STAINLESS STEEL GAS GRILL USE AND CARE GUIDE MODEL NO.:720-0125-LP ® FOR OUTDOOR USE ONLY PLEASE CONTACT 1-800-913-8999 FOR ASSISTANCE DO NOT RETURN TO PLACE OF PURCHASE.
IMPORTANCE * * * WARNING * * * FOR YOUR SAFETY If you smell gas: 1. Shut off gas to the appliance. 2. Extinguish any open flame. 3. Open lid 4. If odor continues, immediately call you gas supplier or your fire department. FOR YOUR SAFETY 1. Do not store or use gasoline or other flammable vapors and liquids in the vicinity of this or any other appliance. 2. An LP cylinder not connected for use shall not be stored in the vicinity of this or any other appliance.
TABLETABLE OF CONTENTS SECTION ONE: Precaution…………………………1-2 Placement of the grill ……………...3 SECTION THREE: Lighting instruction ……………………………..16 Using the side burner …………………………..17 Care & maintenance ……………………………18 Lighting illustrations………………….…………..19 To match light the grill ……………..……………20 Care & maintenance of side burner …….…….21 Troubleshooting …………………………………21 SECTION TWO: Assembly instruction………………4-11 Gas hook-Up ………………………. 12 Leak testing ….……………………. 12 Installer final ….…………………… .
PRECAUTIONS WARNING Do not try lighting this appliance without reading the “LIGHTING INSTRUCTIONS” section of this manual. Do not repair or replace any part of the grill unless specifically recommended in this manual. All other service should be referred to a qualified technician. TESTED IN ACCORDANCE WITH ANSI Z21.58a1995 STANDARD FOR OUTDOOR COOKING GAS APPLIANCES. THIS GRILL IS FOR OUTDOOR USE ONLY. CHILDREN SHOULD NOT BE LEFT ALONE OR UNATTENDED IN AN AREA WHERE THE GRILL IS BEING USED.
PRECAUTIONS When using the grill, do not touch the grill rack, burner grate or immediate surroundings as these areas become extremely hot and could cause burns. Use only dry potholders. Moist or damp potholders on hot surfaces may cause burns from steam. Do not use a towel or bulky cloth in place or potholders. Do not let potholders touch hot portions of the grill rack. could, in the presence of heat, ignite or cause metal parts to corrode.
ASSEMBLY INSTRUCTIONS PLEASE READ THE INSTRUCTIONS CAREFULLY AND FOLLOW STEP BY STEP. Attention: Please lock the caster during the process of installation of the grill. TOOLS REQUIRED: Philips head screwdriver(not provide),monkey wrench(not provide) The TM Glass o Step1：. Assemble two regular casters to the right side panels and caster with brakes on the left side panel as shown figure below..
Step 2: : Assemble bottom panel to side panels,back panel and transom panel with eight( 14) 1/4’ *15 mm screws as shown figure below Step 3: Assemble the head part to the bobywork part. Remove the head unit of grill from carton. Insert the upper portion of the grill onto the cart from the top with four (4)1/4*13mm screws. Caution!! The firebox is heavy, and we recommend two or more people to lift up firebox.
Step 4: First assemble handle of side shelf,then assemble sprice tray and control panel of side burner as the figure show below: Step5: Remove the head unit of screws with four (8)1/4’*13mm screws.
Step 6 : Assemble the fortified steel to the main with (8)1/4’*13. The GlaT M sso . Step7: Assemble side shelf and side burner with four(8) 1/4*13mm screws as figure show below .
ASSEMBLY INSTRUCTIONS Side burner valve assembly: Step 1: Insert valve assembly through side panel Step 2: Remove 4(four) screws & washers from the “U” brackets on the side burner Valve (#22) (Side panel, right #29) Step 3: Insert valve stem assembly into burner venturi Valve Stem Step 4: Insert valve stem assembly through knob hole to the control panel (Control Panel #22) Valve Step 5: Replace “U” brackets with 4(four) Screws( DO NOT TIGHTEN) Step 6: Align & tighten knob bezel & valve stem with
Step 8: Assemble the door to the grill as the figure show below: The GlaT M sso Step9: Assemble the motor bracket to the fire box with four (4) 1/4*10mm screws.
How to install a gas tank Opening the front door and place gas tank into the gas tank holes. Secure the gas tank by turning the retention screw at the right of the grill clockwise until it is tight. .
Your gas grill is ready to use 11
GAS HOOK-UP Only the pressure regulator and hose assembly supplied with the grill should be used. Any replacement pressure regulator and hose assembly must be specified by the grill manufacturer. L.P. GAS HOOK-UP: Ensure that the black plastic grommets on the LP cylinder valve are in place and that the hose does not come into contact with the grease tray or the grill head. This is a liquid propane configured grill.
local gas supply may make it necessary to adjust the burners. The flames of the burners should be visually checked. BEFORE TESTING Make sure that all packing material is removed from the grill including the burner tie-down straps. Flames should be blue and stable with no yellow tips, excessive noise or lifting. If any of these conditions exist, check to see if the air shutter or burner ports are blocked by dirt, debris, spider webs, etc.
PROPANE TANK ASSEMBLE Attach propane gas tank to regulator inlet fitting by turning the regulator clockwise as shown in figure below.
OPERATING INSTRUCTION General use of the grill Each main burner is rated at 12,000 Btu/hr. The main grill burners encompass the entire cooking area and are side ported to minimize blockage from falling grease and debris. Above the burners are stainless steel radiant (flame covers). The igniter knobs are located on the lower center portion of the valve panel. Each rotary igniter is labeled on the control panel. USING THE GRILL: Grilling requires high heat for searing and proper browning.
