Service manual
Table Of Contents
- ul-68P81076C25-C_AT_DS_ASPlus-Part1_astro_d.pdf
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- File 1 (Front cover to pg. 6-14)
- Foreword
- Table of Contents
- List of Figures
- List of Tables
- Related Publications
- Commercial Warranty
- Model Numbering, Charts, and Specifications
- Mobile Radio Model Numbering Scheme
- ASTRO Digital Spectra Motorcycle 15 Watt (Ranges 1 and 2) Model Chart
- ASTRO Digital Spectra Motorcycle 15 Watt (Ranges 3 and 3.5) Model Chart
- ASTRO Digital Spectra VHF 10–25 Watt Model Chart
- ASTRO Digital Spectra VHF 10–25 and 50–110 Watt Model Chart
- ASTRO Digital Spectra VHF 10–25 and 50–110 Watt Model Chart (cont.)
- ASTRO Digital Spectra UHF 10–25 Watt Model Chart
- ASTRO Digital Spectra UHF 20–40 Watt Model Chart
- ASTRO Digital Spectra UHF 20–40 Watt Model Chart (cont.)
- ASTRO Digital Spectra UHF 50–110 Watt Model Chart
- ASTRO Digital Spectra UHF 50–110 Watt Model Chart (cont.)
- ASTRO Digital Spectra 800 MHz Model Chart
- ASTRO Digital Spectra Plus VHF 25–50 and 50–110 Watt Model Chart
- ASTRO Digital Spectra Plus VHF 25–50 and 50–110 Watt Model Chart (cont.)
- ASTRO Digital Spectra Plus 800 MHz Model Chart
- ASTRO Digital Spectra Plus 800 MHz Model Chart (cont.)
- VHF Radio Specifications
- UHF Radio Specifications
- 800 MHz Radio Specifications
- Chapter 1 Introduction
- Chapter 2 General Overview
- 2.1 Introduction
- 2.2 Analog Mode of Operation
- 2.3 ASTRO Mode of Operation
- 2.4 Control Head Assembly
- 2.4.1 Display (W3 Model)
- 2.4.2 Display (W4, W5, and W7 Models)
- 2.4.3 Display (W9 Model)
- 2.4.4 Vacuum Fluorescent Display Driver
- 2.4.5 Vacuum Fluorescent Voltage Source (W9 Model)
- 2.4.6 Controls and Indicators
- 2.4.7 Status LEDs
- 2.4.8 Backlight LEDs
- 2.4.9 Vehicle Interface Ports
- 2.4.10 Power Supplies
- 2.4.11 Ignition Sense Circuits
- 2.5 Power Amplifier
- 2.6 Front-End Receiver Assembly
- 2.7 RF Board Basic
- 2.8 Voltage-Controlled Oscillator
- 2.9 Command Board
- 2.10 ASTRO Spectra Vocoder/Controller Board
- 2.11 Radio Power
- Chapter 3 Theory of Operation
- 3.1 RF Board
- 3.2 Command Board
- 3.2.1 Microcontroller and Support ICs
- 3.2.2 Serial Input/Output IC
- 3.2.3 Power-Up/-Down Sequence
- 3.2.4 Regulators
- 3.2.5 Reset Circuits
- 3.2.6 Serial Communications on the External Bus
- 3.2.7 Synchronous Serial Bus (MOSI)
- 3.2.8 Received Audio
- 3.2.9 Microphone Audio
- 3.2.10 Transmit Deviation
- 3.2.11 RS-232 Line Driver
- 3.2.12 Flash Programming
- 3.2.13 Encryption Voltages
- 3.2.14 Regulator and Power-Control IC
- 3.3 ASTRO Spectra VOCON Board
