User Manual

ManualsBrandsNewco ManualsAppliances108460-B - Coffee Brewer, Plumbed, 120V, 8-1/2"W x 16-1/2"D x 20-1/8"H

Man PN 102863

Rev 20080623

INSTALLATION, OPERATION, AND SERVICE MANUAL FOR

THE ACE SERIES - AUTOMATIC COFFEE EQUIPMENT

120 V Watts 120 V Amps 240 V

Model Warmers Width Depth Height Weight US Canada US Canada Watts Amps

ACE-S 3 8-1/2 16-1/2 17-7/16 29 1710 1410 14.3 11.8 3810 17.2

ACE-LP 3 15-1/2 16-1/2 15-7/8 31 1710 1410 14.3 11.8 3810 17.2

ACE-AP 0 8-1/2 17-11/16 22-1/4 29 1760 1410 14.7 11.8 3510 14.6

ACE-D 0 8-1/2 17-11/16 26-1/4 32 1760 1410 14.7 11.8 3510 14.6

ACE-TC 0 8-1/2 17-11/16 16-9/16 28 1760 1410 14.7 11.8 3510 14.6

ACE-LD 0 8-1/2 17-11/16 20-1/8 28 1760 1410 14.7 11.8 3510 14.6

ACE-TS 0 8-1/2 17-11/16 Varies 34 1760 1410 14.7 11.8 N/A N/A

Newco Enterprises, Inc. * 3650 New Town Blvd * St. Charles, MO 63301 * Ph 800.325.7867 * Fax 636.925.0029

Summary of content (12 pages)

PAGE 1
Man PN 102863 Rev 20080623 INSTALLATION, OPERATION, AND SERVICE MANUAL FOR THE ACE SERIES - AUTOMATIC COFFEE EQUIPMENT Model ACE-S ACE-LP ACE-AP ACE-D ACE-TC ACE-LD ACE-TS Warmers 3 3 0 0 0 0 0 Width 8-1/2 15-1/2 8-1/2 8-1/2 8-1/2 8-1/2 8-1/2 Depth Height 16-1/2 17-7/16 16-1/2 15-7/8 17-11/16 22-1/4 17-11/16 26-1/4 17-11/16 16-9/16 17-11/16 20-1/8 17-11/16 Varies Weight 29 31 29 32 28 28 34 120 V Watts US Canada 1710 1410 1710 1410 1760 1410 1760 1410 1760 1410 1760 1410 1760 1410 120 V Amps 240 V U
PAGE 2
ACE CONTROL OVERVIEW The ace series brewers have been upgraded to include the “Super Ace” control. This control has all the features of the previous Ace control board with the additional options of pulse brewing, auto arm and half/full brew in one new compact control. These additional options may or may not be activated on your unit and may require additional parts. The following text outlines and explains the features and options. Features: Digital technology – Gives more consistent brew cycle.
PAGE 3
PLUMBER'S INSTALLATION INSTRUCTIONS CAUTION: Power to brewer must be OFF before proceeding with plumbing installation. 1. Flush water line before installing brewer. Brewer should be connected to COLD WATER LINE only. 2. Water pressure should be at least 20 lbs. For less than a 25 ft run, use 1/4" copper tubing and connect to 1/2" or larger water line. For longer runs, use 3/8" copper tubing & connect to 1/2" or larger water line and provide an adapter fitting for connection to the brewer.
PAGE 4
COFFEE PREPARATION PROCEDURES 1. Place filter into brew basket. 2. Put the proper amount of coffee into the filter. 3. Slide the brew basket into holder. 4. Place the appropriate empty decanter into position below the brew basket. For airpots first open lid and remove pump stem. For other dispensers remove the lid unless it is a brew thru design. Turn lower warmer switch, or power switch for dispenser brewers, to the ON position. 5. Press brew start switch.
PAGE 5
TROUBLE SHOOTING GUIDE SYMPTOM CAN'T START BREW CYCLE NO HOT WATER STEAMING OR SPITTING AROUND FUNNEL DRIPPING WATER KEEPS RUNNING OVER FLOWING POSSIBLE CAUSE WHAT TO CHECK REMEDY 1. No water. 1. Incoming water lines and water shutoff valve. 1. Be sure water shutoff valve is open. 2. No power. 2. Fuse or circuit breaker. Power cord and plug connections. 2. Replace or reset circuit breaker as required. Unit should be plugged in securely. 3. ON/OFF or lower warmer switch.
PAGE 6
TROUBLE SHOOTING GUIDE SYMPTOM POSSIBLE CAUSE WHAT TO CHECK REMEDY 1. Not siphoning properly. 1. Refer to "DRIPPING" Step 1. 1. Refer to "DRIPPING" Step 1. 2. Control board/timer. 2. Timer consistency. Time several brew cycles. 2. If times are irregular replace board. 3. Fluctuating water pressure. 3. Water pressure. 3. If pressure fluctuates 10-20 PSI during operation of brew cycle, add a pressure regulator to inlet side of brewer, set to lowest pressure level registered.
PAGE 7
ACE SERIES BREWERS – REPLACEMENT PARTS LIST Part No 100010 100187 102581 102580 100071 102850 704227 111593 100085 201985 102775 102862 102841 121723 111725 100500 ELECTRICAL COMPONENTS Description Warming plate ass'y 120 V, black Warming Element, 120 V 100 W Element main heating, 1100 W 120 V Element main heating, 1400 W 120 V Element main heating, 1750 W 120 V Element main heating, 3500 W 240 V Main thermostat Hi-limit Thermostat, manual reset Lighted rocker switch 120 V Brew switch, black, rectangular D
PAGE 8
Desired Volume 1 liter 64 oz 72 oz 2.2 liters 2.5 liters 3 gallons Item 1 2 3 4a 4b 4c 4d 5 6 7 8a 8b 8c Table 1-Timer Setting Required To Obtain Desired Volume Flow Rate–In Gallons Per MInute 0.175 0.200 0.220 0.250 0.300 0.350 0.500 0.
PAGE 9
Telescoping Brewer Supplemental Information Telescoping Brewer Principal of Operation - Your brewer is equipped with a telescoping column to allow periodic adjustment of the brewer height. This feature allows continued use of the same piece of brewing equipment although the dispensers may change over time. The brewer has an inner and an outer column which slide up and down against each other. Three functional elements combine together to give the telescoping brewer its unique characteristics and strength.
PAGE 10
Telescoping Brewer Chasis Diagrams Telescoping Brewer 120 V Wiring Diagram PAGE 10
PAGE 11
WIRING DIAGRAMS PAGE 11
PAGE 12
Wiring Continued - Thermal Brewer Shown With Autoarm 240V 120V Miscellaneous Figures Valve Section View Micro Switch Section View PAGE 12