2-VOLT UTILITY TASK VEHICLE KT1518WMDS Age: 3–7 years Weight: Maximum 130 lbs (59 kg) Maximum Speed: 5 MPH Battery: 12V t WARNING This manual contains important safety and use information. Keep this manual for future reference. • An adult must read this entire manual • Adult supervision is required at all times Nerf is a trademark of Hasbro and is used with permission. © 2019 Hasbro. All Rights Reserved. Licensed by Hasbro.
1 Safety -- WARNING FAILURE TO FOLLOW THE SAFETY INSTRUCTIONS LISTED BELOW MAY RESULT IN SERIOUS INJURY OR DEATH. The owner’s manual contains assembly, use and maintenance instructions. Child Safety Warnings Safe Riding Warnings • Adults supervising children must read and understand this entire manual before allowing any child to use this product.
-- WARNING 6. Be aware that this ride-on toy does not have braking capabilities. Allowing use of this ride-on toy in areas that require braking may cause rolls, crashes, serious injury, or death to the child rider. 7. Teach children not to allow other children to use this ride-on toy. Communicate this message to other adults and supervisors of fellow children with which your child interacts. 8. Sternly alert children that hands, legs, hair, and clothing can potentially get caught in moving parts.
WARNING Battery and Charging Warnings The following safety hazards may result in serious injury or death to the user of the ride-on: Corrosive Material Warnings • Battery posts, terminals and related accessories contain lead and lead compounds (acids) chemicals and are toxic and corrosive. Never open the battery. • Contact or exposure to battery leakage (lead acid) may cause serious injury. If contact or exposure occurs with the skin or in the eyes, or if the chemical is swallowed, immediately call 911.
CAUTION Re-Charge Interval and Time Important! • Damage to the battery may occur if it is allowed to drain completely. Do not allow the battery to drain completely. Product Warning WARNING WARNING This product can expose you to chemicals including lead, which is known to the State of California to cause cancer and birth defects or other reproductive harm. For more information go to www.P65Warnings.ca.gov. • Check the battery and charger (supply cord, connector) for wear and damage before charging.
Pre-Ride Safety Checklist To be performed by a supervising adult Before every ride, it is important to carry out the following safety checks. Do not ride a battery-powered ride-on toy that is not in proper working condition! Replace any worn or broken parts as needed. Steering and Control The steering wheel or handlebars are tightened and secured in the mount or dashboard. The steering wheel or handlebars are positioned so that the rider can easily operate and steer the ride-on.
Parts 2 Parts List Part number Part name Quantity 1 Seat 1 2 Rollbar 1 3 UTV Body 1 4 Rear wheels 2 5 Hubcaps 4 6 Front wheels 2 7 Windshield 1 8 Steering wheel 1 9 Charger 1 TIP! 1 2 7 8 3 9 4 5 6 Before beginning assembly, check to ensure that the parts listed above are present. Some hardware is attached to the sub assembly.
Hardware (actual size) Tools Required x1 x4 8 x4 x1 (included) x2
3 Assembly Attach Front Wheels ❹ ❶ ❹ ❶ ❸❷ ❷❸ ❺ 9
Attach Rear Wheels ❹ ❶ ❸❷ TIP! When you tighten the nuts (step 3), if you attempt to tighten one nut at a time the axle will spin preventing the nut from properly tightening. Instead tighten the nut on each wheel simultaneously to ensure that all hardware is locked into place.
❷ ❸ ❶ 11
Click TIP! 12 Click
Charge the Battery for the First Time ❷ ❸ 10 ❹ 18 ❸ ❶ ❷ TIP! • The product will not turn on while plugged into the charger. Remove from charger prior to turning on. • Watch for the LED light to turn green to indicate when charging is complete.
Charging the Battery WARNING • A battery contains hazardous material that may cause serious injury or death if handled, connected, or charged improperly. Only an adult who has read and understands the warnings and instructions in this manual should handle, connect, or charge the battery. Always contact Pacific Cycle at 1-877-741-6154 if you have any questions or concerns regarding handling, connecting, or charging the battery.
Attach the Seat ❷ ❺ ❶ ❶ 15
4 Use 5 MPH 2.5 MPH Note Maximum Speed: 5 MPH Minimum Speed: 2.
Charge the Battery ❸ ❷ ❹ 12 ❸ ❶ ❷ TIP! 24+ Do not charge the battery for more than 24 hours. • The product will not turn on while plugged into the charger. Remove from charger prior to turning on. • Watch for the LED light to turn green to indicate when charging is complete.
5 Maintenance Battery Replacement and Disposal ❷ The battery will eventually lose the ability to hold a charge. Depending on the amount of use, and varying conditions, the battery should operate for one to three years. Follow these steps to replace and dispose the battery. Important! Recycle the dead battery responsibly. The battery contains lead acid (electrolyte) and must be disposed of properly and legally. It is illegal in most areas to incinerate lead acid batteries or dispose of them in landfills.
❹ ❹ ❺ ❻ ❼ ❸ 19
6 Care The ride-on toy should be checked for damage, missing or badly worn parts before each use. • Check the tightness of the fasteners before each use. • Check the tightness of the wheels before each use. • Ensure the battery is securely in place before each use. 20 Note • Store the to ride-on toy indoors or cover it with a tarp to protect it from the wet weather. Keep it away from sources of heat, such as stoves and heaters.
7 Service Do not return this product to the place of purchase. If your ride-on toy needs service, repairs or replacement parts, call: Pacific Cycle Consumer Relations Hours: 8:00 am – 5:00 pm (CST) Monday - Friday Phone: 877-741-6154 Email: customerservice@kidtraxtoys.com For a complete list of replacement parts, please contact Pacific-Cycle Consumer Relations. To order parts, please have the model and serial number available, which can be found underneath the seat on the battery cover.
8 Warranty One Year Limited Warranty | Six-Month Limited Limitation of Damages: Warranty on Battery The warranty and remedies as set forth are exclusive and in lieu of Pacific Cycle, Inc. (PC) warrants this product to the original retail purchaser as follows: The ride-on toy (except for the 12-volt battery) is warranted against defective materials or workmanship for one year from the date of original purchase.
