Operation and Parts Manual MODEL gac3.6hz portable generator (HONDA GX240 GASOLINE ENGINE) Revision #1 (03/31/10) To find the latest revision of this publication, visit our website at: www.multiquip.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
Table of Contents GAC3.6HZ Portable 60 Hz Generator Table Of Contents..................................................... 2 Parts Ordering Procedures....................................... 3 Safety Information................................................. 4-8 Specifications (Generator)...................................... 12 Specifications (Engine)........................................... 11 Dimensions............................................................. 12 Installation.....................
www.multiquip.com parts ordering procedures Ordering parts has never been easier! choose from three easy options: Order via internet (dealers Only): Best deal! Effective: January 1st, 2006 If you have an MQ Account, to obtain a Username and Password, E-mail us at: parts@multiquip. com. Order parts on-line using Multiquip’s SmartEquip website! ■ View Parts Diagrams ■ Order Parts ■ Print Specification Information To obtain an MQ Account, contact your District Sales Manager for more information.
Safety Information Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the safety messages and operating instructions could result in injury to yourself and others. Potential hazards associated with the operation of this equipment will be referenced with hazard symbols which may appear throughout this manual in conjunction with safety messages.
Safety Information geNeRal saFeTY cauTiON NeveR operate this equipment without proper protective clothing, shatterproof glasses, respiratory protection, hearing protection, steel-toed boots and other protective devices required by the job or city and state regulations. NeveR operate this equipment when not feeling well due to fatigue, illness or when under medication. NeveR operate this equipment under the influence of drugs or alcohol.
Safety Information eNgiNe saFeTY daNgeR The engine fuel exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled. The engine of this equipment requires an adequate free flow of cooling air. NeveR operate this equipment in any enclosed or narrow area where free flow of the air is restricted. If the air flow is restricted it will cause injury to people and property and serious damage to the equipment or engine.
Safety Information NeveR use fuel as a cleaning agent. dO NOT smoke around or near the equipment. Fire or explosion could result from fuel vapors or if fuel is spilled on a hot engine. elecTRical saFeTY daNgeR Make sure power cables are securely connected to the generator’s output receptacles. Incorrect connections may cause electrical shock and damage to the generator. NOTICE alWaYs make certain that proper power or extension cord has been selected for the job.
Safety Information If the battery liquid (dilute sulfuric acid) comes into contact with clothing or skin, rinse skin or clothing immediately with plenty of water. eNviRONmeNTal saFeTY If the battery liquid (dilute sulfuric acid) comes into contact with eyes, rinse eyes immediately with plenty of water and contact the nearest doctor or hospital to seek medical attention. Dispose of hazardous waste properly. Examples of potentially hazardous waste are used motor oil, fuel and fuel filters.
NOTES gac3.6hz 60 hz GENERATOR • operation and parts manual — rev.
SPECIFICATIONS (gENERATOR) Table 1. Specifications (Generators) Model Type Excitation Speed Cooling System Continuous Power Output AC Generator Max Power Output 60 Hz AC Power Sourc Rated Voltage Current Max/Continuous (120V) Current Max/Continuous (240V) Phase Frequency Power Factor Dimensions (L x W x H) Dry Net Weight GAC3.6HZ Brushless Revolving Field Type Solid State, Statically Excited System 3,600 RPM Self-Ventilation 3.2 kW 3.6 kW 120/240V 30.0/26.6 amps 15.0/13.
SPECIFICATIONS (engine) Engine Dimensions (L x W x H) Dry Net Weight Table 2. Specifications (Engine) HONDA GX240K1EDN2 Model HONDA GX240U1EDN2 Air-cooled 4 stroke, Single Cylinder, OHV, Type Horizontal Shaft Gasoline Engine 2.87 in. X 2.28 in. Bore X Stroke (73 mm x 58 mm.) Displacement 14.75 cu-in (242 cm3) Max Output 8.0 H.P./3600 R.P.M. Fuel Unleaded Automobile Gasoline Fuel Capacity 5 gallons (19 liters) Lube Oil Capacity 1.16 quarts (1.