- 3.3.1 General
- 3.3.2 Controller Section
- 3.3.3 Vocoder Section
- 3.3.4 RX Signal Path
- 3.3.5 TX Signal Path
- 3.3.6 Controller Bootstrap and Asynchronous Buses
- 3.3.7 Vocoder Bootstrap
- 3.3.8 Serial Peripheral Interface (SPI) Bus
- 3.3.9 Controller Memory Map
- 3.3.10 Vocoder Memory Map
- 3.3.11 MCU System Clock
- 3.3.12 DSP System Clock
- 3.3.13 Radio Power-Up/Power-Down Sequence
- 3.3.14 VOCON BOARD Signals
- 3.4 ASTRO Spectra Plus VOCON Board
- 3.4.1 General
- 3.4.2 ASTRO Spectra Plus Controller Section
- 3.4.3 ASTRO Spectra Plus Vocoder Section
- 3.4.4 ASTRO Spectra Plus RX Signal Path
- 3.4.5 ASTRO Spectra Plus TX Signal Path
- 3.4.6 ASTRO Spectra Plus Controller Bootstrap and Asynchronous Busses
- 3.4.7 ASTRO Spectra Plus Serial Peripheral Interface Bus
- 3.4.8 ASTRO Spectra Plus MCU and DSP System Clocks
- 3.4.9 ASTRO Spectra Plus Voltage Regulators
- 3.4.10 ASTRO Spectra Plus Radio Power-Up/Power-Down Sequence
- 3.5 Voltage Control Oscillator
- 3.6 Receiver Front-End
- 3.7 Power Amplifiers
- Chapter 4 Troubleshooting Procedures
- 4.1 ASTRO Spectra Procedures
- 4.2 ASTRO Spectra Plus Procedures
- 4.3 VCO Procedures
- 4.4 Receiver Front-End (RXFE)
- 4.5 Power Amplifier Procedures
- Chapter 5 Troubleshooting Charts
- Chapter 6 Troubleshooting Waveforms
- File 2 (pgs. 7-1 to 7-25)
- File 3 (pgs. 7-26 to 7-48)
- File 4 (pg. 7-49 to back cover)
- File 1 (Front cover to pg. 6-14)
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- ul-68P81076C25-C_AT_DS_ASPlus-Part2_astro_d
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- File 1 (Front cover to pg. 6-14)
- File 2 (pgs. 7-1 to 7-25)
- Chapter 7 Schematics, Component Location Diagrams, and Parts Lists
- 7.1 RF Section
- Table 7-1: J500 Command Board to RF Board Interconnect Board
- Table 7-2: P502 Command Board to Control Head Interconnect Board
- Table 7-2: P502 Command Board to Control Head Interconnect Board
- Table 7-3: P503 Command Board to RF Power Amplifier Board
- Table 7-4: Configuring Command Board Jumpers for Non-RS232 Operation
- Table 7-5: J501 Command Board to VOCON Board
- Table 7-5: J501 Command Board to VOCON Board
- Table 7-6: J801 VOCON Board to Encryption Board
- Table 7-6: J801 VOCON Board to Encryption Board
- Table 7-7: J601 RF Board to VCO Board
- ASTRO Spectra Radio Interconnection
- HRN4009B/HRN6014A VHF RF Board; HRN4010B/HRN6020A UHF RF Board; and HRN6019A 800 MHz RF Board Schematic
- HRN4009B/HRN6014A VHF RF Board, HRN4010B/HRN6020A UHF RF Board, and HRN6019A 800 MHz RF Board Component Location Diagrams
- HRN4009B, HRN6014A VHF RF Board HRN4010B, HRN6020A UHF RF Board HRN6019A 800 MHz RF Board Electrical Parts List
