Product Manual

PAGE 22 — MQ62TK SERIES TRASH PUMP • OPERATION AND PARTS MANUAL — REV. #0 (01/30/18)
ENGINE COMPONENTS
The engine (Figure 5) must be checked for proper
lubrication and filled with fuel prior to operation. Refer
to the manufacturer’s engine manual for operation and
maintenance information.
1. Radiator — Coolant capacity is 1.25 gallons
(4.75 liters). Use recommended coolant only.
2. V-Belt — ALWAYS make sure the V-belt is properly
tensioned. A loose or defective V-belt can adversely
affect engine performance.
3. Lift Loops (2) — When lifting of the engine is required,
attach a strap or chain of adequate lifting capacity to
these lifting points.
4. Muffler — Reduces noise and emissions.
5. Oil Filter — Spin-on type, filters oil contaminants.
6. Engine Nameplate — Provides engine model
identification and information.
7. Oil Drain Bolts (2) — Remove to drain oil from the
crankcase. ALWAYS dispose of used oil and oil filters
in an environmentally safe manner. DO NOT allow used
oil to drain onto the ground or into a water runoff drain.
WARNING
Engine components generate extreme
heat. To prevent burns, DO NOT touch
these areas while the engine is running
or immediately after operating. NEVER
operate the engine with the muffler removed.
Figure 5. Kohler Engine Components
1
2
3
4
3
5
6
7
8
7
9
10
11
12
13
14
15
16
17
8. Oil Pan — Holds a maximum of 3.2 quarts (3.0 liters)
of motor oil.
9. Oil Dipstick — Remove to determine engine oil level.
10. Alternator — Provides power to the engine 12-volt
electrical system. Replace with manufacturer's
recommended type alternator only.
11. Fan Guard — Protects personnel from rotating fan
blades.
12. Oil Pressure Sensor — Monitors engine oil pressure.
The engine will shut down when oil pressure is low.
13. Glow Plugs (4) — Glow plugs help start the engine
in cold weather conditions. Allow the glow plugs to
preheat before starting the engine in cold weather.
14. Oil Filler Cap — Remove to add engine oil as
recommended in Table 2.
15. Air Cleaner — Prevents dirt and debris from entering
the fuel system. Open the air cleaner cover to access
the filter element.
16. Starter — Starts the engine when the ignition key is
turned to the START position.
17. Fuel Filter — Filters fuel contaminants.