English 2
English Contents Components Symbols used to mark instructions.............................................4 Attachments Included Attachments.................................................................5 Accessories Included Accessories..................................................................6 Guidance Congratulations...........................................................................7 Getting the best results...............................................................
English Components 1. Cold Water Tank 2. Detergent Tank 3. Steam Control 4. Collection Tank 5. Filter Panel 6. Vacuum Hose Socket 7. Steam Hose Socket 8. Castor With Brake Diagram A 9. Wire Basket 10. Serial Number Diagram B 11. On/Off Switch 12. Mode Switch 13. Heater On LED 14. Steam Ready LED 15. Cold Water Refill LED 16.
English Attachments These Parts were carefully packed at Nilfisk. Please check all accessories on receipt. If any parts are missing or damaged please contact the company in which you purchased this machine, within 7 days of purchase quoting your serial number on the back of the machine. 1. 2.5 Metre Steam, Detergent & Vacuum Hose 3. Floor Nozzle 300mm 5. Carpet Insert for Floor Nozzle 7. Clear Upholstery Tool 9. Nylon Details Brush x 5 11. Short Steam Lance 13. Suction Nozzle 150mm 15.
English Accessories These Parts were carefully packed at Nilfisk. You will find these items in your box with all the attachments. Please check all accessories on receipt. If any parts are missing or damaged please contact the company in which you purchased this machine, within 7 days of purchase quoting your serial number on the back of the machine.
English Guidance Congratulations ………………………………………………... We would like to take this opportunity to thank you for your purchase of the Nilfisk combined steam, detergent and vacuum cleaner. The SDV4500 is manufactured in the EU to the highest quality Standards This instruction manual contains all of the necessary information to operate and maintain this machine. Please read this instruction manual carefully before you start using or carrying out any maintenance on the machine.
English Installation • Lift the machine out of the box. • Carefully place the machine on its side in order to assemble the wheels securely. !! A flat surface is required which will not scratch or damage the surfaces of the machine. • Diagram D – Back wheel assembly. Using a 10 mm spanner remove the bolts from the machine and place the assembly into place towards the back of the machine. Tighten the bolts securely ensuring no movement on the brackets. Diagram D – Casters with Brake x 2.
English Operating Procedure ………………………………………………... 1. Switch mode switch (Number 12 Diagram B) to position 11. • This will switch on the boiler elements and will enable you to use the handle controls on the hose once connected. 2. Fill the cold water tank (Number 1 Diagram A) with clean cold water only. !! Anything other than clean cold water used in the water tank will void the manufacturers warranty. 3. Fill the detergent tank (Number 2 Diagram A) with Nilfisk approved detergent.
English Operating Procedure cont…. ………………………………………………... 11. The handle controls are now active. • The red trigger on the hose handle will release steam when pressed. • The red button on the side of the handle will lock the steam trigger in the off position. • Pressing the left hand switch on top of the handle will activate the vacuum. • Pressing the right hand momentary switch located on the top of the handle will activate the detergent pump. Hold the switch as long as you need to dispense the detergent.
English Maintenance Warning: Disconnect the machine from the mains before cleaning or carrying out any maintenance work. Daily Maintenance ………………………………………………... To be carried out every day or every 8 hours of operation. 1. Grease “O” rings on the steam pin in the steam hose. 2. Wash the hose by sucking one or two litres of water from a basin into the collection tank. 3. Empty the collection tank, rinse and wipe down. 4. Remove the foam filter, wash in water and re fit.
English Service & Guarantee If you require a service or advice on using or maintaining your machine please contact your Nilfisk approved distributor. Service Guarantee ………………………………………………...
English Technical Technical Information ………………………………………………... Boiler Wattage: Type: Capacity: Continuous Fill Steam Pressure Steam at source: 1950W Stainless Steel 1.8 Litres Yes 4.5 Bar 135°C > Vacuum Type Motor Integral 850 Watt Electrical Voltage Low Voltage Controls Cord length 230V ~ single phase 5V 10m Capacities Boiler Cold Water Tank Collection Tank Detergent Tank Weight 1.8 Litres 2.5 Litres (easy fill) 12 Litres 2.
English Trouble Shooting Symptom No power Possible cause Not connected / Faulty socket On / Off switch not on No steam Fuse blown Unknown Steam Control turned down fully clockwise Steamer not ready Clean water tank is low (beeping sound& "refill" light is lit) No steam, Just water Unknown Steamer not ready Boiler at pressure and not heating(temperature less than 110ºC) Steam Leaking from front socket Unknown “O” Rings split “O” rings worn Vacuum power low Vacuum operation has been selected on the