- HRN4009C/HRN6014C VHF RF Board Schematic Diagram
- HRN4009C/HRN6014C VHF RF Board Component Location Diagrams
- HRN4009C/HRN6014C VHF RF Board Electrical Parts List
- HRN4009E and HRN6014D VHF RF Board; HRN4010D and HRN6020C UHF RF Board; and HRN6019C 800 MHz RF Board Schematic Diagram (Sheet 1 of 2)
- HRN4009E and HRN6014D VHF RF Board; HRN4010D and HRN6020C UHF RF Board; and HRN6019C 800 MHz RF Board Schematic Diagram (Sheet 2 of 2)
- HRN4009E and HRN6014D VHF RF Board; HRN4010D and HRN6020C UHF RF Board; and HRN6019C 800 MHz RF Component Location Diagram
- HRN4009E and HRN6014D VHF RF Board, HRN6010D and HRN6020C UHF RF Board, and HRN6019C 800 MHz RF Board Parts Lists
- 7.2 Command Board Section
- HLN5558E/F/G, HLN6529C/D/E/F/G, HLN6560C/D/E/F/G/H and HLN6562C/D/E/F/G/H Command Board Schematic Diagram
- HLN5558E/F/G, HLN6529C/D/E, HLN6560C/D/E/F/G/H, and HLN6562C/D/E/F/G/H Command Board Component Location Diagrams
- Command Boards Reference Designator and Part Number Comparison Chart
- HLN5558E/F/G, HLN6529C/D/E, HLN6560C/D/E/F/G/H, and HLN6562C/D/E/F/G/H Parts List
- HLN5558H/J, HLN6529H, HLN6560J and HLN6562J Command Board Schematic Diagram
- HLN5558H/J, HLN6529H, HLN6560J and HLN6562J Component Location Diagram
- Command Boards Reference Designator and Part Number Comparison Chart
- HLN5558H/J, HLN6529H, HLN6560J and HLN6562J Parts List
- 7.1 RF Section
- Chapter 7 Schematics, Component Location Diagrams, and Parts Lists
- File 3 (pgs. 7-26 to 7-48)
- File 4 (pg. 7-48 to back cover)
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- ul-68P81076C25-C_AT_DS_ASPlus-Part3_astro_d
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- File 1 (Front cover to pg. 6-14)
- File 2 (pgs. 7-1 to 7-25)
- File 3 (pgs. 7-26 to 7-48)
- 7.3 VOCON Section
- HLN6458D VOCON Board Schematic (Sheet 1 of 2)
- HLN6458D VOCON Board Component Location Diagrams (Sheet 1 of 2)
- HLN6458D VOCON Board Component Location Diagrams (Sheet 2 of 2)
- HLN6458D VOCON Board Parts List
- HLN6458E VOCON Board Schematic (Sheet 1 of 2)
- HLN6458E VOCON Board Schematic (Sheet 2 of 2)
- HLN6458E VOCON Board Component Location Diagrams (Sheet 1 of 2)
- HLN6458E VOCON Board Component Location Diagrams (Sheet 2 of 2)
- HLN6458E VOCON Board Electrical Parts List
- HLN6458F/G VOCON Board Schematic (Sheet 1 of 2)
- HLN6458F/G VOCON Board Schematic (Sheet 2 of 2)
- HLN6458F/G VOCON Board Component Location Diagrams (Sheet 1 of 2)
- HLN6458F/G VOCON Board Component Location Diagrams (Sheet 2 of 2)
- HLN6458F/G VOCON Board Parts List
