Operation and Parts Manual MODEL ga6Hr/ga6Hrs portable generatorS (HONDA GX340RT2EDN2/GX340RT2EDE2 GASOLINE ENGINES) Revision #0 (08/12/14) To find the latest revision of this publication, visit our website at: www.multiquip.com THIS MANUAL MUST ACCOMPANY THE EQUIPMENT AT ALL TIMES.
PROPOSITION 65/START FIRES WARNINGS Operation of this equipment may create sparks that can start fires around dry vegetation. A spark arrestor may be required. The operator should contact local fire agencies for laws or regulations relating to fire prevention requirements. page 2 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
Table of Contents GA6HR/GA6HRS 60 Hz Portable Generator Proposition 65/Start Fires Warnings......................... 2 Table Of Contents..................................................... 3 Nameplate/Safety Information.................................. 4 Parts Ordering Procedures....................................... 5 Safety Information.................................................... 6 Safety Information............................................... 7-11 Specifications (Generator)................
nameplate/safety information nAMEPLATE AND sAFETY lABELS NOTICE Safety labels are attached to the generator as shown in Figure 1. Keep these safety labels clean at all times. When the safety labels become worn or damaged, contact your nearest dealer or the Multiquip Parts Dept. For safety label part numbers, reference the parts section of this manual.. MODEL SERIAL NO.
www.multiquip.com parts ordering procedures Ordering parts has never been easier! Choose from three easy options: Order via internet (dealers Only): Best deal! Effective: January 1st, 2006 If you have an MQ Account, to obtain a Username and Password, E-mail us at: parts@multiquip. com. Order parts on-line using Multiquip’s SmartEquip website! ■ View Parts Diagrams ■ Order Parts ■ Print Specification Information To obtain an MQ Account, contact your District Sales Manager for more information.
Safety Information Do not operate or service the equipment before reading the entire manual. Safety precautions should be followed at all times when operating this equipment. Failure to read and understand the safety messages and operating instructions could result in injury to yourself and others. Potential hazards associated with the operation of this equipment will be referenced with hazard symbols which may appear throughout this manual in conjunction with safety messages.
Safety Information gENERAl sAFETY CAuTiON NEvER operate this equipment without proper protective clothing, shatterproof glasses, respiratory protection, hearing protection, steel-toed boots and other protective devices required by the job or city and state regulations. AlWAYs know the location of the nearest phone or keep a phone on the job site. Also, know the phone numbers of the nearest ambulance, doctor and fire department. This information will be invaluable in the case of an emergency.
Safety Information ENgiNE sAFETY dANgER The engine fuel exhaust gases contain poisonous carbon monoxide. This gas is colorless and odorless, and can cause death if inhaled. The engine of this equipment requires an adequate free flow of cooling air. NEvER operate this equipment in any enclosed or narrow area where free flow of the air is restricted. If the air flow is restricted it will cause injury to people and property and serious damage to the equipment or engine.
Safety Information NEvER use fuel as a cleaning agent. dO NOT smoke around or near the equipment. Fire or explosion could result from fuel vapors or if fuel is spilled on a hot engine. ElECTRiCAl sAFETY dANgER Make sure power cables are securely connected to the generator’s output receptacles. Incorrect connections may cause electrical shock and damage to the generator. NOTICE AlWAYs make certain that proper power or extension cord has been selected for the job.
Safety Information If the battery liquid (dilute sulfuric acid) comes into contact with clothing or skin, rinse skin or clothing immediately with plenty of water. ENviRONmENTAl sAFETY/dECOmmissiONiNg If the battery liquid (dilute sulfuric acid) comes into contact with eyes, rinse eyes immediately with plenty of water and contact the nearest doctor or hospital to seek medical attention. Decommissioning is a controlled process used to safely retire a piece of equipment that is no longer serviceable.
Safety Information EmissiONs iNFORmATiON NOTICE The gasoline engine used in this equipment has been designed to reduce harmful levels of carbon monoxide (CO), hydrocarbons (HC) and nitrogen oxides (NOx) contained in gasoline exhaust emissions. This engine has been certified to meet US EPA Evaporative emissions requirements in the installed configuration.
SPECIFICATIONS (gENERATOR) Table 1. Specifications (Generator) Model GA6HR GA6HRS Type Brushless Revolving Field Type Excitation Solid State, Statically Excited System AC Generator Speed 3,600 RPM Cooling System Self-Ventilation Fuel Capacity 5 gallons (19 liters) Continuous Power Output 5.0 kW Max Power Output 6.0 kW Rated Voltage 120/240V 50.0/41.6 amps 60 Hz AC Power Current Max/Continuous (120V) Source Current Max/Continuous (240V) 25.0/20.
