Service manual
Table Of Contents
- ul-68P81076C25-C_AT_DS_ASPlus-Part1_astro_d.pdf
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- File 1 (Front cover to pg. 6-14)
- Foreword
- Table of Contents
- List of Figures
- List of Tables
- Related Publications
- Commercial Warranty
- Model Numbering, Charts, and Specifications
- Mobile Radio Model Numbering Scheme
- ASTRO Digital Spectra Motorcycle 15 Watt (Ranges 1 and 2) Model Chart
- ASTRO Digital Spectra Motorcycle 15 Watt (Ranges 3 and 3.5) Model Chart
- ASTRO Digital Spectra VHF 10–25 Watt Model Chart
- ASTRO Digital Spectra VHF 10–25 and 50–110 Watt Model Chart
- ASTRO Digital Spectra VHF 10–25 and 50–110 Watt Model Chart (cont.)
- ASTRO Digital Spectra UHF 10–25 Watt Model Chart
- ASTRO Digital Spectra UHF 20–40 Watt Model Chart
- ASTRO Digital Spectra UHF 20–40 Watt Model Chart (cont.)
- ASTRO Digital Spectra UHF 50–110 Watt Model Chart
- ASTRO Digital Spectra UHF 50–110 Watt Model Chart (cont.)
- ASTRO Digital Spectra 800 MHz Model Chart
- ASTRO Digital Spectra Plus VHF 25–50 and 50–110 Watt Model Chart
- ASTRO Digital Spectra Plus VHF 25–50 and 50–110 Watt Model Chart (cont.)
- ASTRO Digital Spectra Plus 800 MHz Model Chart
- ASTRO Digital Spectra Plus 800 MHz Model Chart (cont.)
- VHF Radio Specifications
- UHF Radio Specifications
- 800 MHz Radio Specifications
- Chapter 1 Introduction
- Chapter 2 General Overview
- 2.1 Introduction
- 2.2 Analog Mode of Operation
- 2.3 ASTRO Mode of Operation
- 2.4 Control Head Assembly
- 2.4.1 Display (W3 Model)
- 2.4.2 Display (W4, W5, and W7 Models)
- 2.4.3 Display (W9 Model)
- 2.4.4 Vacuum Fluorescent Display Driver
- 2.4.5 Vacuum Fluorescent Voltage Source (W9 Model)
- 2.4.6 Controls and Indicators
- 2.4.7 Status LEDs
- 2.4.8 Backlight LEDs
- 2.4.9 Vehicle Interface Ports
- 2.4.10 Power Supplies
- 2.4.11 Ignition Sense Circuits
- 2.5 Power Amplifier
- 2.6 Front-End Receiver Assembly
- 2.7 RF Board Basic
- 2.8 Voltage-Controlled Oscillator
- 2.9 Command Board
- 2.10 ASTRO Spectra Vocoder/Controller Board
- 2.11 Radio Power
- Chapter 3 Theory of Operation
- 3.1 RF Board
- 3.2 Command Board
- 3.2.1 Microcontroller and Support ICs
- 3.2.2 Serial Input/Output IC
- 3.2.3 Power-Up/-Down Sequence
- 3.2.4 Regulators
- 3.2.5 Reset Circuits
- 3.2.6 Serial Communications on the External Bus
- 3.2.7 Synchronous Serial Bus (MOSI)
- 3.2.8 Received Audio
- 3.2.9 Microphone Audio
- 3.2.10 Transmit Deviation
- 3.2.11 RS-232 Line Driver
- 3.2.12 Flash Programming
- 3.2.13 Encryption Voltages
- 3.2.14 Regulator and Power-Control IC
- 3.3 ASTRO Spectra VOCON Board
- 3.3.1 General
- 3.3.2 Controller Section
- 3.3.3 Vocoder Section
- 3.3.4 RX Signal Path
- 3.3.5 TX Signal Path
- 3.3.6 Controller Bootstrap and Asynchronous Buses
- 3.3.7 Vocoder Bootstrap
- 3.3.8 Serial Peripheral Interface (SPI) Bus
