INSTALLATION INSTRUCTIONS with Design Guide Fresh-Food Refrigerator Bar Refrigerator with Icemaker MONOGRAM.
Safety Information BEFORE YOU BEGIN Read these instructions completely and carefully. • IMPORTANT – Save these instructions for local inspector’s use. Observe all governing codes and ordinances. • Note to Installer – Be sure to leave these instructions with the Consumer. • Note to Consumer – Keep these instructions with your Owner’s Manual for future reference. WARNING If you received a damaged refrigerator, you should immediately contact your dealer or builder.
Consignes de Sécurité AVERTISSEMENT Risque d’explosion. Conservez les matériaux et vapeurs inflammables de votre réfrigérateur. Le non-respect de cette instruction peut entraîner un risque d’incendie, d’explosion ou de décès. AVERTISSEMENT Pour réduire le risque d’étouffement pendant l’installation de ce produit, ne pas laisser les petites pièces à la portée des enfants âgés de moins de 3 ans. BRANCHEMENTS ÉLECTRIQUES AVERTISSEMENT Risque d’électrocution.
Installation Instructions CONTENTS Important Information .................................................2 Parts Required ..............................................................4 Tools/Hardware Required ............................................4 Staining Wood Panel Fronts ........................................4 Caring for Your Stainless Steel .....................................4 Product Location ...........................................................4 Install Water Line ..................
Installation Instructions INSTALL WATER LINE (ZIBI240 AND ZIBS240 MODELS ONLY) WARNING Connect to potable water supply only. AVERTISSEMENT Raccordez l’appareil à une alimentation d’eau potable seulement. • A cold water supply is required for automatic icemaker operation. The water pressure must be between 20 and 120 p.s.i. (137-827 kPa). • The water line can enter the opening through the floor or back wall. Route 1/4” O.D.
Design Guide For models ZIFI240, ZIFS240, ZIBI240, ZIBS240 THE INSTALLATION SPACE SINGLE PRODUCT INSTALLATION F NOTE: Waterline location for ZIBS240 and ZIBI240 ONLY. A P N,O J Std. Cabinet Opening K Min. Cabinet Opening G,I SIDE BY SIDE PRODUCT INSTALLATION H D B, C E P N,O NOTE: Custom Handles may vary. Monogram Handle Depths see D-Handle Depth Range.
Design Guide For models ZIFI240, ZIFS240, ZIBI240, ZIBS240 THE INSTALLATION SPACE SIDE-BY-SIDE INSTALLATIONS All models may be used freestanding. For a complete refreshment center, Install a fresh food refrigerator beside a Double-Drawer refrigerator, Beverage Center, or Wine Chiller/Wine Reserve. • A side by side installation requires minimum width openings depending on if the product will be flush or standard mounted and if there are stainless or custom panels. See chart below.
Design Guide For Models ZIFS240 and ZIBS240 with Stainless Steel Door Panels and Handles for Flush and Standard Installation THE INSTALLATION SPACE PRODUCT CLEARANCES For a flush installation Install a 1/4”-wide filler strip on the hinge side. The filler strip will act as a spacer between the door case and adjacent cabinets and will prevent interference with the cabinet door swing.
Design Guide For Models ZIFI240 and ZIBI240 with Custom Door Panels and Handles for Standard Installation only THE INSTALLATION SPACE PRODUCT CLEARANCES Flush Installation not allowed with custom Door Panels and Handles The Fresh-Food Refrigerator or Bar Refrigerator with Icemaker is factory set for a 110° door swing. When installed in a corner: • Allow 16” minimum clearance on the hinge side for a full 110° door swing. • Allow 4-1/2” min.
Installation Instructions STEP 1 REMOVE PACKAGING AND INSTALLATION PARTS • Remove corner blocks and foam drawer stops. • Remove all packing material, tape and protective plastic coverings. • Remove the toekick attached to the back of the unit. • Remove the custom panel attached to the front of the unit. WARNING Small objects are a choke hazard for children. Remove and discard any parts not used. AVERTISSEMENT Les petits objects peuvent étrangler les enfants.
Installation Instructions STEP 2 REVERSING THE DOOR (Cont.) (ZIFI240 model only) • Install the new left bottom hinge pin and new door stop that are enclosed in the hardware bag. STEP 2 REVERSING THE DOOR (Cont.) (ZIFS240 model only) WARNING Follow all steps when reversing the door swing. Failure to follow these instructions, leaving off parts, or over tightening screws, can lead to the door falling off and result in injury and property damage.
Installation Instructions STEP 2 REVERSING THE DOOR (Cont.) (ZIFS240 model only) STEP 2 REVERSING THE DOOR (Cont.) (ZIFS240 model only) • Move the plug on the toekick from the left to the right and reattach toekick to the unit. • Insert the new top plug/bushing in the new top of the door. • Rotate the door 180°. • Re-insert the black screw post in the new bottom of the door. • Remove top plug/bushing from the door using a flat head screwdriver. Discard the bushing. • Rotate the door 180°.
Installation Instructions STEP 3 INSTALL CUSTOM 3/4” DOOR PANEL AND HANDLE (ZIFI240 and ZIBI240 STEP 3 INSTALL CUSTOM 3/4” DOOR PANEL AND HANDLE (ZIFI240 and ZIBI240 models only) 3/4” Overlay Panel Dimensions Model ZIFI240 and ZIBI240 require a field-installed overlay door panel. Overlay Panel • The overlay panel must be Door secured to a 1/4” thick backer panel that slides into the trim. A .10” thick spacer panel must be placed between the overlay and 1/4" backer panel. .
Installation Instructions STEP 3 INSTALL CUSTOM 3/4” DOOR PANEL AND HANDLE (ZIFI240 and ZIBI240 models only) • Slide overlay panel into the door trim. STEP 5 CONNECT WATER SUPPLY (ZIBI240 and ZIBS240 models only) WARNING Connect to potable water supply only. AVERTISSEMENT Raccordez l’appareil à une alimentation d’eau potable seulement. WARNING Electrical Shock Hazard Attach tubing clamp using existing hole only. DO NOT drill into the refrigerator.
Installation Instructions STEP 6 CONNECT POWER • Connect power cord plug to a properly grounded receptacle. • Check to make sure power is on by opening the door to see if interior light turns on. • Bar Refrigerator with Icemaker – The interior fan runs all the time except during defrost cycle when the door is open. • Fresh-Food Refrigerator – The interior fan runs all the time except when the door is open. See the Owner’s Manual for further explanation of the fan.
NOTE: While performing installations described in this book, safety glasses or goggles should be worn. NOTE: Product improvement is a continuing endeavor at Monogram. Therefore, materials, appearance and specifications are subject to change without notice. 31-1000642 02-22 GEA Monogram.