dimensions 3600 GAC-3.6H OFF POWERED by 18.9 IN (480 MM.) Honda Engines 211052 AC CIRCUIT BREAKER INTERRUPTEUR DE COURANT PRINCIPAL MARCHE V 120 NEUTRAL BONDED TO FRAME NEUTRE MIS A LA MASSE A AC VOLTMETER LA CARCASSE DU MOTEUR VOLTOMETRE CA ON MARCHE ON ARRET OFF OFF ARRET IDLE OPERATION CONTROL SWITCH CONTROL INTERRUPTEUR DE RALENTI DE OPERATION 240V 120V GR PRISE DE TERRE 25.0 IN (635 MM.) 19.68 IN (500 MM.) Figure 1. Dimensions page 12 — gac3.
note gac3.6hz 60 hz GENERATOR • operation and parts manual — rev.
installation Connecting the Ground The nut and ground terminal on the generators should always be used to connect the generators to a suitable ground. The ground cable should be #8 size wire minimum. At the generator, connect the terminal of the ground cable between the lock washer and the nut (Figure 2) and tighten the nut fully. Connect the other end of the ground cable to a suitable earth ground (ground rod). 3600 GAC-3.
installation Outdoor Installation Generator Grounding If possible install the generator in a area that is free of debris, bystanders, and overhead obstructions. Make sure the generator is on secure level ground so that it cannot slide or shift around. To guard against electrical shock and possible damage to the equipment, it is important to provide a good EARTH ground. The installation site must be relatively free from moisture and dust.
general information GAC3.6HZ FAMILIARIZATION Generator The Multiquip GAC3.6HZ generator has been designed as a portable dual purpose power source for 60 Hz (single phase) lighting facilities, power tools, submersible pumps and other industrial and construction machinery. DANGER Before connecting this generators to any building’s electrical system, a licensed electrician must install an isolation (transfer) switch. Serious injury or death may result without this transfer switch.
components (generator) 3600 GAC-3.6H POWERED by OFF 1 Honda Engines 211052 AC CIRCUIT BREAKER INTERRUPTEUR DE COURANT PRINCIPAL MARCHE V 120 NEUTRAL BONDED TO FRAME NEUTRE MIS A LA MASSE A AC VOLTMETER LA CARCASSE DU MOTEUR VOLTOMETRE CA ON MARCHE 240V 120V 9 8 ON ARRET OFF OFF ARRET IDLE OPERATION CONTROL SWITCH CONTROL INTERRUPTEUR DE RALENTI DE OPERATION GR PRISE DE TERRE 2 3 4 5 6 7 Figure 3. Generator Components 1.
components (generator) Figure 4. Generator Components (Continued) 10. Spark Plug – Provides spark to the ignition system. Set spark plug gap to 0.6 - 0.7 mm (0.028 - 0.031 inch) Clean spark plug once a week. 16. Engine Oil Filler Cap – Remove cap/dipstick when the adding of engine oil is required. See Table 4 for recommended type engine oil. 11. Muffler/Heat Shield – Used to reduce noise and emissions. NEVER touch this heat shield when the generator/welder is in use.
INSPECTION/SETUP General Inspection Prior to Operation Ground Power Tools When using power tools or electrical equipment requireing AC power from the generator, make sure power tool cord has a ground pin or is double insulated as shown in Figure 5. NOTICE Double-insulated power tools and small appliances have specially insulated housings that eliminate the need for a ground pin.
INSPECTION/SETUP Before Starting 1. Read safety instructions at the beginning of manual. 2. Clean the generator, removing dirt and dust, particularly the engine cooling air inlet, carburetor and air cleaner. 3. Check the air filter for dirt and dust. If air filter is dirty, replace air filter with a new one as required. 4. Check carburetor for external dirt and dust. Clean with dry compressed air. Figure 7. Engine Oil Dipstick(Oil Level) 5. Check fastening nuts and bolts for tightness Engine Oil Check 1.
operation This section is intended to assist the operator with the initial start-up of the portable generator. It is extremely important that this section be read carefully before attempting to use the generators in the field. Before Starting the Engine 3. Place the choke lever (Figure 11) in the OPEN position if starting a warm engine or the temperature is warm. 4. Place the generator's operation switch (Figure 12) in the ON position. 1.