- 3.3.9 Controller Memory Map
- 3.3.10 Vocoder Memory Map
- 3.3.11 MCU System Clock
- 3.3.12 DSP System Clock
- 3.3.13 Radio Power-Up/Power-Down Sequence
- 3.3.14 VOCON BOARD Signals
- 3.4 ASTRO Spectra Plus VOCON Board
- 3.4.1 General
- 3.4.2 ASTRO Spectra Plus Controller Section
- 3.4.3 ASTRO Spectra Plus Vocoder Section
- 3.4.4 ASTRO Spectra Plus RX Signal Path
- 3.4.5 ASTRO Spectra Plus TX Signal Path
- 3.4.6 ASTRO Spectra Plus Controller Bootstrap and Asynchronous Busses
- 3.4.7 ASTRO Spectra Plus Serial Peripheral Interface Bus
- 3.4.8 ASTRO Spectra Plus MCU and DSP System Clocks
- 3.4.9 ASTRO Spectra Plus Voltage Regulators
- 3.4.10 ASTRO Spectra Plus Radio Power-Up/Power-Down Sequence
- 3.5 Voltage Control Oscillator
- 3.6 Receiver Front-End
- 3.7 Power Amplifiers
- Chapter 4 Troubleshooting Procedures
- 4.1 ASTRO Spectra Procedures
- 4.2 ASTRO Spectra Plus Procedures
- 4.3 VCO Procedures
- 4.4 Receiver Front-End (RXFE)
- 4.5 Power Amplifier Procedures
- Chapter 5 Troubleshooting Charts
- Chapter 6 Troubleshooting Waveforms
- File 2 (pgs. 7-1 to 7-25)
- File 3 (pgs. 7-26 to 7-48)
- File 4 (pg. 7-49 to back cover)
- File 1 (Front cover to pg. 6-14)
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- ul-68P81076C25-C_AT_DS_ASPlus-Part2_astro_d
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- File 1 (Front cover to pg. 6-14)
- File 2 (pgs. 7-1 to 7-25)
- Chapter 7 Schematics, Component Location Diagrams, and Parts Lists
- 7.1 RF Section
- Table 7-1: J500 Command Board to RF Board Interconnect Board
- Table 7-2: P502 Command Board to Control Head Interconnect Board
- Table 7-2: P502 Command Board to Control Head Interconnect Board
- Table 7-3: P503 Command Board to RF Power Amplifier Board
- Table 7-4: Configuring Command Board Jumpers for Non-RS232 Operation
- Table 7-5: J501 Command Board to VOCON Board
- Table 7-5: J501 Command Board to VOCON Board
- Table 7-6: J801 VOCON Board to Encryption Board
- Table 7-6: J801 VOCON Board to Encryption Board
- Table 7-7: J601 RF Board to VCO Board
- ASTRO Spectra Radio Interconnection
- HRN4009B/HRN6014A VHF RF Board; HRN4010B/HRN6020A UHF RF Board; and HRN6019A 800 MHz RF Board Schematic
- HRN4009B/HRN6014A VHF RF Board, HRN4010B/HRN6020A UHF RF Board, and HRN6019A 800 MHz RF Board Component Location Diagrams
- HRN4009B, HRN6014A VHF RF Board HRN4010B, HRN6020A UHF RF Board HRN6019A 800 MHz RF Board Electrical Parts List
- HRN4009C/HRN6014C VHF RF Board Schematic Diagram
- HRN4009C/HRN6014C VHF RF Board Component Location Diagrams
- HRN4009C/HRN6014C VHF RF Board Electrical Parts List
- HRN4009E and HRN6014D VHF RF Board; HRN4010D and HRN6020C UHF RF Board; and HRN6019C 800 MHz RF Board Schematic Diagram (Sheet 1 of 2)
- HRN4009E and HRN6014D VHF RF Board; HRN4010D and HRN6020C UHF RF Board; and HRN6019C 800 MHz RF Board Schematic Diagram (Sheet 2 of 2)
