group © 2003 NMP Only for training and service purposes 7(9) RF GSM NHL-10 (6600) 15.09.2003 Band GSM 900 GSM 1800 GSM 1900 Version 1.0 Approved (PWB) NH_051.
Customer Care Solutions Schematics / Layouts NHL-10 Signal Overview Customer Care Europa, Middle East & Africa SCCE Training Group © 2003 NMP Only for training and service purposes 1) SLEEPCLK 32.768kHz 900mVpp at C197 2) RFCLK 26MHz 1Vpp at J170 Signal Overview NHL-10 (6600) 18.07.2003 Version 1.0 Approved (PWB) NH_051.v05a VR3=2.8V 10) DET at Power level 19 19 Vibra Control 11) VPCTRL GSM 900 Power level 5 at R818 2 3) TXP at J610 4) TXC 900 P. level 5 / 1800/1900 P.
Customer Care Solutions Schematics / Layouts NHL-10 Component finder 3 4 5 6 7 8 9 10 11 12 13 14 TOP C D C D GND GND Antenna connector E E F F G G IHF speaker H H I Camera connector I Battery connector J + VBat BSI J GND IRDA K K L L M M Bluetooth SIM card connector N N Vibra O O P P Q Q MMC reader R R S S T T U U V V W W Bottom connector X X 3 4 ISSUE 2 01/2004 5 6 7 8 9 10 11 12 13 14 A A600 A800 B B190 B601 C C100 C101
Customer Care Solutions Schematics / Layouts NHL-10 Schematics (NH4_055) RF-BB Connections A800 DMC04206 PA SHIELD ASSY GND RF schematic RXIINP RXIINN RXQINP RXQINN 0 1 2 3 A600 BB DMC04207 RF SHIELD ASSY schematic RFCONV_O(9:0) VREF1 9 RFICCNTRL_O(2:0) RFBUSEN1 RFBUSCLK RFBUSDA RESET 2 0 1 6 PUSL_O(2:0) GND RFAUXCONV_O(2:0) GENIO_O(28:0) TXC TXP TXIOUTP TXIOUTN TXQOUTP TXQOUTN RFAUX_O(1:0) 0 5 4 5 6 7 RFCLKGND_I RFCLK_I RFCLK_I GND X150 LCD_GND_PAD NF ISSUE 2 01/2004 Copyright © No
Customer Care Solutions Schematics / Layouts VBATTRF NHL-10 VBAT MJOELNER INT_32R INT_25R INT_33R VBATTRF_ INT_29R VR1A VR2 VR3 VR4 VR5 VR6 VR7 VIO INT_26R VBATTRF INT_27R POWER_AMP RXIINP RXIINN RXQINP RXQINN VREF1 schematic VBD VBD DET DET VPD_900 VPD_1800 TX_900 TX_1800 VTXB_900 schematic RFBUSEN1 RFBUSCLK RFBUSDA RESET Components: 800 - 899 ISSUE 2 01/2004 VREF1 RFBUSEN1 RFBUSCLK RFBUSDA RESET VPD_900 VPD_1800 TX_900 TX_1800 TXC TXP TXIOUTP TXIOUTN TXQOUTP TXQOUTN VTX
Customer Care Solutions Schematics / Layouts NHL-10 Power Amp VBD DET C803 27p L805 VBATTRF_ C810 R801 4k7 4p7 V801 HSMS-282C-TR1 42R/100MHz C815 C814 27p C813 10n 33u_16V R802 1k0 C834 27p C805 27p C804 47p TX_1800 R819 L801 LDC15D190A0010A B2_OUT B2_IN COUP TERM 1 R803 2 47R TX_DCS_PCS C826 8p2 GND 3 C823 1p0 4 L808 5n6H 5 6 C855 1p0 L812 NF 292R 17R6 N801 PF08125B-02-TB B1_IN 292R TX_GSM B1_OUT Pin_DCS 12 Ident N/C Vapc_DCS Pout_DCS Vapc_GSM Vdd2 Pin_GSM Vdd1
Customer Care Solutions Schematics / Layouts NHL-10 Mjoelner RXIINP RXIINN RXQINP RXQINN X600 R715 R715 L608 X603 X601 C604 1p0 2n7H X602 C701 15p ? /2 5k6 ? /2 5k6 TXQOUTP C716 IN OUT C641 27p TXIOUTP TXIOUTN R716 R716 L609 C640 15p ? /2 5k6 ? /2 5k6 C715 68p 2n7H TXQOUTN 68p TXP Z603 1960MHz R717 R717 L603 ? /2 2k2 TXP ? /2 2k2 Tx1-GSM Tx2 DCS/PCS TX_DCS_PCS Z601 ANTENNA SWITCH LM-T118S1E2 Z602 1842.