operation 7. Before the generators is placed into operation, run the engine for 3-5 minutes. Check for abnormal smells, fuel leaks, and noises that would associate with lose components. additional verification of voltage, an external voltmeter can be used to measure the output voltage as shown in Figure 17. 8. Place the idle control switch (Figure 14) in the OFF (down) position. This will allow the engine speed to run at about 3600 RPM's. Figure 14.
operation/shutdown Stopping the Engine 1. Place the main circuit breaker (Figure 19) in the OFF position. 1. Place the generator's operation switch (Figure 21) in the OFF position. Figure 19. Main Circuit Breaker (OFF) 2. Place the idle control switch (Figure 20) in the OFF position. Figure 20. Idle Control switch (OFF) 3. Let the engine run at idle with no load for 2-3 minutes. 4. To shut-down the engine, place the generator's operation switch (Figure 21) in the OFF position. Figure 21.
preparation for long term storage Generators Storage For storage of the generating set for over 30 days, the following is required: Drain the fuel tank completely, or add STA-BIL to the fuel. Run the engine until the gasoline in the carburetor is completely consumed. Completely drain the oil from the crankcase and refill with fresh oil. Remove the spark plug, pour 2 or 3 cc of SAE 30 oil into the cylinder and crank slowly to distribute the oil.
maintenance Use Table 5 as a general maintenance guideline when servicing your engine. For more detail engine maintenance information, refer to the engine owner's manual supplied with your engine. Table 5.
maintenance Maintenance Perform the scheduled maintenance procedures as defined by Table 5 and below: Daily Thoroughly remove dirt and oil from the engine and control area. Clean or replace the air cleaner elements as necessary. Check and retighten all fasteners as necessary. Weekly Remove the fuel filter cap and clean the inside of the fuel tank. Remove or clean the filter at the bottom of the tank. Remove and clean the spark plug (Figure 23), then adjust the spark gap to 0.024 ~0.028 inch (0.
generator wiring diagram SYMBOL PART NAME Ar Armature Winding Fg-PN Field Winding EXW1~2 Excitation Winding V AC Voltmeter (120/240) Re1~2 Rectifier CON1 Receptacle L5-30R CON2 Receptacle L6-20R CON3 CB Wiring Color Code Symbol Color Symbol B BLACK R Color RED L BLUE W WHITE Receptacle 5-15R BR BROWN Y YELLOW UPM-2 20A G GREEN LB LIGHT BLUE CB1 CP-31E/15N 15A GR GRAY LG LIGHT GREEN SW1 Idle Control Switch V VIOLET O ORANGE SW2 Operation Switch P PINK RC
troubleshooting Table 6. Engine Troubleshooting Symptom Difficult to start. Fuel is available but no SPARK at spark plug. Difficult to start. Fuel is available and SPARK is present at the spark plug. Difficult to start. Fuel is available, SPARK is present at the spark plug and compression is normal. Difficult to start. Fuel is available, SPARK is present at the spark plug and compression is low. No fuel present at carburetor. Weak in power. Compression is proper and does not misfire.
troubleshooting Table 6. Engine Troubleshooting (Continued) Symptom Possible Cause Solution Weak in power. Compression is proper but misfires. Water in fuel system? Flush fuel system and replace with correct type of fuel. Dirty spark plug? Clean or replace spark plug Ignition coil defective? Replace ignition coil. Spark plug heat value improper? Replace with correct type of spark plug. Incorrect type of fuel? Replace with correct type of fuel. Cooling fins dirty? Clean cooling fins.
troubleshooting Symptom Low voltage Low voltage. Engine speed normal 3650 RPM (unloaded), 2500 RPM (idle) Table 7. Generator Troubleshooting Possible Problem Solution Engine speed too low? Raise engine speed to rated RPM. AC voltmeter not working? Replace Ac voltmeter. Control box internal wiring Check control box wiring. malfunction? Check red and green ignition wires. Defective ignition coil? Replace ignition wires if necessary. Rotor winding malfunction? Check or replace rotor.
notes gac3.6hz 60 hz GENERATOR • operation and parts manual — rev.
Explanation of Code in Remarks Column The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if there are any questions. NOTICE The contents and part numbers listed in the parts section are subject to change without notice. Multiquip does not guarantee the availability of the parts listed. sample paRTs lisT NO. 1 2% 2% 3 4 paRT NO. paRT Name QTY. RemaRKs 12345 BOLT......................1 .....