- HRN4009E and HRN6014D VHF RF Board; HRN4010D and HRN6020C UHF RF Board; and HRN6019C 800 MHz RF Component Location Diagram
- HRN4009E and HRN6014D VHF RF Board, HRN6010D and HRN6020C UHF RF Board, and HRN6019C 800 MHz RF Board Parts Lists
- 7.2 Command Board Section
- HLN5558E/F/G, HLN6529C/D/E/F/G, HLN6560C/D/E/F/G/H and HLN6562C/D/E/F/G/H Command Board Schematic Diagram
- HLN5558E/F/G, HLN6529C/D/E, HLN6560C/D/E/F/G/H, and HLN6562C/D/E/F/G/H Command Board Component Location Diagrams
- Command Boards Reference Designator and Part Number Comparison Chart
- HLN5558E/F/G, HLN6529C/D/E, HLN6560C/D/E/F/G/H, and HLN6562C/D/E/F/G/H Parts List
- HLN5558H/J, HLN6529H, HLN6560J and HLN6562J Command Board Schematic Diagram
- HLN5558H/J, HLN6529H, HLN6560J and HLN6562J Component Location Diagram
- Command Boards Reference Designator and Part Number Comparison Chart
- HLN5558H/J, HLN6529H, HLN6560J and HLN6562J Parts List
- 7.1 RF Section
- Chapter 7 Schematics, Component Location Diagrams, and Parts Lists
- File 3 (pgs. 7-26 to 7-48)
- File 4 (pg. 7-48 to back cover)
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- ul-68P81076C25-C_AT_DS_ASPlus-Part3_astro_d
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- File 1 (Front cover to pg. 6-14)
- File 2 (pgs. 7-1 to 7-25)
- File 3 (pgs. 7-26 to 7-48)
- 7.3 VOCON Section
- HLN6458D VOCON Board Schematic (Sheet 1 of 2)
- HLN6458D VOCON Board Component Location Diagrams (Sheet 1 of 2)
- HLN6458D VOCON Board Component Location Diagrams (Sheet 2 of 2)
- HLN6458D VOCON Board Parts List
- HLN6458E VOCON Board Schematic (Sheet 1 of 2)
- HLN6458E VOCON Board Schematic (Sheet 2 of 2)
- HLN6458E VOCON Board Component Location Diagrams (Sheet 1 of 2)
- HLN6458E VOCON Board Component Location Diagrams (Sheet 2 of 2)
- HLN6458E VOCON Board Electrical Parts List
- HLN6458F/G VOCON Board Schematic (Sheet 1 of 2)
- HLN6458F/G VOCON Board Schematic (Sheet 2 of 2)
- HLN6458F/G VOCON Board Component Location Diagrams (Sheet 1 of 2)
- HLN6458F/G VOCON Board Component Location Diagrams (Sheet 2 of 2)
- HLN6458F/G VOCON Board Parts List
- HLN6458H VOCON Board Schematic (Sheet 1 of 2)
- HLN6458H VOCON Board Schematic (Sheet 2 of 2)
- HLN6458H VOCON Board Component Location Diagrams
- HLN6458H VOCON Board Electrical Parts List
- 7.3 VOCON Section
- File 4 (pg. 7-48 to back cover)
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- ul-68P81076C25-C_AT_DS_ASPlus-Part4_astro_d
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
- File 1 (Front cover to pg. 6-14)
- File 2 (pgs. 7-1 to 7-25)
- File 3 (pgs. 7-26 to 7-48)
- File 4 (pg. 7-49 to back cover)
- Chapter 7: Schematics, Component Location Diagrams, and Parts Lists: ASTRO Spectra Plus VOCON Section
- 7.4 ASTRO Spectra Plus VOCON Section
- ASTRO Spectra Plus Top Level Schematic (Sheet 1 of 2)
