Operating instructions

ManualsBrandsMontigo ManualsLawn and GardenM40DV-CR

 Check local codes and

read all instructions

prior to installation.

 Leave this manual with

the owner.

Conversion Kit

This appliance may be installed as an OEM installation in a manufac-

tured home (USA only) or mobile home and must be installed in accord-

ance with the manufacturer's instructions and the Manufactured Home

Construction and Safety Standard, Title 24 CFR, Part 3280, in the United

States or The Mobile Home Standard, CAN / CSA Z240 MH Series, in

Canada. This appliance is only for use with the type(s) of gas indicated

on the rating plate. A conversion kit is supplied with the appliance.

Warning: If the information in these instructions is not followed

exactly, a ﬁre or explosion may result causing property damage,

personal injury or loss of life.

Do not store or use gasoline or other ammable vapors and liquids in the

vicinity of this or any other appliance.

 What To Do If You Smell Gas:

• Do not try to light any appliance.

• Do not touch any electrical switch; do not use any phone in your building.

• Immediately call your gas supplier from a neighbor's phone. Follow the gas

supplier's instructions.

• If you cannot rea

ch your gas supplier, call the re department.

Installation and service must be performed by a qualiﬁed installer, service agency or

the gas supplier.

RCV725

Conversion to LP

RCV825

Conversion to Natural Gas

M40DV-PFC(MH)

M40DV-CR/

CL(MH)

Manufactured/ Mobile Home

Approved Fireplace

Summary of content (6 pages)

PAGE 1
Conversion Kit Manufactured/ Mobile Home Approved Fireplace M40DV-PFC(MH) M40DV-CR/ CL(MH) RCV725 Conversion to LP RCV825 Conversion to Natural Gas This appliance may be installed as an OEM installation in a manufactured home (USA only) or mobile home and must be installed in accordance with the manufacturer's instructions and the Manufactured Home Construction and Safety Standard, Title 24 CFR, Part 3280, in the United States or The Mobile Home Standard, CAN / CSA Z240 MH Series, in Canada.
PAGE 2
M40 Series Mobile Home Conversion Kit Table Of Contents General Information.................................................................. 2 Parts list..................................................................................... 2 A.Conversion General Information This gas conversion kit contains the necessary components for field conversion of an approved Montigo fireplace from Natural Gas (NG) to Liquid Propane (LP), or from LP to NG.
PAGE 3
M40 Series Mobile Home Conversion Kit Gas Conversion Instructions A. Conversion CAUTION - Before you begin: 1. Shut off gas at the shut-off valve and disconnect the electrical supply (if used). 2. Remove the glass door as shown in the installation instructions and remove the logs. Flip down the lower trims to access the control compartment. Ember Burner: 3. Disconnect the 1/4" tubing from the fitting on the underside of the pan base. Disconnect the fitting from the inlet side of the gas control valve. 4.
PAGE 4
M40 Series Mobile Home Conversion Kit Gas Conversion Instructions Main Burner under the gas valve. 10. Remove cover plate on both ends of the main (center) burner and remove main burner tube. (See figure 5) 11. Loosen the set screws at each end of the burner tube. Slide the sleeves out of each end of the tube and replace them with the ones from the package marked 'Main Burner Sleeves' in this kit. (See Inset, Figure 6.) Re-tighten the set screws. B. Checking the Gas Pressure 1. 12.
PAGE 5
M40 Series Mobile Home Conversion Kit Operating Instructions For Your Safety - READ BEFORE LIGHTING: WARNING: If you do not follow these instructions exactly, a fire or explosion may result causing property damage, personal injury or loss of life. A. This appliance has a pilot which must be lighted by hand. When lighting the pilot, follow these instructions exactly. B. BEFORE LIGHTING smell all around the appliance area for gas.
PAGE 6
XG0640 Rev. 01 - 02/02 Canadian Heating Products Inc. Montigo Del Ray Corp.