SPECIFICATIONS (engine) Table 2. Specifications (Engine) Model HONDA GX340RT2EDN2 HONDA GX340RT2EDE2 Air-cooled 4 stroke, Single Cylinder, OHV, Horizontal Shaft Type Gasoline Engine 3.46 in. X 2.52 in. Bore X Stroke (88 mm x 64 mm.) Displacement 23.70 cu-in (389 cm3) Engine Max Output 11.0 H.P./3600 R.P.M. Fuel Unleaded Automobile Gasoline Lube Oil Capacity 1.16 quarts (1.
dimensions C GA-6HR ON 0N V 120 120 P O W E R F A U L T OFF AC VOLTMETER IDLE CONTROL OFF OPERATION SWITCH 120V MANUAL RESET AC CIRCUIT BREAKER GFCI PROTECTED QUARTZ 120V 20A 120V 120V 20A 20A A 120V 240/120V FULL POWER SWITCH 30A 120/240V 30A B D Figure 2. Dimensions Table 3. Generator Dimensions REFERENCE LETTER DESCRIPTION DIMENSIONS: IN. (MM) A HEIGHT (LIFTING BALE) 34.1 (865) B HEIGHT (FRAME) 29.7 (755) C LENGTH 29.9 (760) D WIDTH 30.
note GA6HR/6HRS 60 hz GENERATOR • operation and parts manual — rev.
installation Connecting the Ground The nut and ground terminal on the generator should always be used to connect the generator to a suitable ground. The ground cable should be #8 size wire (aluminum) minimum. If copper wire is used, #10 size wire minimum should be used At the generator, connect the terminal of the ground cable between the lock washer and the nut (Figure 3) and tighten the nut fully. Connect the other end of the ground cable to a suitable earth ground (ground rod).
installation Outdoor Installation Generator Grounding If possible install the generator in a area that is free of debris, bystanders, and overhead obstructions. Make sure the generator is on secure level ground so that it cannot slide or shift around. To guard against electrical shock and possible damage to the equipment, it is important to provide a good EARTH ground. The installation site must be relatively free from moisture and dust.
general information FAMILIARIZATION Generator The Multiquip GA6HR/GA6HRS generator is designed as a portable dual purpose power source for 60 Hz (single phase) lighting facilities, power tools, submersible pumps and other industrial and construction machinery. DANGER Before connecting this generator to any building’s electrical system, a licensed electrician must install an isolation (transfer) switch. Serious injury or death may result without this transfer switch.
components (generator) 3 1 2 4 5 6 7 8 GA-6HR 120 P O W E R F A U L T F A U L T P O W E R OFF OPERATION SWITCH 120V 20A 120V MANUAL RESET AC CIRCUIT BREAKER GFCI PROTECTED 120V 120V 20A 20A OFF IDLE IDLE AC VOLTMETER CONTROL CONTROL 120V MANUAL RESET QUARTZ 0N V 120 120 OFF IDLE AC VOLTMETER CONTROL 8 GA-6HRS ON 0N V 120 120V 30A AC CIRCUIT BREAKER GFCI PROTECTED QUARTZ 240/120V FULL POWER SWITCH 120V 120/240V 20A 120V 120V 20A 20A 30A 120V 30A OPERATION SWITCH 240/120V
components (generator) GA-6HR GA-6HRS ON 0N V 120 120 P O W E R F A U L T P O W E R OFF OPERATION SWITCH F A U L T 120V 16 MANUAL RESET AC CIRCUIT BREAKER GFCI PROTECTED QUARTZ 120V 120V 120V 20A 20A 120V 30A 240/120V FULL POWER SWITCH OFF IDLE IDLE AC VOLTMETER CONTROL CONTROL 120V 20A 0N V 120 120 OFF IDLE AC VOLTMETER CONTROL 120/240V 16 MANUAL RESET AC CIRCUIT BREAKER GFCI PROTECTED QUARTZ 120V 20A 120V 120V 20A 20A 30A 120V OPERATION SWITCH 240/120V FULL POWER SWITC
components (generator) 19 17 24 25 18 6kW 23 26 20 27 21 28 22 30 29 Figure 8. Generator Components (Continued) 17. Fuel Gauge – This gauge is located on top of the fuel tank. Read this gauge to determine when fuel is low. 18. Fuel Tank Cap – Remove this cap to add unleaded gasoline to the fuel tank. Replenish with clean unleaded gasoline. Make sure cap is tightened securely. DO NOT over fill. 19. Fuel Tank – Capacity is 5 gallons (19 liters). Fill with unleaded gasoline. 20.