- ASTRO Spectra Plus Top Level Schematic (Sheet 2 of 2)
- ASTRO Spectra Plus RF Interface Schematic (Sheet 1 of 2)
- ASTRO Spectra Plus RF Interface Schematic (Sheet 2 of 2)
- ASTRO Spectra Plus Digital/USB Schematic (Sheet 1 of 2)
- ASTRO Spectra Plus Digital/USB Schematic (Sheet 2 of 2)
- ASTRO Spectra Plus Audio/DC Schematic
- ASTRO Spectra Plus Voltage Conversion Schematic
- ASTRO Spectra Plus Secure Interface Schematic
- ASTRO Spectra Plus VOCON Component Location Diagram, Top View
- ASTRO Spectra Plus VOCON Component Location Diagram, Bottom View
- HLN6837A ASTRO Spectra Plus VOCON Electrical Parts List
- 7.5 VCO Section
- HLD6061D and HLD6062D VHF VCO Hybrid Schematic
- HLD6061D and HLD6062D VHF VCO Hybrid Component Location Diagram
- HLD6061D and HLD6062D Parts List
- HLD4342B and HLD4343B VHF VCO Carrier Schematic Diagram
- HLD4342D and HLD4343D VHF VCO Carrier Schematic Diagram
- HLD4342B/HLD4343B VHF VCO Carrier Component Location Diagram
- HLD4342D/HLD4343D VHF VCO Carrier Component Location Diagram
- HLD4342B and HLD4343B VHF VCO Parts List
- HLD4342D and HLD4343D VHF VCO Parts List
- UHF VCO Ranges 1, 2, 3, and 4 Hybrid Schematic
- HLE6101A UHF VCO Range 1 Hybrid and HLE6102A Range 2 Hybrid Component Location Diagram
- HLE6101A UHF VCO Range 1 Hybrid and HLE6102A UHF VCO Range 2 Hybrid Parts List
- HLE6103B UHF VCO Range 3 Hybrid and HLE6104B Range 4 Hybrid Component Location Diagram
- HLE6103B UHF VCO Range 3 Hybrid and HLE6104B UHF VCO Range 4 Hybrid Parts List
- UHF VCO Ranges 1, 2, 3, and 4 Schematic Diagram
- HLE6045B Range 1 and HLE6046B Range 2 UHF VCO Component Location Diagram
- HLE6000D Range 3 and HLE6041D Range 4 UHF VCO Component Location Diagrams
- HLE6000D and HLE6041D UHF VCO Parts List
- HLF6080B 800 MHz VCO Schematic Diagram
- HLF6080B 800 MHz VCO Component Location Diagram
- HLF6080B 800 MHz VCO Parts List
- 7.6 RX Front-End Section
- HRD6001E/6002E/6011E/6012E VHF Receiver Front-End Schematic
- HRD6001E/6002E/6011E/6012E VHF Component Location Diagram
- HRD6001E VHF RXFE Parts List
- HRD6002E Parts List
- HRD6011E Parts List
- HRD6012E Parts List
- HRD6001G/6002G/6011G/6012G VHF Receiver Front-End Schematic
- HRD6001G/6002G/6011G/6012G VHF Receiver Front-End Component Location Diagram
- HRD6001G/HRD6002G/HRD6011G/HRD6012G VHF RXFE Parts List
- HRE6001B/6002C/6003B/6004B/6011B/6012B/6014B UHF Receiver Front-End Preamp and Standard Schematics
- HRE6001B/6002C/6003B/6004B/6011B/6012B/6014B UHF Receiver Front-End Hybrid Component Location Diagram
- HRE6011B UHF RXFE Pre-Amp Parts List
- HRE6012B UHF RXFE Pre-Amp Parts List
- HRE6014B UHF RXFE Pre-Amp Parts List
- HRE6001B and HRE6002C UHF RXFE Standard Parts List
- HRE6003B and HRE6004B UHF RXFE Standard Parts List
- HRF6004B/C 800 MHz Receiver Front-End Schematic Diagram