Suggested Spare Parts gaC3.6HZ portable 60 hZ generator with honda GX240k1edn2/GX240U1EDN2 gasoline engineS 1 to 3 units Qty. P/N Description 1............0810106004...........CAP FUEL TANK 1............0810107103...........FILTER FUEL 1............7895419004...........rubber suspension 4............1725419214...........rubber suspension 3............9807955846...........SPARK PLUG 1♦..........15510ZE2043........SWITCH ASSY., OIL ALERT 1◊ .........15510ZE2053........SWITCH ASSY., OIL ALERT 2............
nameplate and decals S/N 5561008 AND BELOW CAUTION Do not use in rain or snow. 1 ATTENTION Ne pas utiliser en cas de pluie ou neige. 3600 A3520000A 8 7 CAUTION/ATTENTION HOT PARTS can burn skin. DO NOT touch until the lamp has sufficiently cooled. 2 Danger de brûlure, pièces chaudes. FUEL COCK ROBINET’ D ESSENCE ON/OUVERT Ne touchez pas avant que l’appareil ne soit suffisamment refroidi.
nameplate and decals NO. PART NO. 1 A3552000004A 2 A6552000404A 3 A6532100904A 4 A6532101004A 5 A5552000804 6 A5552000704A 7 A9508200004 8 W7910631002 10 A3532100304A 11 A9511100204 12 A9504000104 13 A9504000204 PART NAME QTY. REMARKS DECAL; CAUTION, RAIN SNOW........................1................A35200000A DECAL; CAUTION, HOT PARTS........................1................A65300040A DECAL; WARNING, EXHAUST GASES.............1................A63210090A DECAL; DANGER, ELECTROCUTION..............
generator assy. page 36 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
generator assy. NO. 1 1-1 1-2 1-3 2 3 4 5 6 7 8 9 10 11 12 13 14 15 15A PART NO.
CONTROL BOX assy. page 38 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
CONTROL BOX assy. NO. 1 2 3 4 4A 5 6 7 8 9 10 11 12 13 13A 14 15 16 17 18 19 20 20A 21 21A 21B 22 23 23A 23B 24 24A 25 25A 26 27 28 29 PART NO.
PIPE FRAME assy. page 40 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
PIPE FRAME assy. NO. 1 2 3 4 5 6 7 8 9 10 10A 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 PART NO. A3418000003 7915415004 0017106016 7915443003 7895419004 0207008000 1725419214 0207008000 0017108040 0017108040 0207008000 7915455103 7915455003 0017106016 7905512002 0810106004 0810107103 0602125034 7855525514 7855525604 0017108030 0017108020 16950ZB4015 950014519040 0605515096 0019106015 PART NAME QTY. REMARKS PIPE FRAME 1 BRACKET 1 HEX. HEAD BOLT 4 BASE 1 RUBBER SUSPENSION 2 HEX.
MUFFLER assy. page 42 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
MUFFLER assy. NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 13A 14 15 16 17 PART NO. 7912310003 18320ZB4000 18325ZB4000 18329ZB4000 18355ZB4630 90183671003 0017106012 18333ZB4800 957000802000 7915461004 0017108020 7915460004 0017108025 0207008000 0017108020 7915469004 0017106020 0017106012 PART NAME QTY. REMARKS MUFFLER 1 PROTECTOR, MUFFLER...................................1................REPLACES P/N 0602302000 PROTECTOR, MUFFLER...................................1................
honda gx240k1/u1edn2 engine — cylinder head assy. page 44 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — cylinder head assy. NO. 1♦ 1◊ 2 3 4 5 6 7 8♦ 9♦ 10 11 12 13 14 15 16♦ 16◊ 16◊ 17 17 18♦ PART NO. 12200ZH9000 12200ZH9405 12204ZE2306 12205ZE2305 12216ZE2300 12251ZE2800 12310ZE2020 12391ZE2020 18330ZE3700 18333ZE3800 90014ZE2000 90042ZE2700 92900080320E 90441ZE2010 9405008000 9430112200 957251008000 957251008000 957011008000 9807955846 9807955855 14775ZE2010 PART NAME QTY. REMARKS HEAD COMP., CYLNDER 1 HEAD COMP., CYLNDER 1 GUIDE, IN. VALVE (OVER SIZE) 1 GUIDE, EX.