INSPECTION/SETUP General Inspection Prior to Operation Ground Power Tools When using power tools or electrical equipment requiring AC power from the generator, make sure power tool cord has a ground pin or is double insulated as shown in Figure 9. NOTICE Double-insulated power tools and small appliances have specially insulated housings that eliminate the need for a ground pin.
INSPECTION/setup Before Starting NOTICE ALWAYS place the main circuit breaker in the OFF position prior to starting the engine. 3. Insert and remove the dipstick without screwing it into the filler neck. Check the oil level shown on the dipstick. 4. If the oil level is low (Figure 11), fill to the edge of the oil filler hole with the recommended oil type (Table 5). Maximum oil capacity is 1.16 quarts (1.1 liters). 1. Read safety instructions at the beginning of manual. 2.
operation This section is intended to assist the operator with the initial start-up of the portable generator. It is extremely important that this section be read carefully before attempting to use the generator in the field. Before Starting the Engine NOTICE Both model generators are equipped with a GFCI sensing module. The purpose of this module is to sense a ground fault during operation of the generator and shut down the generator once the ground fault has been detected.
operation 6. Press the generator's pushbutton start switch (Figure 18) and listen for the engine to start. ON OFF Figure 18. Start Switch (GA6HRS Only) 7. If the engine has started, slowly return the choke lever (Figure 15) to the OPEN position. If the engine has not started repeat steps 1 through 6. Figure 20. Idle Control switch (ON) 10. Place main circuit breaker (Figure 21) in the ON position. ON 8. Before the generator is placed into operation, run the engine for 3-5 minutes.
operation GFCI L14-30R G 120VAC X 240VAC 120VAC W L14-30R 120VAC W 120VAC L5-30R X X G G W Y Y 120V 120 VAC OFF 240 VAC V~ V 300 mV OFF V~ V V 120 300 mV A A~ V 240 V A A~ V COM COM Figure 23. 120V Twist-Lock/GFCI Receptacles 13. Place the full power switch (Figure 24) in the 240/120V position (down). DOWN 240/120V Figure 24. Full Power Switch 240/120V Position (Down) Figure 25.
shutdown Stopping the Engine (Normal Shutdown) 1. Place main circuit breaker (Figure 26) in the OFF position. 5. Place engine fuel valve lever (Figure 29) in the OFF position. ON OFF Figure 26. Main Circuit Breaker (OFF) 2. Place idle control switch (Figure 27) in the OFF position. Figure 29. Engine Fuel Valve Lever (OFF) 6. Remove all loads from the generator. Emergency Shutdown 1. Place operation switch (Figure 30) in the OFF position. ON GA6HRS OFF Figure 27. Idle Control switch (OFF) 3.
preparation for long term storage Generator Storage For storage of the generating set for over 30 days, the following is required: Drain the fuel tank completely, or add STA-BIL to the fuel. Run the engine until the gasoline in the carburetor is completely consumed. Completely drain the oil from the crankcase and refill with fresh oil. Remove the spark plug, pour 2 or 3 cc of SAE 30 oil into the cylinder and crank slowly to distribute the oil.
maintenance Use Table 6 as a general maintenance guideline when servicing your engine. For more detail engine maintenance information, refer to the engine owner's manual supplied with your engine. Table 6. Engine Maintenance Schedule DESCRIPTION (3) Engine Oil Air Cleaner Charcoal Canister (4) All Nuts & Bolts Spark Plug Cooling Fins Spark Arrester Fuel Tank Fuel Strainer Idle Speed Valve Clearance Fuel lines OPERATION CHECK CHANGE CHECK CHANGE FIRST EVERY 3 BEFORE MONTH OR MONTHS 10 HRS. OR 25 HRS.
maintenance Maintenance Spark Plug Perform the scheduled maintenance procedures as defined by Table 6 on the previous page: 1. Remove and clean the spark plug (Figure 32), then adjust the spark gap to 0.024 ~0.028 inch (0.6~0.7 mm). This unit has electronic ignition, which requires no adjustments. Daily Thoroughly remove dirt and oil from the engine and control area. Clean or replace the air cleaner elements as necessary. Check and retighten all fasteners as necessary.
