This gas grill must be used only outdoors in a well-ventilated space and must not be used inside a building, garage, screened-in porch, gazebo or any other enclosed area. EN APPLY SERIAL NUMBER LABEL FROM CARTON Serial No. XXXXXX000000 MODEL NO. PG.19 DO NOT DISCARD ROGUE RSE425RSB RSE525RSB RSE625RSB ! ! DANGER IF YOU SMELL GAS: • • • • Shut off gas to the appliance. Extinguish any open flame. Open lid.
Napoleon President’s 15 Year Limited Warranty NAPOLEON products are designed with superior components and materials, and are assembled by trained craftsmen who take great pride in their work. The burner and valve assembly are leak tested and test-fired at a quality test station. This grill has been thoroughly inspected by a qualified technician before packaging and shipping to ensure that you, the customer, receive the quality product you expect from NAPOLEON.
! WARNING! Failure to follow these instructions could result in property damage, personal injury or death. Read and follow all warnings and instructions in this manual prior to operating grill. Safe Operating Practices • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • • N415-0704-AU Jun 02.21 This gas grill must be assembled exactly according to the instructions in the manual.
Location Locating Your Outdoor Gas Grill It is important when selecting a location for your gas grill to ensure clearances to adjacent combustibles are met. This appliance is intended for installation on an outdoor patio or in your yard. ‘This appliance shall only be used in an above ground open-air situation with natural ventilation, without stagnant areas, where gas leakage and products of combustion are rapidly dispersed by wind and natural convection.
N415-0704-AU Jun 02.21 15” (38cm) 55”(140cm ) [NON FOLDED SIDE SHELF] 45”(114cm ) [RSIB NON FOLDED, FOLDED REG SHELF] 48 1/2”(123cm) LID CLOSED 63”(160cm ) LID OPEN 36”(92cm) GRILL HEIGHT 25” (64cm) GRILL DEPTH ALL DIMENSIONS ARE APPROXIMATE GRILL SIZE: 18” X 23 1/2” = 425in2 WARMING RACK SIZE: 6 1/4” X 23 1/4” = 147in2 SIDE BURNER SIZE: 9 1/2” X 11 1/4” = 107in2 3 x 12.7 MJ/h MAIN BURNER 1 x 9.5 MJ/h SIDE BURNER (IF EQUIPPED) 1 x 15.
www.napoleon.com 15” (38cm) 60 1/2”(154cm) [NON FOLDED SIDE SHELF] 50”(127cm) [RSIB NON FOLDED, FOLDED REG SHELF] 48 1/2”(123cm) LID CLOSED 63”(160cm) LID OPEN 36”(92cm) GRILL HEIGHT 25”(64cm ) GRILL DEPTH ALL DIMENSIONS ARE APPROXIMATE GRILL SIZE: 18” X 28 3/4”= 525 in2 WARMING RACK SIZE: 6 1/4” X 28 1/2” = 180in2 SIDE BURNER SIZE: 9 1/2” X 11 1/4” = 107in2 4 x 12.7 MJ/h MAIN BURNER 1 x 9.5 MJ/h SIDE BURNER (IF EQUIPPED) 1 x 15.
N415-0704-AU Jun 02.21 15” (38cm) 36”(92cm ) GRILL HEIGHT 25”(64cm) GRILL DEPTH ALL DIMENSIONS ARE APPROXIMATE 48 1/2”(123cm ) LID CLOSED 63”(160cm) LID OPEN 66”(168cm) [NON FOLDED SIDE SHELF] 56”(142cm) [RSIB NON FOLDED, FOLDED REG SHELF] GRILL SIZE: 18” X 34 3/4”= 625in2 WARMING RACK SIZE: 6 1/4” X 34 1/4” = 216in2 SIDE BURNER SIZE: 9 1/2” X 11 1/4” = 107in2 5 x 12.7 MJ/h MAIN BURNER 1 x 9.5 MJ/h SIDE BURNER (IF EQUIPPED) 1 x 15.
