INSTALLATION INSTRUCTIONS 42” Island Vent Hood ZV1050 MONOGRAM.
Safety Information BEFORE YOU BEGIN Read these instructions completely and carefully. Ŷ IMPORTANT — Save these instructions for local inspector’s use. IMPORTANT — Observe all governing codes and ordinances. Ŷ Note to Installer — Be sure to leave these instructions with the Consumer. Ŷ Note to Consumer — Keep these instructions with your Owner’s Manual for future reference. Ŷ Skill Level — Installation of this appliance requires basic mechanical and electrical skills.
Design Information CONTENTS Design Information 3URGXFW 'LPHQVLRQV ...................................................... 3 'XFW &RYHU $FFHVVRULHV ............................................ Determine Installation Height ....................................... $GYDQFH 3ODQQLQJ Tools and Materials Required ....................................... 5 3RZHU 6XSSO\ ................................................................ 5 'XFW )LWWLQJV ..............................................................
Design Information DETERMINE INSTALLATION HEIGHT DUCT COVER ACCESSORIES Order the accessory at the same time as the vent hood and have on-site before installation begins. Use this chart to accurately determine the need for a 'XFW &RYHU $FFHVVRU\ Installation Heights Actual Ceiling Height Possible VENTED Installation Height Duct Cover 7'11" 29" Supplied 8'0" 30" Supplied 8'1" 30" Supplied 8'2" 25-1/2" to 30" ZX1059SFSS 8'3" 25-1/2" to 30" ZX1059SFSS 8'4" 25-1/2" to 30" ZX1059SFSS 8'5"
Advance Planning TOOLS AND MATERIALS REQUIRED POWER SUPPLY (not supplied) • Tape measure • Knife • Spirit level :LUH FXWWHU :LUH VWULSSHU :LUH QXWV (OHFWULF GULOO DQG ´ ELW 3KLOOLSV VFUHZGULYHU )ODW EODGH VFUHZGULYHU • Hammer 3OLHUV • Safety glasses • Tape to mount template *ORYHV WR SURWHFW DJDLQVW VKDUS HGJHV 9 +] RU $PS ZLUH ZLWK JURXQG properly grounded branch circuit • Strain relief for junction cover 3OXPE ERE • Center punch IMPORTANT - (Please read car
Advance Planning DUCT FITTINGS This Hood Must Use an 8” Round Duct. It Can Transition to a 3-1/4” x 12” Duct. 8VH WKLV FKDUW WR FRPSXWH PD[LPXP SHUPLVVLEOH OHQJWKV for duct runs to outdoors. NOTE: 'R QRW H[FHHG PD[LPXP SHUPLVVLEOH HTXLYDOHQW lengths! Maximum duct length: 100 foot for range hoods. Duct Piece Dimensions Equivalent Length* 5RXQG straight 1 ft. (per foot length) ´ [ ´ straight 1 ft.
Installation Preparation 1 CONSTRUCT CEILING SUPPORT Plan the location Ceiling 'HWHUPLQH WKH H[DFW ORFDWLRQ RI WKH YHQW KRRG Hood Ducting Centerline Ŷ Use a plumb bob to check location to be sure countertop/cooktop location below the hood will align H[DFWO\ Ŷ 7KH KRRG VKRXOG SURMHFW IRUZDUG ´ EH\RQG WKH front edge of the cooking appliance. See illustration. Ŷ 2EVHUYH WKH UHFRPPHQGHG VSDFH ´ EHWZHHQ WKH cooking surface and bottom of hood. Hood Front 15-3/4" 31-1/2" Approx.
Installation Preparation 1 CONSTRUCT CEILING SUPPORT (cont.) EXAMPLE B -RLVW Spacing ,QVWDOO &URVV )UDPLQJ 6\PPHWULFDOO\ $ERXW Duct/Cooktop Centerline [ &URVV )UDPLQJ 8" Duct Cooktop $OLJQ 'XFW WR Center of Cooktop Outline Front of Hood 7RS 9LHZ²&HLOLQJ -RLVWV 5XQ 3HUSHQGLFXODU WR )URQW RI +RRG EXAMPLE C [ &URVV )UDPLQJ ,QVWDOO &URVV )UDPLQJ 6\PPHWULFDOO\ $ERXW Duct/Cooktop Centerline 8" Duct -RLVW Spacing $OLJQ 'XFW WR Center of Cooktop Cookt
Installation Instructions 1 CONSTRUCT CEILING SUPPORT (cont.) Ŷ $UUDQJH FURVV IUDPLQJ LQ WKH FHLOLQJ WR VXLW WKH H[LVWLQJ VWUXFWXUH 6HH H[DPSOHV ± 6HFXUH HDFK [ EORFN ZLWK DW OHDVW IRXU ZRRG VFUHZV ´ ORQJ QRW VXSSOLHG 8VH ZRRG screws total for the two supports. Ŷ 7KH FURVV IUDPLQJ PXVW EH DFFXUDWHO\ DOLJQHG WR ensure correct positioning of the hood. Ŷ 7KH FURVV IUDPLQJ PXVW EH OHYHO LQ DOO GLUHFWLRQV Check with a spirit level and adjust if necessary.