honda gx240k1/u1edn2 engine — cylinder barrel assy. page 46 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — cylinder barrel assy. NO. 1♦ 1◊ 2♦ 2◊ 2◊ 3 4 5 6 7 8 9# 10 11 12 13 14 15♦ 15◊ 15◊ PART NO. 12000ZE2815 15510ZE2406 15510ZE2043 15510ZE2043 15510ZE2053 16541ZE2010 31161ZE2000 90013883000 90131883000 90446KE1000 9410912000 91201890003 91353671004 9405010000 9425108000 957010601200 90013883000 34150ZH7003 34150ZH7003 34150ZH7013 PART NAME QTY. REMARKS BARREL ASSY., CYLINDER..............................1................INCLUDES ITEM W/# BARREL ASSY., CYLINDER 1 SWITCH ASSY.
honda gx240k1/u1edn2 engine — crankcase cvr. assy. page 48 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — crankcase cvr. assy. NO. 2♦ 2◊ 3 4 6 8%$ 9# 10#< 11#< 12#< 13♦# 13◊ # 14♦ 15# 16 18# 19 20# 21◊ # PART NO. 11300ZE2000 11300ZE2020 11381ZE2801 15600ZG4003 15600735003 15625ZE1000 16510ZE2000 16511ZE2000 16512ZE2000 16513ZE2000 16531ZE2000 16531Z0A000 90473147000 90602ZE1000 90701HC4000 9410106800 957010803500 961006206000 91201890003 PART NAME QTY. REMARKS COVER ASSY., CRANKCASE............................1................INCLUDES ITEMS W/# COVER ASSY., CRANKCASE.............
honda gx240k1/u1edn2 engine — CRANKSHAFT assy. page 50 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — CRANKSHAFT assy. NO. 1♦ 1◊ 1◊ 4# 5◊ PART NO. 13310ZE2701 13310ZE2701 13310ZE2702 961006206000 90741ZE2000 PART NAME QTY. REMARKS CRANKSHAFT COMP.........................................1................INCLUDES ITEM W/# CRANKSHAFT COMP.........................................1................INCLUDES ITEM W/# CRANKSHAFT COMP.........................................1................
honda gx240k1/u1edn2 engine — PISTON assy. page 52 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — PISTON assy. NO. 1 1 1 1 1 1 1 1 2 2 2 2 3 4 4 5# 6 PART NO. 13020ZE2921 13010ZE2922 13011ZE2921 13011ZE2922 13012ZE2013 13012ZE2921 13013ZE2922 13013ZE2014 13101ZE2W00 13102ZE2W00 13103ZE2W00 13104ZE2W00 13111ZE2000 13200ZE2000 13200ZE2305 90001ZE8000 90551ZE1000 PART NAME QTY. REMARKS RING SET, PISTON (STD) 1 RING SET, PISTON (STD) 1 RING SET, PISTON (0.25) 1 RING SET, PISTON (0.25) 1 RING SET, PISTON (0.50) 1 RING SET, PISTON (0.50) 1 RING SET, PISTON (0.
honda gx240k1/u1edn2 engine — cAMshaft assy. page 54 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — cAMshaft assy. NO. 1 2 3 4 5 6# 7 8 9 10 11 12◊ 13 14 15 16 17 PART NO. 14100ZE2W01 14410ZE2013 14431ZE2010 14441ZE2000 14451ZE1013 14568ZE1000 14711ZE2000 14721ZE2000 14751ZE2003 14771ZE2000 14773ZE2000 14775ZE2010 14781ZE2000 14791ZE2010 90012ZE0010 90206ZE1000 12209ZE8003 PART NAME QTY. REMARKS CAMSHAFT ASSY..............................................1................
