OPERATION AND PARTS MANUAL © COPYRIGHT 2004, MULTIQUIP INC. MODEL SS-233 SUBMERSIBLE PUMP Revision #2 (05/03/04) STOW CONSTRUCTION EQUIPMENT PARTS DEPARTMENT: A DIVISION OF MULTIQUIP INC. POST OFFICE BOX 6254 CARSON, CA 90749 310-537-3700 • 888-252-STOW [888-252-7869] FAX: 310-537-1986 • FAX: 800-556-1986 E-MAIL: stow@multiquip.com • WWW: stowmfg.
HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING PARTS DEPARTMENT 800-427-1244 FAX: 800-672-7877 310-537-3700 FAX: 310-637-3284 SERVICE DEPARTMENT 800-478-1244 FAX: 310-537-4259 310-537-3700 TECHNICAL ASSISTANCE 800-478-1244 FAX: 310-631-5032 WARRANTY DEPARTMENT 800-421-1244, EXT. 279 FAX: 310-537-1173 310-537-3700, EXT. 279 SALES DEPARTMENT 310-661-4242 FAX: 310-604-9237 877-289-7869 (877-BUY-STOW) PAGE 2 — STOW SS-233 SUBMERSIBLE PUMP — OPERATION MANUAL — REV.
STOW SS-233 SUBMERSIBLE PUMP — TABLE OF CONTENTS STOW MODEL SS-233 SUBMERSIBLE PUMP Here's How To Get Help ............................................2 Table Of Contents .....................................................3 Parts Ordering Procedures .......................................4 Safety Message Alert Symbols .................................5 Rules For safe Operation ..................................... 6-7 Specifications ............................................................
STOW YELLOW SUB.
STOW YELLOW SUB. PUMP — SAFETY MESSAGE ALERT SYMBOLS FOR YOUR SAFETY AND THE SAFETY OF OTHERS! Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the Safety Messages and Operating Instructions could result in injury to yourself and others. NOTE This Owner's Manual has been developed to provide complete instructions for the safe and efficient operation of the STOW Model SS233 Submersible Pump.
STOW SS-233 SUBMERSIBLE PUMP — RULES FOR SAFE OPERATION CAUTION: Failure to follow instructions in this manual may lead to serious injury or even death! This equipment is to be operated by trained and qualified personnel only! This equipment is for industrial use only. The following safety guidelines should always be used when operating the STOW Model SS-233 Submersible Pump: GENERAL SAFETY ■ DO NOT operate or service this equipment before reading this entire manual.
STOW SS-233 SUBMERSIBLE PUMP — RULES FOR SAFE OPERATION ■ ALWAYS make sure that electrical circuits are properly grounded per the National Electrical Code (NEC) and local codes before operating pump. Severe injury or death by electrocution can result from operating an ungrounded pump. E . mergencies ■ ALWAYS know the location of the nearest fire extinguisher. ■ ALWAYS be sure the operator is familiar with proper safety precautions and operations techniques before using submersible pump.
STOW SS-233 SUBMERSIBLE PUMP — SPECIFICATIONS TABLE 1. SPECIFICATIONS Model SS-233 Type Submersible Pump Plastic Impeller Suction & Discharge Size 2.00 in. (50.8 mm) Maximum Pumping Capacity 64 gallons/minute (238 liters/minute) Discharge Height Above Pumping Level 5 ft (1.5 meters) 3,720 gallons/hr (14,082 liters) 10 ft (3.0 meters) 3,300 gallons/hr (12,492 liters) 15 ft (4.5 meters) 2,700 gallons/hr (10,221 liters) 20 ft (6.0 meters) 2,100 gallons/hr (7,950 liters) 0.5 HP (0.