maintenance Engine Air Cleaner spark arrester cleaning DANGER Clean the spark arrester every 6 months or 100 hours. DO NOT use gasoline as a cleaning solvent, the possibility exists of fire or explosion which can cause damage to the equipment and severe bodily harm or even DEATH! 1. Remove the muffler protector retaining bolts (Figure 36), then remove muffler protector. 2. Next, remove tapping screw that secures spark arrestor to muffler, then remove spark arrester. 1.
maintenance battery (ga6Hrs) NOTICE This unit is of negative ground DO NOT connect in reverse. Always maintain battery fluid level between the specified marks. Battery life will be shortened, if the fluid levels are not properly maintained. Add only distilled water when replenishment is necessary. Check to see whether the battery cables are loose. Poor contact may result in poor starting or malfunctions. Always keep the terminals firmly tightened.
maintenance 3. On the GFCI module (Figure 40), verify that the green POWER LED is ON. 240 V 120 F A U L T P O W E R Figure 43. AC Voltmeter (Zero Volts) 8. To restore power, press the RESET button (Figure 44) on the GFCI module and verify that the red FAULT LED turns OFF and the green POWER LED should turn ON GREEN POWER LED MANUAL RESET Figure 40. GFCI Module (Green LED ON) 4. Also verify that the AC voltmeter is registering a voltage reading as indicated by Figure 45. P O W E R 5.
generator wiring diagram (ga6hR) Figure 46. Generator Wiring Diagram (GA6HR) page 34 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
generator wiring digram (ga6hRS) Figure 47. Generator Wiring Diagram (GA6HRS) GA6HR/6HRS 60 hz GENERATOR • operation and parts manual — rev.
troubleshooting (ENGINE) Troubleshooting (Engine) symptom possible problem Spark plug bridging? Check gap, insulation or replace spark plug. Carbon deposit on spark plug? Clean or replace spark plug. Short circuit due to deficient spark plug insulation? Check spark plug insulation, replace if worn. Improper spark plug gap? Set to proper gap. Fuel reaching carburetor? Check fuel line. Water in fuel tank? Flush or replace fuel tank. Fuel filter clogged? Replace fuel filter.
troubleshooting (ENGINE) Troubleshooting (Engine) - continued symptom Weak in power, compression is proper and does not misfire. Weak in power, compression is proper but misfires. Engine overheats. Rotational speed fluctuates. Recoil starter malfunctions. (if applicable) Starter malfunctions. possible problem Clean or replace air cleaner. Improper level in carburetor? Check float adjustment, rebuild carburetor. Defective spark plug? Clean or replace spark plug.
troubleshooting (GENERATOR) Troubleshooting (generator ) symptom Low voltage Low voltage. Engine speed normal 3650 RPM (unloaded), 2500 RPM (idle) possible problem Engine speed too low? AC voltmeter not working? Control box internal wiring malfunction? Defective ignition coil? Rotor winding malfunction? Stator winding malfunction? Leakage breaker malfunction? Full power switch malfunction? Voltage output too high. Voltage output too high.
notes GA6HR/6HRS 60 hz GENERATOR • operation and parts manual — rev.
Explanation of Code in Remarks Column The following section explains the different symbols and remarks used in the Parts section of this manual. Use the help numbers found on the back page of the manual if there are any questions. NOTICE The contents and part numbers listed in the parts section are subject to change without notice. Multiquip does not guarantee the availability of the parts listed. sAmplE pARTs lisT NO. 1 2% 2% 3 4 pART NO. pART NAmE QTY. REmARks 12345 BOLT .....................1 .....
Suggested Spare Parts GA6HR/GA6HRS portable 60 hZ generator with HONDAGX340RT2EDN2/GX340RT2EDE2 gasoline engines 1 to 3 units Qty. P/N Description 1............0430430120...........CAP FUEL TANK 1............0641360030...........FILTER FUEL 3............16950ZB4015........fuel strainer 2............3015419604...........rubber suspension 2............1665419004...........rubber suspension 3............9807955876...........SPARK PLUG 1............35480ZF6003........SWITCH ASSY., OIL ALERT 2............
