MSDS

ManualsBrandsMosquito Sentry ManualsOutdoorsRechargeable Natural Repellent System

RE: BATTERIES, WET “NON-SPILLABLE”-UN2800

GASTON BATTERY INDUSTRIAL LTD “Non-Spillable” type batteries are excepted from the

following Hazardous Material (dangerous goods) Regultations. These regulations cover

transportation via Air, Water and Ground.

Regulations:

Department of Transportation

Code of Federal Regulations Title 49

Section 173. 159 Para (d)

International Air Transport Association (IATA)

Dangerous Goods Regulations 42

Edition

Packing Instruction # 806 and Special Provision

A-67 are applicable

International Civil Aviation Organization (ICAO)

Technical Instructions for the safe transport of dangerous goods

Packing Instructions #806 and Special Provision

A-67 are applicable

International Maritirne Dangerous Goods Code (IMDG Code)

Amendment # 30 Speicial provision #238 is applicable

This is to certify that the “Non-Spillable” batteries are capable of withstanding the Vibration and

Pressure Different Tests specified in the above regulations and that at a temperature of 55 degrees

Centigrade, the electrolyte will not flow from a ruptured or cracked case and there is no free liquid

to flow. The batteries when packaged have been protected against short-circuiting and plainly

marked “ Non-Spillable Battery”.

GASTON “Non-Spillable” battery types are:

GTS Range

GT-F Range

GT-HR Range

GTS-L Range

GT Range

GT-C range

GT-M Range

----------------------- ---------------------------- ---------------------

Dong Haijun Zhang Hua Zhao Qingjiang

Corporate Quality Direct, Technology Corporate Traffic Manager

Assurance Manager

Summary of content (10 pages)

PAGE 1
RE: BATTERIES, WET “NON-SPILLABLE”-UN2800 GASTON BATTERY INDUSTRIAL LTD “Non-Spillable” type batteries are excepted from the following Hazardous Material (dangerous goods) Regultations. These regulations cover transportation via Air, Water and Ground. Regulations: Department of Transportation Code of Federal Regulations Title 49 Section 173.
PAGE 2
MATERIAL SAFETY DATA SHEET SECTION I: CHEMICAL PRODUCT AND COMPANY IDENTIFICATION Chemical/Trade Name (Identity used on label): Chemical Family/Classification: Valve Regulated Lead-Acid Battery Electric Storage Battery Synonyms/Common Name: HMIS Rating for Sulfuric Acid: Shipping Regulations: Lead Acid Battery 302X See Section IX COMPANY NAME: GASTON BATTERY INDUSTRIAL LTD ADDRESS: ROOM 1713A WELL FUNG INDUSTRIAL CENTRE, 68 TA CHUEN PING STREET,KWAICHUNG,HONGKONG CONTACT: Question Concerning M
PAGE 3
ANGLESITE 1 mg/m3 Specific Chemical Identity: STEL SULFURIC ACID (40%) 22 Common Name: 7664-93-9 3 3mg/m3 1mg/m 1mg/m3 ( 15 Min. BATTERY ELECTROLYTE (ACID) Max./8 hr.shift) SECTION III: Physical Data Material is (at normal Appearance and Odor: temperatures): Battery electrolyte (acid) is a clear to cloudy liquid with a sharp, X SOLID penetrating, pungent odor. Acid saturated lead oxide is a dark X LIQUID Gas reddish-brown to gray solid with slight acidic odor.
PAGE 4
SECTION IV: Health Hazard Information NOTE: Under normal conditions of battery use, Internal components will not present a health hazard. The following is provided for battery electrolyte (acid) and lead for exposure that may occur during battery production or container breakage or under extreme heat conditions such as fire. ROUTES AND METHODS OF ENTRY Skin Contact Battery electrolyte (acid) may cause irritative contact dermatitis. Skin Absorption Skin absorption is not a significant route of entry.
PAGE 5
The IARC study classified lead as an A3 carcinogen (animal carcinogen). While the agent is carcinogenic in experimental animals at relatively high doses, the agent is unlikely to cause cancer in humans except under uncommonly high levels of exposure. For further information, see the ACGIH's pamphlet, 1996 Threshold Limit Values and Biological Exposure Indices. EMERGENCY AND FIRST AID PROCEDURES Inhalation Consult a physician if any of the acute effects listed above develop.
PAGE 6
SECTION V: FIRE AND EXPLOSION DATA Flash Point (test method) Auto Ignition Temperature Flammable Limits in Air, % by 3/4 Vol. Hydrogen - 259°C Hydrogen 580°C (Hydrogen) Lower - 4.1 Upper - 74.2 Extinguishing Media Dry chemical, foam, or CO2 Special Fire Fighting Procedures Use positive pressure, self-contained breathing apparatus.
PAGE 7
SECTION VII: CONTROL MEASURES Engineering Controls Store lead acid batteries with adequate ventilation. Room ventilation is required for batteries utilized for standby power generation. Never recharge batteries in an unventilated, enclosed space. Work Practices Do not remove vent caps. Follow shipping and handling instructions, which are applicable to the battery type. To avoid damage to terminals and seals, do not double-stack industrial batteries.
PAGE 8
then collect residue and place in a drum or other suitable container. Dispose of as a hazardous waste. Wear acid-resistant boots, chemical face shield, chemical splash goggles, and acid-resistant gloves. DO NOT RELEASE UNNEUTRALIZED ACID! Waste Disposal Method Battery Electrolyte (Acid): Neutralize as above for a spill, collect residue, and place in a drum or suitable container. Dispose of as a hazardous waste. DO NO FLUSH LEAD-CONTAMINATED ACID INTO SEWER.
PAGE 9
SECTION I: MATERIAL IDENTIFICATION MATERIALNAME Mosquito Sentry Natural Insect Repellent Manufactor'sName Monster Mosquito Systems StreetAddress 25700 1-45 North Suite 102 City, Province,Country Spring, Texas Postal Code 77386 Chemical Name N/A MolecularWeight N/A SECTION Ingredients No Controlled Product Product IdentificationNumber 50-BUG-0650 Ready to Use o Suppliers Name Monster Mosquito Systems L.L.C. L.L.C.
PAGE 10
Material Name: Mosquito Sentry Natural Insect Repellent Ready to Use SECTI0N VI - TOXICOLOGICAL PROPERTIES OF PRODUCT Route of Entry: Il!l Skin Contact Il!l Skin Absorption Il!l Eye Contact Il!l Inhalation Acute 0 Inhalation Chronic Il!l Ingestion Effects of Acute Exposure to Product: If Ingested, may cause nausea.