INSTALLATION INSTRUCTIONS 36" Stainless Steel Vent Hood ZV950 MONOGRAM.
Safety Information BEFORE YOU BEGIN Read these instructions completely and carefully. Ŷ IMPORTANT — Save these instructions for local inspector’s use. Ŷ IMPORTANT — Observe all governing codes and ordinances. Ŷ Note to Installer — Be sure to leave these instructions with the Consumer. Ŷ Note to Consumer — Keep these instructions with your Owner’s Manual for future reference. Ŷ Skill Level — Installation of this appliance requires basic mechanical and electrical skills.
Design Information CONTENTS Design Information 3URGXFW 'LPHQVLRQV DQG &OHDUDQFHV ........................ 3–4 2SWLRQDO $FFHVVRULHV ..................................................... 4 Installation Preparation $GYDQFH 3ODQQLQJ 'XFWZRUN )UDPLQJ ...................................................... 5 3RZHU 6XSSO\ ................................................................ 5 'XFW )LWWLQJV................................................................... Tools and Materials Required..............
Design Information PRODUCT DIMENSIONS AND CLEARANCES (Cont.) OPTIONAL ACCESSORIES Using Duct Cover Accessories =; 6'66 RSWLRQDO VWDLQOHVV VWHHO GXFW FRYHU LV DYDLODEOH IRU FHLOLQJ KHLJKWV JUHDWHU WKDQ IW DQG XS to 14 ft. Using Duct Cover Accessories $ 'XFW &RYHU $FFHVVRU\ PD\ EH UHTXLUHG IRU \RXU hood installation height. Use this chart to determine installation height and accessory for your ceiling height.
Installation Preparation ADVANCE PLANNING Ŷ 'HWHUPLQH WKH H[DFW ORFDWLRQ RI WKH YHQW KRRG Ŷ 3ODQ WKH URXWH IRU YHQWLQJ H[KDXVW WR WKH RXWGRR UV Ŷ 8VH WKH VKRUWHVW DQG VWUDLJKWHVW GXFW URXWH SRVVLEOH )RU VDWLVIDFWRU\ SHUIRUPDQFH GXFW UXQ VKRXOG QRW H[FHHG IW HTXLYDOHQW OHQJWK IRU DQ\ GXFW FRQILJXUDWLRQV Ŷ 5HIHU WR ³'XFW )LWWLQJV´ FKDUW RQ SDJH WR FRPSXWH WKH PD[LPXP SHUPLVVLEOH OHQJWK IRU GXFW UXQV WR WKH outdoors. Ŷ :KHQ DSSOLFDEOH LQVWDOO DQ\ PDNHXS UHSODFHPHQW air system in accord
Installation Preparation DUCT FITTINGS This Hood Must Use an ” Round Duct. It Can Transition to a 3-1/4” x 12” Duct. Dimensions Equivalent Length* 5RXQG VWUDLJKW 1 ft. (per foot length) ´ [ ´ VWUDLJKW 1 ft. (per foot length) HOERZ IW HOERZ IW Maximum duct length: 100 ft. for range hoods. » ´ [ ´ HOERZ 43 ft. Flexible ducting: ´ [ ´RU HOERZ IW ´ [ ´ IODW HOERZ IW ´ URXQG WR ´ [ ´ WUDQVLWLRQ 2 ft.