STOW SS-233 SUBMERSIBLE PUMP — GENERAL INFORMATION Introduction The STOW Model SS-233 submersible pumps is designed to pump water and is used for the draining (de-watering) of flooded rooms, drains and fill tanks, power fountains and waterfalls swimming pool covers, and flat roofs. A plastic impeller is attached to the output shaft of a 1/2 HP electric motor which provides adequate power for general purpose pumping.
STOW SS-233 SUBMERSIBLE PUMP — COMPONENTS Figure 1. Submersible Pump Components Figures 1 shows the location of the basic components, for the STOW Model SS-233 submersible pump. Listed below is a brief explanation of each component. 1. AC Power Cable – This unit is supplied with a 20 ft. (6.1 meters) AC power cable. Always check the cable for signs of wear. NEVER! use a defective power cable. Replace the cable immediately if the cable is worn or defective. 2.
STOW SS-233 SUBMERSIBLE PUMP — OPERATION Operation 1. Attach a suitable lifting cable (rope) to the carrying handle (Figure 2) on the pump and lower the pump into place. For applications where there is an excessive amount of mud, grit or silt, the use of a support platform is desirable. When pumping water from swimming pool type applications where there is little or no debris, the support platform is not required. 2. Make sure the pump is always placed in an upright position, not tilted (Figure 3).
STOW SS-233 SUBMERSIBLE PUMP — OPERATION 4. NEVER! grab or touch a live power cord (Figure 4) with wet hands, the possibility exists of electrical shock, electrocution and even death. WET HANDS 4. Wait a few seconds and water should begin to flow from the discharge hose. 5. If water is not flowing from the discharge hose or not flowing freely after a few minutes, remove the power from the pump and check the system for leaks. Pump Shut-Down/Clean-up 1.
STOW SS-233 SUBMERSIBLE PUMP — TROUBLESHOOTING/CABLE TABLE 2. PUMP TROUBLESHOOTING SYMPTOM POSSIBLE PROBLEM SOLUTION Incorrect voltage/amps? Check that proper voltage (115 VAC 1Ø) is being supplied to the pump. Also check that there is an adequate amount of current (amps) to run the pump. Check power source circuit breaker. Check electrical connections? Inspect power cord. Blown fuse or defective circuit breaker? Replace fuse or circuit breaker. Check cause of blown fuse or tripped circuit breaker.
STOW SS-233 SUBMERSIBLE PUMP — PUMP ASSY. PAGE 14 — STOW SS-233 SUBMERSIBLE PUMP — OPERATION MANUAL — REV.
STOW SS-233 SUBMERSIBLE PUMP — PUMP ASSY. PUMP ASSY. NO. PART NO. 1 020177 2 020246 3 PART NAME QTY. REMARKS CABLE 20 FT 1 FITTING, 2" NPT 1 SUBMERSIBLE PUMP ....................... 1 ................... CONTACT MQ UNIT SALES STOW SS-233 SUBMERSIBLE PUMP — OPERATION MANUAL — REV.
Effective: July 15, 2003 TERMS AND CONDITIONS OF SALE — PARTS Terms and Conditions of Sale STOW Construction Equipment PAYMENT TERMS Terms of payment for unit sales are 2% 15 days net 30 days from date of invoice unless otherwise specifically stated on our invoice. Parts invoices have terms of net 10 days. Minimum parts billing is $15.00 net. Applicable discounts will be computed on merchandise value only. Late charges will be assessed at prevailing rates.
NOTE PAGE STOW SS-233 SUBMERSIBLE PUMP — OPERATION MANUAL — REV.
OPERATION AND PARTS MANUAL HERE'S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING PARTS DEPARTMENT 800-427-1244 FAX: 800-672-7877 310-537-3700 FAX: 310-637-3284 SERVICE DEPARTMENT 800-478-1244 FAX: 310-537-4259 310-537-3700 TECHNICAL ASSISTANCE 800-478-1244 FAX: 310-631-5032 WARRANTY DEPARTMENT 800-421-1244, EXT. 279 FAX: 310-537-1173 310-537-3700, EXT.