- HLN6458H VOCON Board Schematic (Sheet 1 of 2)
- HLN6458H VOCON Board Schematic (Sheet 2 of 2)
- HLN6458H VOCON Board Component Location Diagrams
- HLN6458H VOCON Board Electrical Parts List
- 7.3 VOCON Section
- File 4 (pg. 7-48 to back cover)
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- ul-68P81076C25-C_AT_DS_ASPlus-Part4_astro_d
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- File 1 (Front cover to pg. 6-14)
- File 2 (pgs. 7-1 to 7-25)
- File 3 (pgs. 7-26 to 7-48)
- File 4 (pg. 7-49 to back cover)
- Chapter 7: Schematics, Component Location Diagrams, and Parts Lists: ASTRO Spectra Plus VOCON Section
- 7.4 ASTRO Spectra Plus VOCON Section
- ASTRO Spectra Plus Top Level Schematic (Sheet 1 of 2)
- ASTRO Spectra Plus Top Level Schematic (Sheet 2 of 2)
- ASTRO Spectra Plus RF Interface Schematic (Sheet 1 of 2)
- ASTRO Spectra Plus RF Interface Schematic (Sheet 2 of 2)
- ASTRO Spectra Plus Digital/USB Schematic (Sheet 1 of 2)
- ASTRO Spectra Plus Digital/USB Schematic (Sheet 2 of 2)
- ASTRO Spectra Plus Audio/DC Schematic
- ASTRO Spectra Plus Voltage Conversion Schematic
- ASTRO Spectra Plus Secure Interface Schematic
- ASTRO Spectra Plus VOCON Component Location Diagram, Top View
- ASTRO Spectra Plus VOCON Component Location Diagram, Bottom View
- HLN6837A ASTRO Spectra Plus VOCON Electrical Parts List
- 7.5 VCO Section
- HLD6061D and HLD6062D VHF VCO Hybrid Schematic
- HLD6061D and HLD6062D VHF VCO Hybrid Component Location Diagram
- HLD6061D and HLD6062D Parts List
- HLD4342B and HLD4343B VHF VCO Carrier Schematic Diagram
- HLD4342D and HLD4343D VHF VCO Carrier Schematic Diagram
- HLD4342B/HLD4343B VHF VCO Carrier Component Location Diagram
- HLD4342D/HLD4343D VHF VCO Carrier Component Location Diagram
- HLD4342B and HLD4343B VHF VCO Parts List
- HLD4342D and HLD4343D VHF VCO Parts List
- UHF VCO Ranges 1, 2, 3, and 4 Hybrid Schematic
- HLE6101A UHF VCO Range 1 Hybrid and HLE6102A Range 2 Hybrid Component Location Diagram
- HLE6101A UHF VCO Range 1 Hybrid and HLE6102A UHF VCO Range 2 Hybrid Parts List
- HLE6103B UHF VCO Range 3 Hybrid and HLE6104B Range 4 Hybrid Component Location Diagram
- HLE6103B UHF VCO Range 3 Hybrid and HLE6104B UHF VCO Range 4 Hybrid Parts List
- UHF VCO Ranges 1, 2, 3, and 4 Schematic Diagram
- HLE6045B Range 1 and HLE6046B Range 2 UHF VCO Component Location Diagram
- HLE6000D Range 3 and HLE6041D Range 4 UHF VCO Component Location Diagrams
- HLE6000D and HLE6041D UHF VCO Parts List
- HLF6080B 800 MHz VCO Schematic Diagram
- HLF6080B 800 MHz VCO Component Location Diagram
- HLF6080B 800 MHz VCO Parts List