GA6HR/GA6HRS— nameplate and decalS ASSY. GA6HRS Exhaust contains carbon monoxide, a poison gas you cannot see or smell. Les gaz d’ échappement contiennent du monoxyde de carbon, un gaz toxique invisible et inodore. Before starting check the oil and fuel level. Switch the circuit breaker to the “OFF” position. Open the fuel valve. Pull the choke knob. Turn the operation switch to the “ON” position and push the start button to start the engine. 6. After the engine starts, gradually push in the choke knob.
GA6HR/GA6HRS— nameplate and decals ASSY. NO. PART NO. 1 A5551000004 2 A9521200104 3 A9504000014 4 5 0800628504 6 920214100 7 D9531100104 8 A9511100103 9 A3551000104 10 1980680004 11 0800696804 12 87533ZC0630 13 A5561001003 14 0800689404 15 0800689504 16 87528898620 17 A5511202802 18 A5511203002 PART NAME QTY. REMARKS DECAL: OPERATING INSTR., GA6HR .............1................A92120010 DECAL: OPERATING INSTR., GA6HRS............1................A55100000 DECAL: WARNING DANGEROUS GAS ...........1........
GA6HR/GA6HRS — GENERATOR ASSY. page 44 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
GA6HR/GA6HRS — GENERATOR ASSY. NO. PART NO. 1 7901002403 1-1$ 1-2$ 0601823213 1-2A$ 0601822638 1-3$ 0071706304 2 7901017004 3 0801086104 4 A5135000103 5 7901315502 6 0013608020 7 0040008000 8 7871315022D 9 7875021523 10 7871331003 11 7901316004 12 7871329514 13 0601851760 PART NAME QTY. REMARKS ROTOR ASSY.....................................................1................INCLUDES ITEMS W/$ FIELD ASSY. 1 RECTIFIER 2 SURGE ABSORBER .........................................2................
GA6HR — CONTROL BOX ASSY. page 46 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
GA6HR — CONTROL BOX ASSY. NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 PART NO. A3214000403 0601850102 0601823204 Y0021003012 0601823853 0021004010 OEMAA8 A3224000703 0601806819 0601814065 0601811092 0601811031 0601812529 0021004010 OEMAA8 0601830737 0601831620 0601831620 A3262800004 011106015 0017105010 0601872301 0021003005 0601829301 Y0601815779 0021004020 OEMAA8 Y0027004025 OEMAA8 58042 0040004000 Y0601800699 Y0021003012 0207003000 PART NAME QTY.
GA6HRS — CONTROL BOX ASSY. page 48 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
GA6HRS — CONTROL BOX ASSY. NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 PART NO. A3214000403 0601850102 0601823204 Y0021003012 0601823853 0021004010 OEMAA8 A3224000703 0601806819 0601814065 0601811092 0601811031 0601812529 0021004010 OEMAA8 0601830737 0601831620 0601831620 A3262800004 011106015 0017105010 0601872301 0021003005 0601829301 Y0601815779 0021004020 OEMAA8 Y0027004025 OEMAA8 58042 0040004000 Y0601800699 Y0021003012 0207003000 PART NAME QTY.
GA6Hr/GA6Hrs — PIPE FRAME ASSY. page 50 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
GA6Hr/GA6Hrs — PIPE FRAME ASSY. NO. 1 1A 2 3 4 5 6 7 8 9 10 11 12 13 14 15 15-1 16 17 18 19 20 21 22 23 24 25 26 27 28 29 30 31 32 33 34 35 36 37 38 39 40 41 42 43 44 45 PART NO.
GA6HRS — BATTERY ASSY. page 52 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
GA6HRS — BATTERY ASSY. NO. 36 37 38 39 40 41 42 42A 42B 43 PART NO. 0162212024 W7905458103 A5344200004 0037806000 0040006000 952404470 A5347000504 D1343200604 Y0602220643 A5347000004 PART NAME QTY. REMARKS BATTERY, 201-149 12N24-3 1 BATTERY BAND 1 BATTERY BOLT 2 WING NUT 2 WASHER, SPRING 2 WASHER, FLAT .................................................2................
GA6Hr/GA6Hrs — MUFFLER ASSY. page 54 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
GA6HR/GA6HRS — MUFFLER ASSY. NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 PART NO. 7912310003 18320ZC2000 18325ZB4000 18329ZB4000 18355ZB4630 90002ZE2U91 0105050616 18333ZB4801 957010802000 7905461004 011008020 7905460004 011208025 020108060 011008020 7905469004 011206020 020108060 0105050616 PART NAME QTY. REMARKS MUFFLER 1 PROTECTOR 1 PROTECTOR 1 SEAL 2 ARRESTOR, SPARK 1 TAPPING SCREW 1 HEX. HEAD BOLT ..............................................5................
