User Manual

PAGE 40 — B-46 WALK-BEHIND TROWEL • OPERATION AND PARTS MANUAL — REV. #8 (05/08/12)
TROUBLESHOOTING (ENGINE)
TABLE 7. TROUBLESHOOTING (ENGINE)
SYMPTOM POSSIBLE CAUSE SOLUTION
Difficult to start, "fuel is available, but no
SPARK at spark plug".
Spark plug bridging?
Check gap, insulation or
replace spark plug.
Carbon deposit on spar
k plug?Clean or replace spark plug.
Short circuit due to deficient spark plug
insulation?
Check spark plug insulation,
replace if worn.
Improper spark plug gap? Set to proper gap.
D
ifficult to start, "fuel is available, and
SPARK is present at the spark plug".
ON/OFF switch is shorted?
Check switch wiring, replace
switch.
Ignition coil defective? Replace ignition coil.
Imp
roper spark gap, points dirty?
Set correct spark gap and
clean points.
Condenser insulation worn or short
circuiting?
Replace condenser.
Spark plug wire broken or short circuiting?
Replace de
fective spark plug
wiring.
Difficult to start, "fuel is available, spark
is present and compression is normal".
Wrong fuel type?
Flush fuel system, and replace
with correct type of fuel.
Water or dus
t in fuel system?Flush fuel system.
Air cleaner dirty? Clean or replace air cleaner.
Choke Open? (Engine cold)Close Choke.
Choke Closed? (Engine warm)Open Choke.
Difficult to start, "fuel is available, spark
is present and compression is
low".
Suction/exhaust valve stuck or protruded? Re-seat valves.
Piston ring and/or cylinder worn?
Replace piston rings and or
piston.
Cylinder head and/or spark plug not
tightened properly?
Tor
que cylinder head bolts and
spark plug.
Head gasket and/or spark plug gasket
damaged?
Replace head and spark plug
gaskets.
No fuel present inside priming bulb.
Fuel not available in fuel tank? Fill with correct type of fuel.
Fuel filter clogged? Replace fuel filter.
Fuel tank cap breather hole clogged?Clean or replace fuel tank cap.
Air in fuel line?Bleed fuel line.