- 7.6 RX Front-End Section
- HRD6001E/6002E/6011E/6012E VHF Receiver Front-End Schematic
- HRD6001E/6002E/6011E/6012E VHF Component Location Diagram
- HRD6001E VHF RXFE Parts List
- HRD6002E Parts List
- HRD6011E Parts List
- HRD6012E Parts List
- HRD6001G/6002G/6011G/6012G VHF Receiver Front-End Schematic
- HRD6001G/6002G/6011G/6012G VHF Receiver Front-End Component Location Diagram
- HRD6001G/HRD6002G/HRD6011G/HRD6012G VHF RXFE Parts List
- HRE6001B/6002C/6003B/6004B/6011B/6012B/6014B UHF Receiver Front-End Preamp and Standard Schematics
- HRE6001B/6002C/6003B/6004B/6011B/6012B/6014B UHF Receiver Front-End Hybrid Component Location Diagram
- HRE6011B UHF RXFE Pre-Amp Parts List
- HRE6012B UHF RXFE Pre-Amp Parts List
- HRE6014B UHF RXFE Pre-Amp Parts List
- HRE6001B and HRE6002C UHF RXFE Standard Parts List
- HRE6003B and HRE6004B UHF RXFE Standard Parts List
- HRF6004B/C 800 MHz Receiver Front-End Schematic Diagram
- HRF6004B/C 800 MHz Receiver Front-End Component Location Diagram
- HRF6004B/C 800 MHz RXFE Parts List
- 7.7 Power Amplifier Section
- HLD6022C VHF 50 Watt PA Schematic
- HLD6022C VHF 50-Watt PA Component Location Diagram, Side 1
- HLD6022C VHF 50-Watt PA Component Location Diagram, Side 2
- HLD6022C VHF 50-Watt PA Parts List
- HLD6064C VHF 100-Watt PA Schematic
- HLD6064C VHF 100-Watt PA Component Location Diagram, Side 1
- HLD6064C VHF 100-Watt PA Component Location Diagram, Side 2
- HLD6064C VHF R1 100-Watt PA Parts List
- HLD6032B/HLD6066B VHF 25-Watt PA Schematic
- HLD6032B/HLD6066B VHF 25-Watt PA Component Location Diagram, Side 1
- HLD6032B/HLD6066B VHF 25-Watt PA Component Location Diagram, Side 2
- HLD6032B VHF R2 25-Watt PA Parts List
- HLD6066B VHF R1 25-Watt PA Parts List
- HLE6062B and HLE6071B UHF 25-Watt PA Schematic
- HLE6062B UHF 25-Watt PA Component Location Diagram, Side 1
- HLE6062B UHF 25-Watt PA Component Location Diagram, Side 2
- HLE6062B VHF R2 25-Watt PA Parts List
- HLE6043C, HLE6044C, and HLE6049B UHF 40-Watt PA Schematic
- HLE6043C, HLE6044C, and HLE6049B UHF 40-Watt PA Component Location Diagram, Side 1
- HLE6043C, HLE6044C, and HLE6049B UHF 40-Watt PA Component Location Diagram, Side 2
- HLE6043C UHF R3 40-Watt Parts List
- HLE6044C UHF R4 40-Watt PA Parts List
- HLE6049B UHF R1 40-Watt PA Parts List
- HLE6039C, HLE6040C, and HLE6051C UHF 100-Watt PA Schematic
- HLE6039C, HLE6040C, and HLE6051C UHF 100-Watt PA Component Location Diagram, Side 1
- HLE6039C, HLE6040C, and HLE6051C UHF 100-Watt PA Component Location Diagram, Side 2
- HLE6039C UHF R3 100-Watt PA Parts List
- HLE6040C UHF R4 100-Watt PA Parts List