Customer Care Solutions Schematics / Layouts NHL-10 Testpoints Testpoints for proto testing J602 RFBUSEN1 J603 RFBUSCLK J604 RFBUSDA RESET J606 RXIINP J607 RXIINN J608 RXQINP J609 RXQINN J610 TXP J611 TXC J612 VR1A J613 VR2 J614 VR3 J616 VR5 J617 VR6 J618 VR7 ISSUE 2 01/2004 Copyright © Nokia 2003. All rights reserved.
Customer Care Solutions Schematics / Layouts NHL-10 BB ACC_IF UEMRST RFAUX(1:0) SLOWAD(6:0) JTAG(6:0) UIDRV(5:0) CBUS(2:0) CHARGER(2:0) DSP_MCUTEST(2:0) GENIO(28:0) MBUS FBUS(1:0) PUSL(2:0) IRIF(1:0) I_IRIF(2:0) DBUS(2:0) LPRFCLK gpio30A gpio34A HS_AUDIO(4:0) ANCTRL(4:0) GPIO(37:0) Components : 370 - 469 CPU POWER Galaxy I_SIMIF(3:0) I_SIMIF(3:0) DSP_MCUTEST(2:0) UEMRST DSP_MCUTEST(2:0) I_MMCIF(4:0) FBUS(1:0) CBUS(2:0) CBUS(2:0) MBUS UEM_INT UEM_INT JTAG(6:0) CHARGER(2:0) DB
Customer Care Solutions Schematics / Layouts NHL-10 Accessory Interface IR Galaxy I_IRIF(2:0) IRIF(1:0) I_IRIF(2:0) IRIF(1:0) Components : 370 - 379 SYS_CONN Galaxy CHARGER(2:0) UIDRV(5:0) HS_AUDIO(4:0) CHARGER(2:0) HS_AUDIO(4:0) SLOWAD(6:0) SLOWAD(6:0) ANCTRL(4:0) ANCTRL(4:0) UIDRV(5:0) GPIO(37:0) GPIO(37:0) RFAUX(1:0) RFAUX(1:0) GENIO(28:0) CBUS(2:0) DSP_MCUTEST(2:0) PUSL(2:0) Components : 380 - 429 LPRF Galaxy PUSL(2:0) GENIO(28:0) CBUS(2:0) LPRFCLK DBUS(2:0) PUSL(2:0) GENIO(28
Customer Care Solutions Schematics / Layouts NHL-10 IR Module VBAT R370 R371 10R 10R R372 R373 10R 10R C370 100n GND V370 TFDU5102-TR3 IRIF(1:0) VFLASH1 J371 IRED_A IRED_C TXD RXD SD/Mode VCC NC GND R376 180R VFLASH1 TX RX 0 1 R374 10k GND C372 470n C373 22p VIO V371 BSS123 ISSUE 2 01/2004 I_IRIF(2:0) SHUTDOWN GND Copyright © Nokia 2003. All rights reserved.
Customer Care Solutions Schematics / Layouts NHL-10 System Connector UIDRV(5:0) VBAT Current sense monitor Z304 CURRENT_SEN J381 1 J385 4 NF 2 3 R383 2k2 X381 CSS5011-1151L NF N380 LM3819BLX CBUS(2:0) 0 2 1 PUSL(2:0) 2 A1 D1 C3 A3 D3 B3 A2 4 5 6 7 3 J386 SENSE+SENSEVio Zint CBusClk CBusEnX CBusDa DetClk Vdd Gnd B1 C1 X381 CSS5011-1151L NF 2 1 GND D2 L380 F380 42R/100MHz VCHARIN 0 1 2 C384 1u0 NF GND GND CHARGER(2:0) HS_AUDIO(4:0) 1.