General Information This gas grill is certified for outdoor use and should be installed in conformity with AS/NZS 5601 and local codes. Check gas type and specifications located on the rating plate located on the back panel of the grill. ! ! www.napoleon.com Universal Liquefied Petroleum Gas Cylinder Specifications WARNING! If these instructions are not followed exactly, a fire causing death or serious injury may occur. WARNING! Do not store a spare ULPG cylinder on the shelf beneath the barbecue.
Cylinder Connection: Ensure the gas regulator hose is kink free. Remove the cap or plug from the cylinder fuel valve. Insert the black QCC1 regulator nipple onto the QCC1 fuel valve. Hand tighten clockwise. Do not use tools. Leak test all joints prior to using the grill. A leak test must be performed annually and each time a cylinder is hooked up or if a part of the gas system is replaced.
Lighting Instructions 525 425 625 Side Burner Rear Burner Igniter Lights Left Centre Right Centre Left Burner Burner Burner Right Burner Side Burner Side Burner Rear Burner Rear Burner Igniter Lights Igniter Left Burner ! Centre Burner Lights Right Burner Left Burner Left Centre Burner Centre Burner Right Centre Right Burner Burner WARNING! Open lid Off Position OFF WARNING! Ensure all burner controls are in the off position. Slowly turn on the gas HIGH supply valve. LOW ! www.
Cooking Instructions Initial Lighting: When lit for the first time, the gas grill emits a slight odor. This is a normal temporary condition caused by the “burn-in” of internal paints and lubricants used in the manufacturing process and does not occur again. Simply run the main burners on high for approximately one-half hour. Main Burner Use: When searing foods, the lid must be kept open and the burners can be set to high.
! Infrared Side Burner Use (If Equipped): The gas grill should be located so that the side burner is protected from the wind, because the wind will adversely affect its performance. The recommended pan diameter is 10” (25 cm). CAUTION! Do not close the side burner lid while it is operating or hot. CAUTION! Do not adjust cooking grid while hot or operating. CAUTION! Do not use side burner to deep fry foods as cooking with oil can create a dangerous situation. ! 1.
Infrared Grilling Chart Food Control Setting Cooking Time Helpful Suggestions Steak 1 in. (2.54cm) thick High setting 2 min. each side. 4 min. – Rare High setting 2 min. each side then medium setting. 6 min. – Medium High setting 2 min. each side then medium setting. 8 min. – Well done When selecting meat for grilling, ask for marbled fat distribution. The fat acts as a natural tenderizer while cooking and keeps it moist and juicy. High setting 2 min. each side. 4 min.
Cleaning Instructions WARNING! Always wear protective gloves and safety glasses when servicing your grill. ! WARNING! To avoid the possibility of burns, maintenance should be done only when the grill is cool. Avoid unprotected contact with hot surfaces. Ensure all burners are turned off. Clean grill in an area where cleaning solutions will not harm decks, lawns, or patios. Do not use oven cleaner to clean any part of this gas grill.
! WARNING! Accumulated grease is a fire hazard. Drip Pan: Clean the drip pan frequently (every 4 – 5 uses or as often as required) to avoid grease buildup. Grease and excess drippings pass through to the drip pan, located beneath the gas grill and accumulate in the disposable grease tray below the drip pan. To access the disposable grease tray or to clean the drip pan, slide the drip pan free of the grill.
Burner: The burner is made from heavy wall 304 stainless steel, but extreme heat and a corrosive environment can cause surface corrosion to occur. This can be removed with a brass wire brush. CAUTION! Beware of Spiders. Spiders and insects are attracted to the smell of Universal Liquefied Petroleum Gas (ULPG). The burner is equipped with an insect screen on the air shutter, which reduces the likelihood of insects building nests inside the burner but does not entirely eliminate the problem.
Problem Possible Causes Solution Excessive flare-ups/ uneven heat. Sear plates installed incorrectly. Ensure sear plates are installed with the holes towards the front and the slots on the bottom. See assembly instructions. Improper preheating. Preheat grill with main burners on high for 10 minutes. Excessive grease and ash build on sear plates and in drip pan. Clean sear plates and drip pan regularly. Do not line pan with aluminum foil. Refer to cleaning instructions.