- HLE6051 UHF R1 100-Watt PA Parts List
- HLF6078B 800 MHz 15-Watt PA Schematic
- HLF6078B 800 MHz 15-Watt PA Component Location Diagram, Side 1
- HLF6078B 800 MHz 15-Watt PA Component Location Diagram, Side 2
- HLF6078C 800MHz 15-Watt PA Parts List
- HLF6077D 800 MHz 35-Watt PA Schematic
- HLF6077D 800 MHz 35-Watt PA Component Location Diagram, Side 1
- HLF6077D 800 MHz 35-Watt PA Component Location Diagram, Side 2
- HLF6077D 800MHz 35-Watt PA Parts List
- 7.4 ASTRO Spectra Plus VOCON Section
- Appendix A Secure Modules
- Appendix B Replacement Parts Ordering
- Glossary
- Back cover
- Chapter 7: Schematics, Component Location Diagrams, and Parts Lists: ASTRO Spectra Plus VOCON Section
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
Schematics, Component Location Diagrams, and Parts Lists: ASTRO Spectra Plus VOCON Section 7-49
68P81076C25-C July 1, 2002
7.4 ASTRO Spectra Plus VOCON Section
ASTRO Spectra Plus Top Level Schematic (Sheet 1 of 2)
SBI
REF_MOD
VOCON BOARD CONNECTOR
USB_MOD
SCLK
LOCK_DET
ROSC/PSC_CE*
DA_SEL*
USB_CONTROL
USB CONNECTOR
DOUT*
GND
DISC_AUDIOI
SYN_SEL*
ODC
USB_D+
MOSI
USB_BOOT
DOUT
USB_D-
USB_PWR
USB_VPP
USB_BOOT
4
5
J501-2
J501-11
J501-9
QSCKA
QSCKB
REFMOD
RESET_OUT
SBI
SCK
SFS
STD
TXE
ABA_RXD
ADDAG_SEL
DOUT
DOUT*
KRSIC_AB(4:0)
KRSIC_CS
KRSIC_DB(7:0)
KRSIC_RD
KRSIC_SEL
KRSIC_WR
MISOA
MISOB
MOD_OUT
MOSIA
MOSIB
ODC
16.8MHz8Khz_DSP
ABA_CLK
ABA_FSYNC
4
712
11
SSI_CLK_5
SSI_FS
SWB
TAMPER
UNSWB
WAKEUP*
VCC10_13V
1
EMC_REQUEST
KEYFAIL
KG_BCKUP
MISO_5
MOSI_5
ONOFF_SWB
SS#_3
SS#_5
SSI_CLK_3IN
J501-13
0
0
J501-8
TP103
1
4
2
1
8
1
TP102
1
2
0
TP104
1
5
3
J501-10
9
0
J501-49
J501-48
TP107
1
J501-7
3
USB_CONTROL
USB_D+
USB_D-
USB_MOD
USB_PWR
USB_VPP
VIPOUT1-BL_EN
VIPOUT2
VIP_IN1
VIP_IN2
WARP
J501-12
RESET_OUT
ROSC-PSC_EN
RTS-RS232
RX
RX-RS232
SAP_FSYNC
SCK
SFS
SPKR_EN
STD
SYN_SEL
TX
TX-RS232
TXE_ADDAG
TXPA_EN*
USB_BOOT
KRSIC_SEL
KRSIC_WR
L H- R X_ DATA
L H- T X_ DATA
LH_RESETI
LH_RESETO
LOCK_DET
LV_DETECT
MISOA
MISOB
MOSIA
MOSIB
OPTB+_BOOT_VPP-CABLE
POR
QSCKA
QSCKB
COLUMN7
CTS-RS232
DA_SEL*
DCLK
DISP_EN-LATCH*
EEPOT_CS*
EEPOT_CS_2
EEPOT_INC*
EEPOT_U_D*
EMER
INT_PTT
K9_4EN-MIC_EN
KRSIC_AB(4:0)
KRSIC_CS
KRSIC_DB(7:0)
KRSIC_RD
8Khz_DSP_int
ABA_CLK
ABA_FSYNC
ABA_RXD
ADDAG_SEL
BUSY_OUT
BUSY_RTS
CLIH
CODEC_PWR_DWN
COLUMN0
COLUMN1
COLUMN2
COLUMN3
COLUMN4
COLUMN5
COLUMN6
5
32KHz
5V_EN*
J501-6
1
TP101
1
TP100
1
TP106
1
3
10
TP105
2
3
J501-1
EEPOT_CS
EEPOT_CS_2
EEPOT_INC*
EEPOT_U_D*
FSYNC
LV_DETECT
MAI
RX
SDO
TX
WARP
RF_INT_5(5:0)
RF_INT_3(5:0)
SECURE_CNT(12:0)
32k_CLK
CLIH
CODEC_PWR_DOWN
DCLK
A
B
C
D
E
F
G
H
I
J
K
L
M
O
P
Q
N
R
S
T
U
V
W
X
Y
Z
AA
BB
CC