honda gx240k1/u1edn2 engine — RECOIL STARTER assy. page 56 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — RECOIL STARTER assy. NO. 1 2# 3# 4# 5# 6# 7# 8# 10# 11# 13# 14 PART NO. 28400ZE2W01ZB 28410ZE2W01ZB 28421ZE2W01 28422ZE2W01 28441ZE2W01 28442ZE2W01 28443ZE2W01 28444ZE2W01 28461ZE2W02 28462ZE2W11 90004ZE2W01 90008ZE2003 PART NAME STARTER ASSY, RECOIL "NH105" CASE COMP., RECOIL STARTER PULLEY, RECOIL STARTER RATCHET, STARTER SPRING, FRICTION SPRING, STARTER RETURN SPRING, RATCHET RETAINER, SPRING GRIP, STARTER ROPE, RECOIL STARTER SCREW, CENTER BOLT, FLANGE, 6X10 QTY.
honda gx240k1/u1edn2 engine — FAN COVER assy. page 58 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — FAN COVER assy. NO. 1 2 3 4 5 PART NO. 19610ZE2700ZD 19631ZE2D00 81329567020 90013883000 90654SA4003 PART NAME COVER COMP., FAN SHROUD GROMMET, DRAIN HOLE BOLT, FLANGE, 6X12 CLIP, WIRE HARNESS QTY. 1 1 1 6 2 REMARKS gac3.6hz 60 hz GENERATOR • operation and parts manual — rev.
honda gx240k1/u1edn2 engine — caRBURETOR assy. page 60 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — caRBURETOR assy. NO. PART NO.
honda gx240k1/u1edn2 engine — caRBURETOR assy. page 62 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — caRBURETOR assy. NO. 26$ 27$ 28$ 29 30$ 31 32$ 33$ 34$ 35$ 36 37$ 38# 39 40$ 41$ 42$ 43 44 45 46 46 46♦# 47# 48 49# PART NO.
honda gx240k1/u1edn2 engine — AIR CLEANER assy. page 64 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — AIR CLEANER assy. NO. 1 2 3♦ 3◊ 3◊ 4 5 6 7 8 9 10 11 12 13◊ 14◊ PART NO. 15721ZB4000 17211899000 17212ZB4003 17212ZB4003 17212Z5R000 17220ZB4003 17222ZB4000 17231899000 17235899000 17236899000 17252899000 17367413690 9405005000 9405006000 17232898000 90634ZL8H00 PART NAME QTY. REMARKS TUBE BREATHER 1 ELEMENT, AIR CLEANER 1 SEPARATOR, AIR CLEANER 1 SEPARATOR, AIR CLEANER.............................1................USE UP TO S/N 119603 SEPARATOR, AIR CLEANER...................
honda gx240k1/u1edn2 engine — FLYWHEEL assy. page 66 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — FLYWHEEL assy. NO. 1 2 3 4♦ 4♦ 4◊ 5 PART NO. 19511ZE2000 28451ZE2W01 31100ZE2812 90201ZE3790 90201ZE3V00 90201ZE3V00 90741ZE2000 PART NAME QTY. REMARKS FAN, COOLING 1 PULLEY, STARTER 1 FLYWHEEL COMP. 1 NUT, SPECIAL, 16MM........................................1................USE UP TO S/N 3467138 NUT, SPECIAL, 16MM........................................1................USE FROM S/N 3467139 NUT, SPECIAL, 16MM 1 KEY, SPECIAL WOODRUFF 1 ♦GX240K1EDN2: Model GAC3.
honda gx240k1/u1edn2 engine — IGNITION COIL assy. page 68 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — IGNITION COIL assy. NO. 1♦ 1◊ 1◊ 2 3 4 5 6 7 8 9 PART NO. 30500ZE2023 30500ZF6W02 30500ZF6W03 30700ZE7013 36103ZE1000 31510ZE3003 31511ZE2000 31512ZE2000 36101ZE2701 90013883000 90015883000 PART NAME QTY. REMARKS COIL ASSY., IGNITION 1 COIL ASSY., IGNITION.......................................1................USE UP TO S/N 1167470 COIL ASSY., IGNITION.......................................1................USE FROM S/N 1167471 CAP ASSY.
honda gx240k1/u1edn2 engine — GOV. CONTROL assy. page 70 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — GOV. CONTROL assy. NO. 1 2 3 4 5 6# 7 8 9# 10 PART NO. 16550ZE2700 16555ZE2000 16561ZE2000 16562ZE2700 16570ZE2701 16584883300 90013883000 90015ZE5010 93600050350A 9405006000 PART NAME QTY. REMARKS ARM, GOVERNOR 1 ROD, GOVERNOR 1 SPRING, GOVERNOR 1 SPRING, THROTTLE RETURN 1 CONTROL ASSY.................................................1................INCLUDES ITEMS W.