GA6HR/GA6HRS — wheel kit ASSY. page 56 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
GA6HR/GA6HRS — wheel kit ASSY. NO. 1 2 3 4 5 6 7 8 9 10 11 12 13 14 15 16 17 18 19 PART NO. A3417400303 Y0605802053 Y0080000020 A3417400404 011008020 L0120236304 011008020 W0805003103 A3417400704 A3417400804 A3417401304 A3417401404 0601851116 0012308020 0010108025 0207608000 0401450080 A3417400904 011106015 PART NAME QTY. REMARKS AXLE 1 TIRE ASSY. 2 SNAP RING 2 BRACKET 2 HEX. HEAD BOLT ..............................................8................REPLACES P/N 0016908020 BRACKET, BRAKE SHAFT 4 HEX.
HONDA GX340RT2EDE2/EDN2 — AIR CLEANER ASSY. page 58 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — AIR CLEANER ASSY. NO. 1 2 3 4 5 6 7 8 9 10 11 13 14 15 PART NO. 15721Z23H60 17211899000 17220Z23S30 17222Z23H60 17223Z23000 17223Z23S30 17229Z23H60 17231Z23H60 17233Z23H60 17238ZE7710 90005ZM3000 90854ZB3000 9405006000 957010603208 PART NAME TUBE, BREATHER ELEMENT, AIR CLEANER CASE COMP., AIR CLEANER STAY, AIR CLEANER SPRING, AIR CLEANER CASE LID BASE COMP., AIR CLEANER SEAL, AIR CLEANER CASE COVER, AIR CLEANER SEAL, AIR CLEANER COVER COLLAR, AIR CLEANER BOLT, FLANGE.
HONDA GX340RT2EDE2/EDN2 — CAMSHAFT ASSY. page 60 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — CAMSHAFT ASSY. NO. 1 3 4 5 6 8 9 10 11 12 13 15 16 17 19 PART NO. 12209ZE8003 14410Z1C000 14431ZE2010 14441ZE2000 14451ZE1013 14711Z5T000 14721Z5T000 14751Z1C000 14771Z8S000 14771Z8S000 14775ZE2010 14791Z1D000 90012ZE0010 90206ZE1000 14100Z5K910 PART NAME SEAL, VALVE STEM ROD, PUSH ARM, VALVE ROCKER LIFTER, VALVE PIVOT, ROCKER ARM VALVE, IN. VALVE, EX. SPRING, VALVE RETAINER, IN. VALVE SPRING RETAINER, EX.
HONDA GX340RT2EDE2/EDN2 — CARBURETOR ASSY. page 62 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — CARBURETOR ASSY. NO. 1$+♦♣@ 2$ 3$ 4$% 5$ 6$%@ 7$% 8 9$ 10$ 11$ 12$ 14 15 17$ 18 19# 20# 21# 22# 23# 24# 25 26# 27# 28# 29# 30 31# 32 33# 34# 35# 36# 37 39# 40$ 41 42# 43# 44# 45# 47 49 50 51$ 51$ 52$ 54 55 PART NO.
HONDA GX340RT2EDE2/EDN2 — CONTROL ASSY. page 64 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — CONTROL ASSY. NO. 1 3 4 5 8 16% 20 21 28% 30 PART NO. 16550ZE3700 16555ZE3000 16561ZK6D70 16562ZE3700 16500Z5T880 16584883300 90013883000 90015Z5T000 93500050350A 9405006000 PART NAME QTY. REMARKS ARM COMP., GOVERNOR 1 ROD, GOVERNOR 1 SPRING, GOVERNOR 1 SPRING, THROTTLE RETURN 1 CONTROL ASSY. ..............................................1................
HONDA GX340RT2EDE2/EDN2 — CRANKCASE COVER ASSY. page 66 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — CRANKCASE COVER ASSY. NO. 1 2 3 4 5@+ 6 7%# 8%# 9%# 10% 11% 12 13% 14% 15 16% 17% PART NO. 11300Z1C000 11381Z5T000 15600Z0T820 15600Z1C000 15625Z0T800 16510ZE3000 16511ZE8000 16512ZE3000 16513ZE2000 16531Z0A000 90602ZE1000 90701HC4000 91201Z1C003 9410106800 957010804000 961006202000 961006207000 PART NAME QTY. REMARKS COVER ASSY., CRANKCASE ...........................1................INCLUDES ITEMS W/% PACKING, CRANKCASE COVER 1 CAP ASSY., OIL FILTER .............................