Installation Instructions 2 REMOVE THE PACKAGING The vent hood is packed separately from the decorative GXFW FRYHU RU DFFHVVRU\ FRYHUV =; 6)66 RU =; 6)66 Ŷ 5HPRYH WKH IUDPH FRYHU SDUWV ER[ DQG SDFNDJLQJ Ŷ 5HPRYH MXQFWLRQ ER[ FRYHU Ŷ ,QVWDOO VWUDLQ UHOLHI RQWR MXQFWLRQ ER[ FRYHU 3 CHECK INSTALLATION HARDWARE AND ACCESSORIES Locate the hardware accessory pack shipped with the hood and check contents.
Installation Instructions 4 MOUNT TEMPLATE Ŷ $OLJQ WKH WHPSODWH ZLWK WKH PDUNV RQ WKH FHLOLQJ DQG tape in place. ± %H VXUH WKH WHPSODWH LV RULHQWHG FRUUHFWO\ ZLWK WKH front of the hood. Ŷ Use a plumb bob to be sure the mounting holes will provide parallel alignment with the countertop below. Ŷ Center-punch all hole locations. Ŷ 'ULOO SLORW KROHV LQ WKH VFUHZ ORFDWLRQV 8VH D ´ ELW DQG GULOO DSSUR[LPDWHO\ ´ GHHS Wire Access Holes Ŷ &XW WKH ´ GXFW RSHQLQJ DQG DSSUR[LPDWHO\ ´ ZLU
Installation Instructions 6 SECURE WIRING 7 SIZE AND INSTALL DUCTWORK Ŷ 5RXWH KRXVH ZLULQJ WKURXJK WKH FHLOLQJ KROH DQG SXOO D OHQJWK WR UHDFK WKH KRRG MXQFWLRQ ER[ DSSUR[LPDWHO\ ´ EHORZ WKH VXSSRUW Ceiling Left Side View Support Frames Tape House Wiring Ŷ 7DSH WKH ZLUH WR WKH OHIW VLGH RI WKH IUDPH VXSSRUW WR prevent damage during installation and service.
Installation Instructions 8 INSTALL DECORATIVE DUCT COVERS Right Side Front Front Ŷ 3UHWDS RU GULYH GHFRUDWLYH VFUHZ LQWR WKH VFUHZ KROHV on the support frame. This will make screw installation easier. Ŷ 6HSDUDWH WKH WZR GHFRUDWLYH GXFW FRYHUV Ŷ 6HOHFW WKH LQVLGH FRYHU WRS ZKLFK KDV WZR VFUHZ holes in the top. Ŷ 6OLGH WKH GHFRUDWLYH GXFW FRYHU RYHU WKH VXSSRUW IUDPH and push to the ceiling. Ŷ $WWDFK WR WKH KRRG VXSSRUW DW WKH WRS ZLWK VXSSOLHG decorative screws.
Installation Instructions 10 CONNECT ELECTRICAL 11 SLIDE DUCT COVER DOWN Verify that power is turned off at the source. WARNING If house wiring is not 2-wire with D JURXQG ZLUH D JURXQG PXVW EH SURYLGHG E\ WKH LQVWDOOHU :KHQ KRXVH ZLULQJ LV DOXPLQXP EH VXUH WR XVH 8/ DSSURYHG DQWLR[LGDQW FRPSRXQG DQG aluminum-to-copper connectors. AVERTISSEMENT Si le câblage de la maison Q¶HVW SDV GX W\SH j GHX[ ILOV DYHF XQ ILO GH WHUUH O¶LQVWDOODWHXU GRLW IRXUQLU XQ FLUFXLW GH WHUUH 4XDQG OHV ILOV GH OD PDLV
Installation Instructions 12 INSTALL FILTERS, FINALIZE INSTALLATION Filter Slots Ŷ 7LS WKH ILOWHU LQWR WKH ORZHU VORWV DW WKH UHDU RI WKH opening. Lift the filter and pull the knob forward until the filter rests on the slots. Ŷ 0DNH VXUH \RX KDYH HQJDJHG WKH ³&OHDQ )LOWHU 5HPLQGHU 6ZLWFK´ ZLWK WKH ULJKW VLGH JUHDVH ILOWHU by checking to see if the red light is glowing in the GLVSOD\ ,I WKH UHG OLJKW LV JORZLQJ SOHDVH DGMXVW WKH filter until the red indicator light turns off.
NOTE: :KLOH SHUIRUPLQJ LQVWDOODWLRQV GHVFULEHG LQ WKLV ERRN safety glasses or goggles should be worn. )RU 0RQRJUDP® ORFDO VHUYLFH LQ \RXU DUHD YLVLW monogram.com. NOTE: 3URGXFW LPSURYHPHQW LV D FRQWLQXLQJ HQGHDYRU DW 0RQRJUDP $SSOLDQFHV 7KHUHIRUH PDWHULDOV DSSHDUDQFH and specifications are subject to change without notice. 31-14899 Rev.