Customer Care Solutions Schematics / Layouts NHL-10 LPRF BT102 Antenna termination Z430 L= W=0.25 GND VFLASH1 L430 33R/100MHz C432 1u0 VBAT N430 LMBTB016 GND L431 600R/100MHz 6 46 53 52 54 DBUS(2:0) C431 1u0 1 2 3 4 5 7 8 9 10 11 13 14 15 17 19 24 29 33 39 43 47 51 GND VIO GND 32 45 C430 1u0 ANT VREG VCCXTAL OSCON VCC RESETX VCC VCC SLEEPX VBBEN GND GND EN26MHZ GND SLPCLK GND SYSCLK REFCLK GND GND XTALGND GND NC GND GND GPP0 GND GPP1 GND GND N.C.
Customer Care Solutions Schematics / Layouts NHL-10 Test Interface All of them should be placed on WING. I_IRIF(2:0) BTTEST(4:0) SLOWAD(6:0) FBUS(1:0) MBUS UIDRV(5:0) Delete for no wing board GENIO(28:0) BT_JTAG(7:0) See also sys conn and card if sheets JTAG(6:0) GPIO(37:0) SLOWAD(6:0) GPIO(37:0) gpio30A gpio34A DSP_MCUTEST(2:0) Name Calimero Test Interface Appr 1 Copyright (C) Nokia Corporation. All rights reserved. ISSUE 2 01/2004 Copyright © Nokia 2003. All rights reserved.
Customer Care Solutions Schematics / Layouts NHL-10 Power AUX_POWER Galaxy GENIO(28:0) GPIO(37:0) GENIO(28:0) GPIO(37:0) CBUS(2:0) CBUS(2:0) PUSL(2:0) PUSL(2:0) ANCTRL(4:0) I_AUDIO(1:0) ANCTRL(4:0) EAR_AUDIO(1:0) EAR_AUDIO(1:0) UEMRST Components : 260 - 299 UEMRST UEM Galaxy I_AUDIO(1:0) I_AUDIO(1:0) UEMRST PUSL(2:0) I_IRIF(2:0) I_IRIF(2:0) CBUS(2:0) IRIF(1:0) MIC_AUDIO(2:0) IRIF(1:0) MIC_AUDIO(2:0) EAR_AUDIO(1:0) PWRONX PWRONX RFAUXCONV(2:0) SLOWAD(6:0) RFAUXCONV(2:0) SLOWAD(6
Customer Care Solutions Schematics / Layouts NHL-10 Aux_Power GPIO(37:0) EAR_AUDIO(1:0) ANCTRL(4:0) VBAT VBATT_SMPS PUSL(2:0) Z260 CBUS(2:0) L= W=0.90 VCOREA VREFRF01 VBATT_SMPS I_AUDIO(1:0) N261 LM2608ATLX-1.
Customer Care Solutions Schematics / Layouts NHL-10 UEM VBAT 0 2 1 R191 VBAT 0R22 GND CHARGER(2:0) D190 UEMK_V4.4_WDOGS_ENABLED VBAT VBAT C241 1u0 GND GND C202 1u0 C243 1u0 GND B190 32.
Customer Care Solutions Schematics / Layouts NHL-10 Card Interface VSIM R496 EMIF03-SIM01 J478 J479 J480 0 1 2 3 VSIM Data R1 R2 R3 CLK CLK Ultra’s Sim Connector X470 SF2W006S4M GND R489 R490 0R 0R Clock Reset GND 6 5 4 1 2 3 VSim SIMIF(3:0) C476 22p NF C477 22p NF C488 22p NF GND C471 100n GND GND GND GND PLACE CAPS C475 476 C477 C488 CLOSE TO X470 I_SIMIF(3:0) GENIO(28:0) VMMC R472 EMIF04-MMC02F1 VMMC I_MMCIF(4:0) J487 J488 3 4 GENIO(28:0) VMMC N470 LP3928TLX-1828 VIO
Customer Care Solutions Schematics / Layouts NHL-10 Audio R330 0 1 2 R366 470R MICB1 MIC1P MIC1N Place R333 and R334 near B339 1k0 C330 X381 CSS5011-1151L R364 2k2 C331 2k2 33n C369 1n0 C368 1n0 MIC_AUDIO(2:0) 8 9 R365 33n C332 22p R332 NF 1k0 R333 R334 C333 10U GND GND GND GND GND GND R336 27k C336 33n 0 1 C337 33n 560p C334 N330 LM4890IBLX R337 C335 68p 22k R338 NF BYPASS _SHUTDOWN 22k IN+ IN- C367 22p NF C366 22p GND 22k R339 I_AUDIO(1:0) Vo1 Vo2 C2= VBATHF A2,
ISSUE 2 01/2004 Copyright © Nokia 2003. All rights reserved.