KEEP YOUR RECEIPT AS PROOF OF PURCHASE TO VALIDATE YOUR WARRANTY. Ordering Replacement Parts Warranty Information MODEL: DATE OF PURCHASE: SERIAL NUMBER: (Record information here for easy reference) For replacement parts and warranty claims, contact the Napoleon dealer where the product was purchased. Before contacting the dealer, check the Napoleon Grills Website for more extensive cleaning, maintenance, troubleshooting and parts replacement instructions at www.napoleon.com.
CAUTION! During unpacking and assembly we recommended you wear work gloves and safety glasses for your protection. Although we make every effort to make the assembly process as problem free and safe as possible, it is characteristic of fabricated steel parts that the edges and corners might be sharp and could cause cuts if handled incorrectly. Getting Started ! 1. Remove all cart panels, hardware, and grill head from carton. Raise lid and remove any components packed inside.
! WARNING – FIRE HAZARD ! WARNING! Do not route hose underneath drip pan. ! www.napoleon.com WARNING! Ensure the hose does not contact any high temperature surfaces, or it may melt and leak causing a fire. N415-0704-AU Jun 02.
Leak Testing Instructions ! ! WARNING! A leak test must be performed annually and each time a cylinder is hooked up or if a part of the gas system is replaced. WARNING! Never use an open flame to check for gas leaks. Be certain no sparks or open flames are in the area while you check for leaks. Sparks or open flames will result in a fire or explosion, damage to property, serious bodily injury, or death.
PARTS LIST Part Number 1 Description N010-1031-SS lid assembly N010-1034-SS lid assembly RSE425 RSE525 RSE625 x x N010-1233-SS lid assembly 2 S91003 temperature gauge x x x 3 N385-0307-SER logo x x x 4 N510-0013 lid bumper x x x 5 S87014 lid pivot hardware x x x 6 S87010 crosslight bracket x S87013 crosslight bracket S87017 crosslight bracket 7 S87001 burner and sear plate x 8 N010-1518-SER control panel assembly p N010-1519-SER control panel assembly
PARTS LIST Part Number 23 Description RSE425 RSE525 RSE625 N475-0363-GY1SG rear cart panel N475-0449-GY1SG rear cart panel N475-0499-GY1SG rear cart panel 24 N080-0437-GY1SG heat shield bracket left/right x x x 25 N570-0126 1/4-20 x 1/2” screw x x x 26 N080-0364 folding bracket “A” x x x 27 N710-0062 grease tray x x x 62007 grease tray liners (5pc) ac ac ac 28 N010-1521-SER side shelf assembly x x x 29 N080-0422-SER bottle opener x x x 30 N370-0928-SE
PARTS LIST Part Number Description RSE425 RSE525 RSE625 N710-0120 drip pan N530-0048 regulator p p p N530-0003 QCC1 regulator p p p 59 N750-0016 side burner electrode x x x 61 N357-0021 2-spark igniter block x x x 62 N720-0055 side burner hose x x x 64 N160-0023 side burner orifice clip x x x 65 N455-0085 side burner orifice p p p 66 N450-0006 locking nut 1/2-20 x x x 67 N720-0082 rear burner hose x x x 68 N255-0058 90 degree fitting x x x
1 14 9 3 15 10 6 4 72 8 5 2 7 12 70 75 11 69 71 13 16 68 73 17 87 67 19 74 20 66 8 76 78 21 77 79 65 80 64 81 83 84 85 22 62 61 59 57 26 51 45 54 28 25 86 55 23 24 27 58 56 29 32 31 30 33 35 50 34 36 37 47 46 45 18 52 44 48 53 N415-0704-AU Jun 02.21 43 49 38 39 40 41 42 www.napoleon.
Napoleon products are protected by one or more U.S. and Canadian and/or foreign patents or patents pending. www.napoleon.