HONDA GX340RT2EDE2/EDN2 — CRANKSHAFT ASSY. page 68 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — CRANKSHAFT ASSY. NO. 7 11$ 12 PART NO. 13351ZE3010 91001ZF6013 13310ZF6D42 PART NAME QTY. REMARKS WEIGHT, BALANCER 1 BEARING, RADIAL BALL 1 CRANKSHAFT COMP. .......................................1................ INCLUDES ITEMS W/$ GA6HR/6HRS 60 hz GENERATOR • operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — CylINDER BARREL ASSY. page 70 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — CylINDER BARREL ASSY. NO. 1 1 2 3 6 7 8$# 9$# 10 11 12 13 14 15$# PART NO. 12000Z5T405 12000Z5T407 35480ZF6003 16541ZE3010 90131883000 90446KE1000 91201Z1C003 91203952771 91353671004 9405010000 9410912000 9425110000 957010601200 961006202000 PART NAME QTY. REMARKS BARREL ASSY., CYL., GX340RT2EDE2............1................INCLUDES ITEMS W/# BARREL ASSY., CYL., GX340RT2EDN2...........1................INCLUDES ITEMS W/$ SWITCH ASSY.
HONDA GX340R2EDE2/EDN2 — CylINDER HEAD ASSY. page 72 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340R2EDE2/EDN2 — CylINDER HEAD ASSY. NO. 1 2# 3# 4# 5 6 8 10 11 12 13 14 15 16 16 PART NO. 12210Z5T406 12204ZE2306 12205ZE2305 12216ZE2300 12251Z5T003 12310ZE2020 12391ZE2020 90014Z5T000 90042ZK6D70 92900080320E 90441ZE2010 9430112200 957011008000 9807955876 9807955855 PART NAME QTY. REMARKS HEAD COMP., CYLINDER .................................1................INCLUDES ITEMS W/# GUIDE, IN. VALVE (OVER SIZE) 1 GUIDE, EX. VALVE (OVER SIZE) 1 CLIP, VALVE GUIDE 1 GASKET, CYL.
HONDA GX340RT2EDE2/EDN2 — FAN COVER ASSY. page 74 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — FAN COVER ASSY. NO. 2 3 6 7 9 PART NO. 19610Z5T800ZC 19631Z5T000 81329567020 90013883000 90654SA4003 PART NAME COVER, FAN *NH1* (BLACK) SHROUD GROMMET, DRAIN HOLE BOLT, FLANGE 6X12 (CT200) CLIP, WIRE HARNESS 6MM (WHITE) QTY. 1 1 1 6 2 REMARKS GA6HR/6HRS 60 hz GENERATOR • operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — FLYWHEEL ASSY. page 76 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — FLYWHEEL ASSY. NO. 1 3 8 9 12 12 PART NO. 19511ZE3000 28451ZE3W01 90201ZE3V00 90741ZE2000 31100Z5T820 31100Z5T810 PART NAME QTY. FAN, COOLING 1 PULLEY, STARTER 1 NUT, SPECIAL 16MM 1 KEY, SPECIAL WOODRUFF 25X18 1 FLYWHEEL COMP. (LAMP), GX340RT2EDE2 1 FLYWHEEL COMP. (LAMP), GX340RT2EDN2 1 REMARKS GA6HR/6HRS 60 hz GENERATOR • operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — IGNITION COIL ASSY. page 78 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — IGNITION COIL ASSY. NO. 1 2 4 5 6 12 13 14 15 21 PART NO. 30500Z5T003 30700Z1C811 31511ZE3000 31512ZE2000 31510ZE1811 90013883000 90012888000 90015883000 90684ZA0601 31510ZE3003 PART NAME COIL ASSY., IGNITION CAP ASSY., NOISE SUPPRESSOR CLAMPER, CORD GROMMET, CORD COIL ASSY., LAMP 12V, 25W BOLT, FLANGE 6X12 BOLT, FLANGE 6X40 BOLT, FLANGE 6X280 CLIP, HARNESS, GX340RT2EDN2 COIL ASSY., LAMP 12V, 125W QTY.