LIGHTING INSTRUCTIONS variations in the local gas supply may take minor adjustments necessary. WARNING: IMPORTANT! BEFORE LIGHTING… Inspect the gas supply hose prior to turning the gas “ON”. If there is evidence of cuts, wear, or abrasion, it must be replaced prior to use. Do not use the grill if the odor of gas is present. Only the pressure regulator and hose assembly supplied with the unit should be used. Never substitute regulators for those supplied with the grill.
USING THE SIDE BURNER control knob counterclockwise to the “HI” position. If the burner does not light, turn the control knob to “OFF”. If the smell of gas is detected and the igniter is not functioning, immediately turn the control knob “OFF”. Allow 5 minutes for any accumulated gas to dissipate. If the side burner igniter is not functioning, see the following section for match lighting. WARNING: IMPORTANT! USING THE SIDE BURNER: Inspect the gas supply hose prior to turning the gas “ON”.
LIGHTING ILLUSTRATIONS Step1. Make sure the lid is open Step 2. Push and turn one of main or side burner knobs to HI position Step 3. You may need 3 or 4 trials to light the burner.
Approximate 1 1/2 “ Flame Height 19
TO MATCH LIGHT THE GRILL If the burner will not light after several attempts then the burner can be match lit. If you’ve just attempted to light the burner with the igniter, allow 5 minutes for any accumulated gas to dissipate. Keep your face and hands as far away from the grill as possible. Insert a lit light rod or lighter through the cooking grids to the burner. Press the control knob and rotate left to the HI setting, continue to press the knob until the burner ignites. Burner should light immediately.
CARE & MAINTENANCE OF SIDE BURNER BURNER CLEANING: Clean the exterior of the burner with a wire brush. Clear any clogged burner ports with a straightened paper clip. Never enlarge the burner ports. Never use a wooden toothpick as it may break off the clog the port. STAINLESS STEEL: There are many different stainless steel cleaners available. Always use the mildest cleaning procedure first, scrubbing in the direction of the grain. Do not use steel wool as it will scratch the surface.
EXPLODED VIEW 01 02 03 04 11 05 06 07 12 08 14 09 23 39 21 22 24 25 38 26 27 28 29 30 31 32 36 35 33 22 17 18 20 37 15 16 10 34 13 19
PARTS LIST REF# 01 02 03 04 05 06 07 08 09 10 11 12 13 14 15 16 17 18 19 20 DESCRIPTION Lid, Front Heat Indicator Handle Assembly, Lid Warming Rack Cooking Grid With Hole Flame Tamer Main Burner Grease Tray Bowl assembly Motor Bracket Rotisserie Bracket Regulator, LP Front Baffle Gas Valve, Main Burner Gas Valve Manifold Manifold Retainer Bracket Control Panel Control Knob Seat Control Knob Cooking Grid, Side Burner Q’TY 1 1 1 1 2 3 3 1 1 1 1 1 1 3 1 4 1 4 4 1 23 REF# 21 22 23 24 25 26 27 28 29 30 31 3
ORDERING PARTS HOW TO ORDER REPLACEMENT PARTS IMPORTANT Use only factory authorized parts. The use of any part that is not factory authorized can be dangerous. This will also void your warranty. To make sure you obtain the correct replacement part(s) for your gas grill, please refer to the parts list on this page. The following information is required to assure getting the correct part.
GRILL COOKING CHART 25
GRILL COOKING CHART 26
GRILL COOKING CHART 27
GRILL COOKING CHART BBQ SALMON TANGY SEAFOOD KABOBS 2 large salmon steaks 1 lb. Large shrimp, shelled & deveined ¾ lbs. sea scallops 2/3 c. chili sauce ¼ c. cider vinegar 2 tbs. Oil Salt & pepper 2 oz. thin bacon slices 2 tbs. Butter 1 tbs. Lemon juice Spring of parsley Lemon wedges Preheat the BBQ. Brush the steaks with oil and season with salt and pepper. Place on BBQ grill and cook for 10 minutes, turning steaks over halfway cooking time. Meanwhile fry the bacon in a pan on the side burner.
GRILL COOKING CHART Preheat grill. Combine cheese, condensed soup, milk, BBQ sauce, oregano, salt and pepper in a large mixing bowl. Stir in potatoes until well coated. Turn into well buttered1-1/2 quart rectangular baking dish. Cover dish with aluminum foil. Bake covered 25 minutes on medium with the lid of your BBQ grill closed. Remove foil and continue baking 15 minutes longer or until potatoes are tender. Let stand 5 minutes before serving.
GRILL COOKING CHART CHICKEN TANDOORI STYLE 8 large chicken thighs or drumsticks 1 c. plain nonfat yogurt ½ c. lemon juice 2 tsp. salt ½ tsp. cayenne ½ tsp. black pepper ½ tsp. crushed garlic ½ tsp. grated ginger 1 tbs. corn oil Combine all the ingredients in a large mixing bowl and marinate the chicken for 8 hours in the refrigerator. Drain the chicken and spread on the spit running the rod on the fleshier side of the bone. Rotis using the rotis burner.
LIMITED WARRANTY MODEL NO.: 720-0125-LP STAINLESS STEEL OUTDOOR GAS GRILL Nexgrill Industries, Inc. warrants to the original consumer purchaser of each Outdoor Gas Grill that when subject to normal residential use, it is free from defects in workmanship and materials for the periods specified below. This warranty excludes grills used in rental or commercial applications. There will be a shipping and handling charge for the delivery of the warranty part(s).
