User Guide

PAMS Technical Documentation Tuning, Flashing and Final Testing Instruc-

TME-3

Issue 3 10/03 Nokia Corporation. Page 3

Table of Contents

Page No

RF Tuning Instructions .................................................................................................. 5

General .........................................................................................................................5

Flashing concept setup .................................................................................................6

JBV-1 Service Concept ...............................................................................................7

TX tuning, step1: TXIQ tuning ...................................................................................8

Typical values: .......................................................................................................... 9

TX tuning, step2: TXpower level tuning ...................................................................10

RX calibration, step1: Channel select filter ...............................................................12

RX calibration, step2 .................................................................................................13

RX calibration,step3: RX AM suppression ...............................................................14

RX calibration, step4: Band filter ..............................................................................15

Final test instructions for TME-3................................................................................. 16

Needed main equipment: ...........................................................................................16

RF Final test ...............................................................................................................16

Preparation for RF Final test:.................................................................................. 17

Carry out RF Final test............................................................................................ 17

M2M Connector Final test .........................................................................................18

Testing Procedure (TME-3 in Normal Mode without test SIM card):.................... 18

List Of Figures

Page No

Fig 1 Flashing concept.........................................................................................................6

Fig 2 JBV-1 Service Concept ..............................................................................................7

Fig 3 TxIQ tuning window .................................................................................................8

Fig 4 TxIQ tuning ...............................................................................................................9

Fig 5 TX power level tuning window, TxPA high mode ....................................................10

Fig 6 TX power level tuning window, TxPA low mode ....................................................10

Fig 7 Rx channel select filter calibration window ..............................................................12

Fig 8 RX calibration window ..............................................................................................13

Fig 9 RX AM Suppression window ....................................................................................14

Fig 10 Rx Band filter response compensation ....................................................................15

Fig 11 Test set-up ...............................................................................................................16

Fig 12 M2M connector test using SB-1 service box ...........................................................18