Product Manual
PAGE 48 — MQ62TK SERIES TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #0 (01/30/18)
NAMEPLATE AND DECALS ASSY.
MODEL
SERIAL NO.
DIESEL FUEL
M90050000
DIESEL FUEL can cause
fire or explosion.
Stop engine before fueling
Keep cigarettes, sparks
and flame away.
WARNING
B90450000
To pr event uncoupling from the tow
vehicl e perfom the following:
1.
defective parts.
2. CHECK that BALL
load rating
is the
same as or greater than the COUPLER
load rating .
3. CHECK that the BALL and COUPLER
are the same size.
4. Open COUPLER CLAMP and place onto BALL .
5. Close COUPLER CLAMP .
6. Lift COUPLER upwards to test that it will not
separate from BALL .
7. LOCK coupler clamp with pin or lock.
CHECK BALL and COUPLER for worn or
AL WAYS use safety chains. Safety chains
keep unit attached to tow vehicle in the event
of coupler malfunction.
Perfom the following when attaching safety chains:
1. CROSS chains underneath coupler.
2. ALLOW for slack for trailer to turn.
3. ATT ACH safety chain hooks securely
to tow vehicle frame.
Lights can prevent trailer from being hit by other vehicles.
Perfom the following when connecting the trailer lights:
CONNECTED
DISCONNECTED
LIGHT PLUG
1. CONNECT trailer and tow vehicle light plugs.
2. CHECK all lights: tail, turn, signal and brake.
Make sure all lights are working properly.
3. DO NOT T OW if lights are not working correctly.
LUG NUTS
TIGHT?
TIRE AND
WHEEL OK?
Tire, wheel or lug nut failure can cause loss of control.
Perform the following before towing:
1. CHECK tire pressure and thread.
2. CHECK tires and wheels for damage.
3. CHECK lug nuts for tightness.
4. For new and remounted wheels re-tighten
lug nuts at first 10, 25 and 50 miles of driving.
5. CHECK and test brakes on both vehicles.
6. INSPECT and grease trailer bearings every
1000 miles or once a year.
7. Trailer to be level when towing. Maximum
towing speed not to exceed 55 MPH (88 KM/H).
P/N 34627
CLAMP
CLOSED
LIFT COUPLER
UPWARD TO TEST.
SECURE CLAMP
WITH PIN OR
PADLOCK
CLAMP
OPEN
BALL
TOW VEHICLE
FRAME
HOOK
SLACK
CROSS
CHAINS
WARNING
WARNINGWARNING WARNING
M
A
N
U
F
A
C
T
U
R
E
I
N
C
O
M
P
L
I
A
N
C
E
W
I
T
H
N
A
T
M
G
U
I
D
E
L
I
N
E
S
NATM
National Association
of Trailer Manufacturers
National Association
of Trailer Manufacturers