Operating instructions

ManualsBrandsMTD ManualsAutomotiveOHV Series

jqa=mêçÇìÅíë=^âíáÉåÖÉëÉääëÅÜ~Ñí=√=p~~êÄêΩÅâÉå=√=dÉêã~åó

I13

FORM NO. 769-08890A

MTD OHV Series

Summary of content (13 pages)

PAGE 1
MTD OHV Series I13 FORM NO.
PAGE 2
PAGE 3
PAGE 4
PAGE 5
PAGE 6
4 11 19 27 35 43 51 58 65 72 79 87 96 104 112 119 126 134 141 148 155 162 171 179 188 197 206 213 221
PAGE 7
English Contents Handling the document . . . . . . . . 4 Safe operating practices . . . . . . . 4 About the engine . . . . . . . . . . . . . 5 Operating instructions . . . . . . . . . 5 Maintenance . . . . . . . . . . . . . . . . 7 Cleaning the engine . . . . . . . . . . 9 Storage . . . . . . . . . . . . . . . . . . . . 9 Warranty . . . . . . . . . . . . . . . . . . . 9 Troubleshooting . . . . . . . . . . . .
PAGE 8
Operating manual for engine Ó cçê=áÖåáíáçå=íÉëíëI=ìëÉ=~å= ~ìíÜçêáëÉÇ=áÖåáíáçå=íÉëíÉê=çåäóK Ó `çåÇìÅí=~å=áÖåáíáçå=íÉëí=çå= ~ ëé~êâ=éäìÖ=ïÜáÅÜ=Ü~ë=ÄÉÉå= êÉãçîÉÇK ! oáëâ=çÑ=Äìêåë>= oáëâ=çÑ=ÑáêÉ> ^=êìååáåÖ=ÉåÖáåÉ=ÖÉåÉê~íÉë=ÜÉ~íK= båÖáåÉ=é~êíëI=ÉëéÉÅá~ääó=íÜÉ=ÉñÜ~ìëíI= ~êÉ=ÉñíêÉãÉäó=ÜçíK=aç=åçí=íçìÅÜI= çíÜÉêïáëÉ=óçì=ÅçìäÇ=êÉÅÉáîÉ=ëÉîÉêÉ= ÄìêåëK= cä~ãã~ÄäÉ=çÄàÉÅíë=ëìÅÜ=~ë=äÉ~îÉëI= Öê~ëëI=ÄìëÜÉëI=ÉíÅK=ã~ó=Å~íÅÜ=ÑáêÉK Ó aç=åçí=íçìÅÜ=íÜÉ=ÉñÜ~ìëíI=ÅóäáåÇÉê= ÄäçÅâ=çê=ÅççäáåÖ=Ñáåë=ìåíáä=íÜÉó= Ü~îÉ=ÅççäÉÇ=ÇçïåK Ó hÉÉé=Å
PAGE 9
English If oil with an individual viscosity is used, a viscosity should be selected from the table for the average tempe-rature in the application area. `~ìíáçå> fÑ=~å=áåÑÉêáçê=çáä=çê=~å=çáä=Ñçê=OJëíêçâÉ= ÉåÖáåÉë=áë=ìëÉÇI=íÜÉ=ëÉêîáÅÉ=äáÑÉ=çÑ= íÜÉ=ÉåÖáåÉ=ã~ó=ÄÉ=Ç~ã~ÖÉÇK Checking the oil level `~ìíáçå> tÜÉå=ÅÜÉÅâáåÖ=íÜÉ=çáäI=ÉåëìêÉ=íÜ~í= íÜÉ=ìåáí=áë=çå=~=äÉîÉä=ëìêÑ~ÅÉ=~åÇ=íÜ~í= íÜÉ=ÉåÖáåÉ=áë=ëïáíÅÜÉÇ=çÑÑK Fig. 2  Unscrew the oil filler cap (1) and wipe the dip stick.
PAGE 10
Operating manual for engine English Starting with the electric starter (depending on model)  Set the throttle (if fitted) to  Disconnect charger from power or supply and unit.  Open fuel tap (11, Fig. 1; if fitted).  Set On/Off switch on the engine (9, Fig. 1; if available) to position “On/I”.  Stand behind the unit, depress the safety lever (2; if fitted) and hold down against the handle.  Turn the key on the steering handle (4) to the right and hold until the engine starts.
PAGE 11
English Operating manual for engine Checking the oil Servicing the air filter  Attach cover:  Before starting the engine, always A dirty air filter restricts the air flow to the carburettor. To prevent the carburettor from malfunctioning, the air filter should be cleaned/replaced regularly. In an extremely dusty environment more frequent maintenance may be required. A paper filter cannot be cleaned and must be changed according to the maintenance interval.
PAGE 12
Operating manual for engine `~ìíáçå> aç=åçí=íáÖÜíÉå=íÜÉ=ëé~êâ=éäìÖ=íçç= íáÖÜíäóK=lÄëÉêîÉ=íÜÉ=ÑçääçïáåÖ=î~äìÉë= Ñçê=íáÖÜíÉåáåÖ=íÜÉ=ëé~êâ=éäìÖ=ïáíÜ= ~ ëé~êâJéäìÖ=ïêÉåÅÜW Ó åÉï=ëé~êâ=éäìÖ=ã~ñáãìã= N LO=êÉîçäìíáçå Ó ìëÉÇ=ëé~êâ=éäìÖ=ã~ñáãìã= NL Ó=NL =êÉîçäìíáçåK U= Q ^å=áåÅçêêÉÅíäó=íáÖÜíÉåÉÇ=ëé~êâ=éäìÖ= ã~ó=ÄÉÅçãÉ=îÉêó=Üçí=~åÇ=Ç~ã~ÖÉ= íÜÉ=ÉåÖáåÉK Maintenance of the activated-carbon filter/fuel filter This maintenance work may only be performed by a service centre according to maintenance schedule.
PAGE 13
English Operating manual for engine Troubleshooting Fault Engine does not start. Possible cause Safety lever not actuated. No fuel in the tank. Stale fuel. Engine in a cold state, choke/primer (if fitted) not actuated. Throttle not set to “START” or maximum speed. Spark plug terminal not connected. Spark plug dirty or defective. Engine runs irregularly (splutters). Engine overheats. Blocked petrol line. Choke (if fitted) actuated. Spark plug terminal connected loosely. Stale fuel.