HONDA GX340RT2EDE2/EDN2 — PISTON ASSY. page 80 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — PISTON ASSY. NO. 1 1 1 1 2 2 2 2 3 4 4 5$% 6 PART NO. 13010Z5R004 13011Z5R004 13012Z5R004 13013Z5R004 13101Z5T800 13102Z5T800 13103Z5T800 13104Z5T800 13111Z5T000 13200Z1C000 13200Z1C305 90001ZE8000 90601ZE3000 PART NAME QTY. REMARKS RING SET, PISTON (STD) 1 RING SET, PISTON (0.25) 1 RING SET, PISTON (0.50) 1 RING SET, PISTON (0.75) 1 PISTON (STD) 1 PISTON (0.25) 1 PISTON (0.50) 1 PISTON (0.75) 1 PIN, PISTON 1 ROD ASSY., CONNEC. (STD)............................1................
HONDA GX340RT2EDE2/EDN2 — recoil starter ASSY. page 82 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — recoil starter ASSY. NO. 1 2% 3% 4% 5% 6% 7% 8% 10% 11% 12 13% 14% PART NO. 28400Z5T013ZB 28410ZE3W01ZB 28421ZE3W01 28422ZE2W01 28441ZE2W01 28442ZE2W01 28443ZE2W01 28444ZE2W01 28462ZV7003 90004ZE2W01 90008ZE2003 28461Z5T003 28463Z5T013 PART NAME QTY. REMARKS STARTER ASSY., RECOIL *NH1* .....................1................INCLUDES ITEMS W/% CASE COMP.
HONDA GX340RT2EDE2 — starter Motor ASSY. page 84 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2 — starter Motor ASSY. NO. 1$ 2$ 3$ 4 5$ 6$ 7$ 8$ 9$ 10$ 11$% 12$ 13$ 14$ 15$ 16$ 17$ 18$ 19$ 20 21$ PART NO. 31204ZA0003 31206ZE3003 31207ZE3003 31210ZE3023 31211ZE2003 31212ZE3003 31213ZE2003 31215ZE2003 31218ZE3003 31219ZE2003 31222ZE3791 31231ZE2003 31232ZE3003 31233ZE2003 90007ZE2003 90110ZE2003 91601ZE2003 938920503218 9407006080 957010803508 31219ZE3003 PART NAME QTY. REMARKS CONTACTOR ASSY. 1 ARMATURE COMP 1 CLUTCH COMP., OVERRUNNING ....................1................
HONDA GX340RT2EDE2/EDN2 — SOLENOID ASSY. page 86 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — SOLENOID ASSY. NO. 1 2 3 4 5 PART NO. 16268893000 17850ZD1E30 36160ZB4013 90013883000 93500050080A PART NAME SPRING, CHOKE RETURN LEVER COMP., THROTTLE SOLENOID ASSY. BOLT, FLANGE 6X12 (CT200) SCREW, PAN 5X8 QTY. 1 1 1 1 2 REMARKS GA6HR/6HRS 60 hz GENERATOR • operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — ENGINE DECALS ASSY. page 88 — GA6HR/GA6HRS 60 hz gENERATOR• operation and parts manual — rev.
HONDA GX340RT2EDE2/EDN2 — ENGINE DECALS ASSY. NO. 1 2 3 4 PART NO. 87533ZC0630 87528898620 87594ZB4A00 87521Z8T000 PART NAME DECAL: AIR CLEANER (ENGLISH) DECAL: CHOKE DECAL: OIL CAUTION EMBLEM (GX340) QTY. 1 1 1 1 REMARKS GA6HR/6HRS 60 hz GENERATOR • operation and parts manual — rev.
Terms and Conditions of Sale — Parts pAYmENT TERms 5. Parts must be in new and resalable condition, in the original Multiquip package (if any), and with Multiquip part numbers clearly marked. 6. The following items are not returnable: Multiquip reserves the right to quote and sell direct to Government agencies, and to Original Equipment Manufacturer accounts who use our products as integral parts of their own products. a. spECiAl EXpEdiTiNg sERviCE Terms of payment for parts are net 30 days.
notes GA6HR/6HRS 60 hz GENERATOR • operation and parts manual — rev.
Operation and Parts Manual HERE’S HOW TO GET HELP PLEASE HAVE THE MODEL AND SERIAL NUMBER ON-HAND WHEN CALLING United StateS Multiquip Corporate Office 18910 Wilmington Ave. Carson, CA 90746 Contact: mq@multiquip.com MQ Parts Department Tel.
