Product Manual

3
Safety Instructions
Save these instructions - This manual contains important safety and operating instructions for the NexPump. Follow these
important safety precautions. Failure to follow safety precautions can result in personal injury or damage to the NexPump.
CAUTION - To reduce the risk of injury, charge only lead type rechargeable batteries. Other types of batteries may burst causing
personal injury and damage.
Do not expose the NexPump system unit to rain or snow.
Do not install the NexPump system unit where temperatures will be below freezing (32 degrees Fahrenheit).
Do not charge a battery that may be frozen. Allow the battery to sit at room temperature before connecting to the NexPump.
If an extension cord must be used, make sure
A. That the pins on the plug or extension cord are the same number, size and shape as those of the plug on the NexPump
system unit.
B. That the extension cord is properly wired and in good electrical condition.
C. That the wire size is large enough for the AC ampere rating of the NexPump system unit.
Do not operate the NexPump system unit if it has received a sharp blow, been dropped, or otherwise damaged in anyway- take it
to a qualified serviceman.
Do not operate the NexPump system unit with a damaged cord or plug - have them replaced or repaired immediately.
Do not disassemble the NexPump system unit- take it to a qualified serviceman when service or repair is required. Dis-assembly
may result in a risk of electric shock or fire and void the warranty.
Never pull directly on any wiring connected to pumps, battery, AC power or sensors. Disconnect by pulling on connectors only.
Never force the connectors out of place, they should disconnect and connect easily. Some connectors have safety latches, so make
sure they are depressed.
Never attempt any maintenance and/or cleaning with the NexPump powered up. Risk of electric shock may result.
WARNING - RISK OF EXPLOSIVE GASES WORKING IN THE VICINITY OF A LEAD-ACID BATTERY CAN BE
DANGEROUS. BATTERIES GENERATE EXPLOSIVE GASES DURING NORMAL BATTERY OPERATION.
FOR THIS REASON, IT IS OF THE UTMOST IMPORTANCE THAT EACH TIME BEFORE USING YOUR NEXPUMP
CONTROL UNIT YOU READ THIS MANUAL AND FOLLOW THE INSTRUCTIONS EXACTLY.
A SPARK NEAR THE BATTERY MAY CAUSE AN EXPLOSION.
Be sure the area around the battery is well ventilated.
Personal Precautions
If LEAD-ACID battery is used
Someone should be within range of your voice and/or close enough to come to your aid when you work near a lead-acid battery.
Have plenty of fresh water and soap nearby in case battery acid contacts skin, clothing or eyes.
Wear complete eye protection and clothing protection. Avoid touching your eyes while working near the battery.
If the battery acid contacts skin and/or clothing, wash immediately with soap and water. If acid enters the eye, immediately flood
eye with running cold water for at least ten minutes and get medical attention immediately.
When the battery fluid level is low, add distilled water in each cell until the level reaches the indicator on each cell. Do not
overfill.
Precautions for all Batteries