Installation Preparation TOOLS AND MATERIALS REQUIRED (NOT SUPPLIED) Ŷ 7DSH PHDVXUH Ŷ .QLIH Ŷ 6SLULW OHYHO Ŷ :LUH FXWWHU VWULSSHU Ŷ :LUH QXWV Ŷ (OHFWULF GULOO ZLWK DQG ELWV Ŷ 3KLOOLSV DQG IODW EODGH VFUHZGULYHUV Ŷ +DPPHU Ŷ 3OLHUV Ŷ 6DIHW\ JODVVHV Ŷ 'XFW WDSH Ŷ 7DSH WR PRXQW WHPSODWH Ŷ *ORYHV WR SURWHFW DJDLQVW VKDUS HGJHV Ŷ 9 +] RU $PS ZLUH ZLWK JURXQG 3URSHUO\ grounded branch circuit Ŷ 6WUDLQ UHOLHI IRU MXQFWLRQ FRYHU Ŷ URXQG PHWDO GXFW OHQJWK WR VXLW LQVWDOOD
Installation Preparation CHECK INSTALLATION HARDWARE DUCTWORK, WIRING LOCATIONS /RFDWH WKH KDUGZDUH DFFHVVRU\ ER[ SDFNHG ZLWK WKH hood and check contents. 'HWHUPLQH WKH H[DFW ORFDWLRQ RI WKH YHQW KRRG Ŷ /RFDWH WKH WHPSODWH SDFNHG ZLWK WKH OLWHUDWXUH ± 0HDVXUH IURP WKH ÀRRU WR WKH WRS RI WKH FRRNLQJ VXUIDFH $GG RU RWKHU recommended space) from the cooking surface to the bottom of the hood. Mark that location.
Installation Instructions 1 INSTALL FRAMING FOR HOOD SUPPORT IMPORTANT: Framing must be capable of supporting 100 lbs. 8" Min. Opening for Ductwork View From Rear Cleats 2 INSTALL MOUNTING BRACKET This vent hood must be secured to the horizontal support or wall studs. Ŷ :LWK WKH WHPSODWH WDSHG LQ SODFH XVH D SXQFK WR mark all mounting screw locations. Ŷ 'ULOO ´ SLORW KROHV DW WKH SXQFKHG ORFDWLRQV Ŷ 5HPRYH WKH WHPSODWH Ŷ 7KH VXSSRUW EUDFNHW KROHV PXVW HQWHU VWXGV RU WKH horizontal support.
Installation Instructions 4 INSTALL THE HOOD 3ODFH WKH KRRG RQ WKH EUDFNHWV DQG VOLGH OHIW RU ULJKW WR center. $GMXVW WKH LQVWDOODWLRQ OHYHOQHVV E\ WLJKWHQLQJ RU ORRVHQLQJ WKH VFUHZV ³$´ DW WKH ERWWRP RI WKH brackets. 2. Mark the 2 lower mounting holes. 3. Remove the hood from the wall. 4. Drill a pilot hole in each lower mounting hole location. The two lower holes can be enlarged to LI WKH\ GLG HQWHU VWXGV 7DS DQFKRUV IRU ZDOO fasteners into the bottom holes.
Installation Instructions 6 CONNECT ELECTRICAL 8 CONNECT ELECTRICAL 9HULI\ WKDW SRZHU LV WXUQHG Rႇ DW WKH VRXUFH Ŷ 5HPRYH SURWHFWLYH ILOP RQ WKH ILOWHUV WARNING If house wiring is not 2-wire with D JURXQG ZLUH D JURXQG PXVW EH SURYLGHG E\ WKH LQVWDOOHU :KHQ KRXVH ZLULQJ LV DOXPLQXP EH VXUH WR XVH 8 / DSSURYHG DQWL R[LGDQW FRPSRXQG DQG aluminum-to-copper connectors.
NOTE: :KLOH SHUIRUPLQJ LQVWDOODWLRQV GHVFULEHG LQ WKLV ERRN safety glasses or goggles should be worn. )RU 0RQRJUDP® ORFDO VHUYLFH LQ \RXU DUHD YLVLW monogram.com. NOTE: 3URGXFW LPSURYHPHQW LV D FRQWLQXLQJ HQGHDYRU DW 0RQRJUDP $SSOLDQFHV 7KHUHIRUH PDWHULDOV DSSHDUDQFH DQG specifications are subject to change without notice. 31-2000900 Rev.