Customer Care Solutions Schematics / Layouts NHL-10 User Interface 16 VKEYB X140 Z140 EMIF10-1K010F1 gpio30A COL5 ROCKER1 ROCKER2 ROCKER3 ROCKER4 ROCKER5 1 2 10 13 11 IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 IN10 GPIO34A GENIO(28:0) 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 COL5 COL3 COL1 ROW5 ROW3 COL0 ROCKER1 ROCKER3 ROCKER5 OUT1 OUT2 OUT3 OUT4 OUT5 OUT6 OUT7 OUT8 OUT9 GNDOUT10 GND 6 SLOWAD(6:0) GND VIO RSTX 4 14 15 17 18 10 11 16 9 IN1 IN2 IN3 IN4 IN5 IN6 IN7 IN8 IN9 IN10 ROW2 RO
Customer Care Solutions Schematics / Layouts NHL-10 VBAT R169 NF Power switch 47k R132 PWRONX 1 3 2 4 READ COMPONENT INFO! 2k2 1825133 S130 R133 14V/50V GND GND VIO VIO Two resistors must be near UPP_WD2. R135 3 2 1 0 3k9 3k9 R134 CIF(3:0) VIO VFLASH1 SDA D+ SCL DExtclk Two resistors must be near UPP_WD2. GENIO(28:0) Four lines(from 100 ohm to UPP_WD2) must be same length. Four lines(from 100 ohm to camera connector) must be same length. These lines must be GND_shielded.
Customer Care Solutions Schematics / Layouts NHL-10 Memories D314 M58NR064ET-80ZG6T_REV.FF42H D315 M58NR064ET-80ZG6T_REV.
Customer Care Solutions Schematics / Layouts NHL-10 GSM BB-RF Interface RFCONV/RFCONV_O: 0: RXIINP 1: RXIINN 2: RXQINP 3: RXQINN 4: TXIOUTP 5: TXIOUTN 6: TXQOUTP 7: TXQOUTN 8: VREFRF02 9: VREFRF01 0 1 2 3 4 5 6 7 8 9 0 1 2 3 4 5 6 7 8 9 RFCONV(9:0) RFCONV_O(9:0) GENIO/GENIO_O 13 5 6 7 8 9 10 11 12 13 5 6 7 8 9 10 11 12 5: TXP 6: RESET 7: TXA 8: TXL1 9: TXL2 10: EXTANT 11: BANDSEL 12: ADATA 13: RXGAIN GENIO(28:0) GENIO_O(28:0) RFAUXCONV/RFAUXCONV_O 0 1 2 0: TXC 1: TXPWRDET 2: AFC 0 1 2 RFAUXC
Customer Care Solutions Schematics / Layouts NHL-10 Layout diagram Bottom ISSUE 2 01/2004 Copyright © Nokia 2003. All rights reserved.
Customer Care Solutions Schematics / Layouts NHL-10 Layout diagram Top ISSUE 2 01/2004 Copyright © Nokia 2003. All rights reserved.
Customer Care Solutions Schematics / Layouts NHL-10 Board layout diagram Bottom ISSUE 2 01/2004 Copyright © Nokia 2003. All rights reserved.
Customer Care Solutions Schematics / Layouts NHL-10 Board layout diagram Top ISSUE 2 01/2004 Copyright © Nokia 2003. All rights reserved.