- HRF6004B/C 800 MHz Receiver Front-End Component Location Diagram
- HRF6004B/C 800 MHz RXFE Parts List
- 7.7 Power Amplifier Section
- HLD6022C VHF 50 Watt PA Schematic
- HLD6022C VHF 50-Watt PA Component Location Diagram, Side 1
- HLD6022C VHF 50-Watt PA Component Location Diagram, Side 2
- HLD6022C VHF 50-Watt PA Parts List
- HLD6064C VHF 100-Watt PA Schematic
- HLD6064C VHF 100-Watt PA Component Location Diagram, Side 1
- HLD6064C VHF 100-Watt PA Component Location Diagram, Side 2
- HLD6064C VHF R1 100-Watt PA Parts List
- HLD6032B/HLD6066B VHF 25-Watt PA Schematic
- HLD6032B/HLD6066B VHF 25-Watt PA Component Location Diagram, Side 1
- HLD6032B/HLD6066B VHF 25-Watt PA Component Location Diagram, Side 2
- HLD6032B VHF R2 25-Watt PA Parts List
- HLD6066B VHF R1 25-Watt PA Parts List
- HLE6062B and HLE6071B UHF 25-Watt PA Schematic
- HLE6062B UHF 25-Watt PA Component Location Diagram, Side 1
- HLE6062B UHF 25-Watt PA Component Location Diagram, Side 2
- HLE6062B VHF R2 25-Watt PA Parts List
- HLE6043C, HLE6044C, and HLE6049B UHF 40-Watt PA Schematic
- HLE6043C, HLE6044C, and HLE6049B UHF 40-Watt PA Component Location Diagram, Side 1
- HLE6043C, HLE6044C, and HLE6049B UHF 40-Watt PA Component Location Diagram, Side 2
- HLE6043C UHF R3 40-Watt Parts List
- HLE6044C UHF R4 40-Watt PA Parts List
- HLE6049B UHF R1 40-Watt PA Parts List
- HLE6039C, HLE6040C, and HLE6051C UHF 100-Watt PA Schematic
- HLE6039C, HLE6040C, and HLE6051C UHF 100-Watt PA Component Location Diagram, Side 1
- HLE6039C, HLE6040C, and HLE6051C UHF 100-Watt PA Component Location Diagram, Side 2
- HLE6039C UHF R3 100-Watt PA Parts List
- HLE6040C UHF R4 100-Watt PA Parts List
- HLE6051 UHF R1 100-Watt PA Parts List
- HLF6078B 800 MHz 15-Watt PA Schematic
- HLF6078B 800 MHz 15-Watt PA Component Location Diagram, Side 1
- HLF6078B 800 MHz 15-Watt PA Component Location Diagram, Side 2
- HLF6078C 800MHz 15-Watt PA Parts List
- HLF6077D 800 MHz 35-Watt PA Schematic
- HLF6077D 800 MHz 35-Watt PA Component Location Diagram, Side 1
- HLF6077D 800 MHz 35-Watt PA Component Location Diagram, Side 2
- HLF6077D 800MHz 35-Watt PA Parts List
- 7.4 ASTRO Spectra Plus VOCON Section
- Appendix A Secure Modules
- Appendix B Replacement Parts Ordering
- Glossary
- Back cover
- Chapter 7: Schematics, Component Location Diagrams, and Parts Lists: ASTRO Spectra Plus VOCON Section
- ASTRO Digital Spectra and Spectra Plus UHF/VHF/800 MHz Mobile Radios Detailed Service Manual
Schematics, Component Location Diagrams, and Parts Lists: RF Section 7-11
68P81076C25-C July 1, 2002
HRN4009C/HRN6014C VHF RF Board Electrical Parts List
1. For optimum performance, order replacement diodes, transistors, and circuit
modules by Motorola part number only.
2. When ordering crystals, specify carrier frequency, crystal frequency, crystal
type number, and Motorola part number.