honda gx240k1/u1edn2 engine — AUTO THROTTLE assy. page 72 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — AUTO THROTTLE assy. NO. 1# 2# 3♦ 3◊ 4# 5# 6♦# 6◊ # 7 8% 9# 10# PART NO. 16252ZA1000 16268893000 16270ZB4000 16270ZB4010 16271ZB4000 16273ZB4000 36160ZB4003 36160ZB4013 90013883000 91502ZB4701 93500050080A 9454004018 PART NAME QTY. REMARKS CAP, CHOKE LEVER 1 SPRING, CHOKE RETURN 1 AUTO THROTTLE ASSY.....................................1................INCLUDES ITEMS W/# AUTO THROTTLE ASSY.....................................1................
honda gx240k1/u1edn2 engine — FUEL COCK assy. page 74 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — FUEL COCK assy. NO. 1# 2 3# 4#% 5# 6# 7 8 9♦ 9◊ 9◊ PART NO. 16173001004 16950ZB4015 16952ZB4005 16958397771 16959471831 16967GA6671 90854ZB2000 950014519040 9500202080 9500202080 950024080008 PART NAME QTY. REMARKS PACKING, FUEL STRAINER CUP 1 COCK ASSY., FUEL...........................................1................INCLUDES ITEMS W/# SCREEN, FUEL STRAINER...............................1................
honda gx240k1/u1edn2 engine — DECAL assy. page 76 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — DECAL assy. NO. 1 2♦ 2◊ 2◊ 3♦ 3♦ 3◊ 3◊ 4 5◊ 5◊ 5◊ 5◊ PART NO. 87533ZC0630 87528898620 87528ZH7000 87528898620 87521ZE2W01 87521ZE2W02 87521ZE2W03 87521ZE2W04 87594ZB4A00 87516ZH7000 87516ZH7010 87516ZH7800 87519ZH7801 PART NAME QTY. REMARKS DECAL, AIR CLEANER 1 DECAL, CHOKE 1 DECAL, CHOKE (GRAY)....................................1................USE UP TO S/N 1028751 DECAL, CHOKE.................................................1................
honda gx240k1/u1edn2 engine — TOOL KIT page 78 — gac3.6hz 60 hz gENERATOR• operation and parts manual — rev.
honda gx240k1/u1edn2 engine — TOOL KIT NO. 1 2# 3# 4# 5# 6# PART NO. 89000ZE1000 89218ZE1000 89219805000 9900110120 9900114170 9900802300 PART NAME QTY. REMARKS TOOL KIT............................................................1................INCLUDES ITEMS W/# WRENCH COMP. (SPARK PLUG) 1 HANDLE, BOX WRENCH 1 SAPNNER, 10X12 1 SAPNNER, 14X17 1 BAG TOOL 1 gac3.6hz 60 hz GENERATOR • operation and parts manual — rev.
Terms and Conditions of Sale — Parts paYmeNT TeRms 5. Parts must be in new and resalable condition, in the original Multiquip package (if any), and with Multiquip part numbers clearly marked. 6. The following items are not returnable: Multiquip reserves the right to quote and sell direct to Government agencies, and to Original Equipment Manufacturer accounts who use our products as integral parts of their own products. a. special eXpediTiNg seRvice Terms of payment for parts are net 30 days.
notes gac3.6hz 60 hz GENERATOR • operation and parts manual — rev.
Operation and Parts Manual HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING UNITED STATES Multiquip Corporate Office 18910 Wilmington Ave. Carson, CA 90746 Contact: mq@multiquip.com MQ Parts Department Tel. (800) 421-1244 Fax (800) 537-3927 Mayco Parts 800-427-1244 310-537-3700 Fax: 800-672-7877 Fax: 310-637-3284 Warranty Department 800-306-2926 310-537-3700 Fax: 800-672-7877 Fax: 310-637-3284 Service Department 800-421-1244, Ext. 279 310-537-3700, Ext.
