Owner`s manual
Page 2
You must read and understand this manual prior to installation, operation or
troubleshooting this appliance. Please retain this owner’s manual for furure reference
and maintenance.
NOTICE
XG0211 - 040912.1
Table of Contents
H*38DF PRC Panorama Indoor Gas Fireplace
INTRODUCTION .................................................................................3
BEFORE YOU START:
.......................................................................4
Section A: Before You Begin .............................................................4
Section 1:
Installation Overview and Product Dimensions
..............5
Section 2: Framing the Fireplace ..................................................6 - 7
Clearances
.................................................................................7
Installing the Standoffs .......................................................................7
Section 3:
The Direct Vent System
.............................................8 - 17
Converting from Top Vent to Rear Vent ..............................................8
Installing a Roof mounted
Termination
........................................9 - 10
Venting Layout .........................................................................9 - 10
Roof mounted
Terminations
.......................................................9
Standard Top Vent (no elbows or offsets) ..................................9
T
op Vent (two elbows one offset)
...............................................9
Top Vent (multi-elbows and offsets) ...........................................9
Standard Roof V
ent (one elbows no offsets)
...........................10
Installing a Wall mounted Termination ................................. 11
▪ Standard MT
O Installation
......................................................... 1
1
▪ Pre-installed MSR Frame ..........................................................11
▪ Pre-installed BSR Frame ...........................................................1
1
▪ Installing MOSR Frame .............................................................11
▪ Installing VSS
Termination Shield
.............................................. 1
1
▪ Installing MTKOG Heat Guard ................................................... 11
V
enting Layout
........................................................................12 - 15
▪ Top Vent, Wall mounted Graph ..................................................12
▪
Top Vent, Wall mounted termination (one elbow)
......................12
▪ Top Vent, Wall mounted termination (multi elbow) .....................12
▪
Top Vent, Wall mounted HP38PR* Graph
.................................13
▪ Top Vent, Wall mounted termination HP38PR*(one elbow) .......13
▪
Top Vent, Wall mounted termination HP38PR* (multi elbow)
....13
▪ Rear Vent, Wall mounted Graph, H*38PR* ................................14
▪ Rear V
ent, Wall mounted Graph, HP38PR*
...............................15
Venting Components ....................................................................16
Heat Shields
...............................................................................17
▪ Installing a RHS8 Wall Mounted Heat Shield ........................17
▪ Installing a RHS101 W
all Mounted Heat Shield
....................17
Section 4:
Wiring
.............................................................................18
▪ SIT Proame gas control and pilot .........................................18
▪ SIT
Nova 820 gas control and pilot
......................................18
▪ Honeywell gas control and pilot ............................................18
▪ Installing remote On/Of
f Wall Switch
.....................................18
Section 5: Installing the Gas Line ....................................................19
Fuel Conversion
...............................................................................19
Gas Pressure ...............................................................................19
Gas Connection
...............................................................................19
Section 6: Finishing ..........................................................................20
Mantels & Surrounds ........................................................................20
Section 7: Installing & Removing the Door ......................................21
Section 8:
Installing the Accessories
.........................................22 - 24
Installing the Logset ..........................................................................22
Installing the HP38PR* Logset .........................................................23
Installing Firestones ..........................................................................24
Installing Optional Burner Cover Kit in Natural Gas Fireplaces .......24
Section 9: Operation .................................................................25 - 27
▪ Start-up Sequence with Standing Continuous Pilot ...................25
▪ Start-up Sequence SIT Proame Gas valve ..............................26
▪ Start-up Sequence with Honeywell Electronic Ignition .............27
Maintenance: ........................................................................28 - 30
▪ General
...............................................................................28
▪ Cleaning ...............................................................................28
▪ Hi-Lo Burner
Adjustment
............................................................28
▪ Pilot Burner Adjustment .............................................................28
▪
Troubleshooting
.........................................................................29
▪ Replacement Parts
...................................................................30
Appendix:
........................................................................31 - 33
A. Venting Terminations ...................................................................31
B. W
arranty
...............................................................................32
C. State of Massachusetts ................................................................33