3. Part value notations:
p=10
-12
m=10
-3
n=10
-9
k=10
3
µ=10
-6
M=10
6
4. ITEM refers to the component reference designator.
5. The RF Board Kits use a 6-layer printed circuit board.
ITEM
MOTOROLA
PART NUMBER
DESCRIPTION
CAPACITOR, Fixed:
unless otherwise stated
C300 2113740B65 470pF
C301, 302 2113741N45 .01µF
C303 - - - - - Not Placed
C304 2311049J26 10pF
C305 2113741B41 6800pF
C306 2113740B69 680pF
C307 2113741N45 .01µF
C308 2311049J26 10pF
C309 2113741N57 .033µF
C310 2113741N69 0.1µF
C311 2311049J26 10pF
C312 - - - - - Not Placed
C313 2113740B65 470pF
C314 2113741N69 0.1µF
C315 2113740B73 1000pF
C316 2113743G21 1.0µF
C317 2311049J26 10pF
C318 2113740B31 18pF
C319 2113741N45 .01µF
C320 2113741N61 .047µF
C321 2113741N21 1000pF
C322, 323 - - - - - Not Placed
C324 2113741N69 0.1µF
C325, 326 2113741N45 .01µF
C327 2311049J26 10pF
C329 2113741N69 0.1µF
C330 2113740B49 100pF
C332 thru 334 2113740B49 100pF
C336, 337 2113740B49 100pF
C339 2113740B49 100pF
C341 2113740B49 100pF
C343 2113740B27 12pF
C345 2113741N69 0.1µF
C350 2113741N45 .01µF
C351 - - - - - Not Placed
C352 2113741N45 .01µF
C353 2113740B15 3.9pF
C354, 355 2113741N69 0.1µF
C357 2113740B17 4.7pF
C358 2113741N69 0.1µF
C600 2113740B49 100pF
C601 2113740B34 24pF
C604 2113741N21 1000pF
C605 2380090M06 10pF
C606, 607 2311049J26 10pF
C608 2380090M06 10pF
C609 2113741N69 0.1µF
C610 2113741N45 .01µF
C611 - - - - - Not Placed
C612 2113741N69 0.1µF
C613 2113741N45 .01µF
C614 2113740B31 18pF
C615 2113740B39 39pF
C616 2113741N45 .01µF
C617 thru 619 2113741N69 0.1µF
C620 2113741N45 .01µF
C621 2113740B25 10pF
C622 2113741N21 1000pF
C623 0880027B09 100pF
C624 2113741N45 .01µF
C625 2113741D28 0.22µF
C626 2113740B76 1500pF
C627 thru 629 2113741N45 .01µF
C630 211374 0B73 1000pF
C631 2311049J07 3.3pF
C632 2380090M06 10pF
C633 2311049J26 10pF
C634 2113740B76 1500pF
C635 2380090M06 10pF
C636 2380090M07 47pF
C637 2113741N69 0.1µF
C638 2113741N45 .01µF
C639 2113741N69 0.1µF
C641 2113740B01 1.0pF
C642 2113741N69 0.1µF
C644 2113741N69 0.1µF
C645 2113740B49 100pF
C646 2113743G21 1.0µF
C647 2113741N69 0.1µF
C648 thru 650 - - - - - Not Placed
C651 2113740B49 100pF
C652 - - - - - Not Placed
C653 2113740B49 100pF
C654 2113740B76 1500pF
C656 2113741N69 0.1µF
C657 2113740B27 12pF
C658 2113741N45 .01µF
C659 2113740B27 12pF
C660 2113741N69 0.1µF
C664 2113741N45 .01µF
C665 2113740B27 12pF
C670 2113740B79 2000pF
DIODE: See Note 1.
CR301 4880006E09 Varactor
CR350 - - - - - Not Placed
CR351 4882958R39 3.3V
CR352 4880154K03 Dual; Shottky
CR601 4880006E09 Varactor
CR602, 603 4811058B11
CR605 - - - - - Not Placed
CR606 4813830A28
CORE:
E301 2680003M03 Ferrite Bead
E302 2680004M03 Ferrite Bead
E602 2680006M02 Ferrite Bead
FILTER: See Note 2.
FL300, 301 9185128U02 LC; 450kHz
JACK:
J350 0980110M01 Receptacle, Coaxial
J500 0980104M02 Receptacle, Bottom-Entry
J601 0980103N02 Sockets, 12-Position
J602 - - - - - Not Placed
JUMPER:
JU300, 301 0611077A01 0W
JU351 0611077A01 0W
JU352 - - - - - Not Placed
JU601 0611077A01 0W
ITEM
MOTOROLA
PART NUMBER
DESCRIPTION
JU604 thru 606 - - - - - Not Placed
JU607 0611077A01 0W
JU608 - - - - - Not Placed
JU609 0611077A01 0W
JU611 - - - - - Not Placed
JU612 0611077A01 0W
JU613 thru 615 - - - - - Not Placed
JU617 0611077A01 0W
JU618 thru 620 - - - - - Not Placed
COIL, RF:
unless otherwise stated
L302 - - - - - Not Placed
L303 2411087A32 3.3µH
L304 2480140E16 10µH
L351 2480140E11 360nH
L352, 353 2405452C78 295nH
L354 2480140E16 10µH
L600 2480140E06 130nH
L603 - - - - - Not Placed
L604 2480140E01 1.2µH
L605 - - - - - Not Placed
L608 2480140E16 10µH
L610, 611 2480140E01 1.2µH
TRANSISTOR: See Note 1.
Q350 4802000P02 NPN
Q351 thru 353 - - - - - Not Placed
Q602, 603 4805128M27 SOT89
Q606 4884235R02 SOT
Q607 4880182D48 PNP
Q608 4880141L01 PNP; SOT23
Q609, 610 4880141L02 NPN; SOT23
Q670 4805218N11 SOT
RESISTOR: Ohms ±5%;
1/8W unless otherwise stated
R300 0611077A98 10k
R301 0611077A19 5.1
R302 0611077A36 27
R303 0611077B33 270k
R307, 308 0611077A46 68
R311, R312 0611077A01 0
R313 0611077A38 33
R314 0611077B09 27k
R315 0611077A98 10k
R316 0611077A94 6.8k
R317 0611077A43 51
R318 0611077A01 0
R319 - - - - - Not Placed
R320 0611077A26 10
R325 - - - - - Not Placed
R350 0611077A52 120
R351 0611077A26 10
R353 0611077A78 1.5k
R354 0611077A28 12
R355 0611077A01 0
R356 0611077A38 33
R357 0611077A98 10k
R358 0611077A10 2.2
R602 0611077A43 51
R607 0611077A74 1k
R608 0611077A98 10k
R609 0611077A62 330
R610 0611077A43 51
ITEM
MOTOROLA
PART NUMBER
DESCRIPTION
R611 0611077B31 220k
R612 - - - - - Not Placed
R613 0611077B11 33k
R614 0611077A90 4.7k
R615 0611077B47 1M
R616 0611077B07 22k
R617 0611077B11 33k
R618 0611077A28 12
R620 0611077A74 1k
R622 0611077A74 1k
R623 0611077A26 10
R624 0611077A98 10k
R625 0611077B07 22k
R626 0611077B23 100k
R627 0611077A90 4.7k
R628 thru 630 0611077A78 1.5k
R631 0611077B47 1M
R633 0611077B21 82k
R634 1880273N01 Potentiometer
R635 0611077B23 100k
R637 0611077B31 220k
R638, 639 0611077A98 10k
R640 0611077B31 220k
R641 0611077A43 51
R642 0611077A98 10k
R645 0611077B47 1M
R646, 647 0611077A98 10k
R653 0611077B11 33k
R670 0611077A90 4.7k
INTEGRATED CIRCUIT
MODULE: See Note 1.
U301 5105835U90 Hybrid, ABACUS
U302 5105469E90 5V Regulator
U600 5180291B09 Reference Oscillator
U601 5180057S09 Prescaler
U602 5180057S10 Synthesizer
CRYSTAL: See Note 2.
Y350 9180084M01 109.65MHz
MISCELLANEOUS:
2605256X01 Shield, Filter
7580094M06 Pad, VF Shock
8485865B01 Circuit Board
ITEM
MOTOROLA
PART NUMBER
DESCRIPTION
LAYER 1 (L1)
LAYER 2 (L2)
LAYER 3 (L3)
LAYER 4 (L4)
INNER LAYERS
LAYER 5 (L5)
LAYER 6 (L6)
MAEPF-18827-A
SIDE 1
SIDE 2
6-LAYER CIRCUIT BOARD DETAIL VIEWING
COPPER STEPS IN PROPER LAYER SEQUENCE