Owner`s manual

217
CHASSIS INFORMATION — 10
2008 LAPALMA XL
NOTE:
Service must be performed every twelve (12) months, regardless of actual mileage, to protect seals, bearings and gaskets from drying out
and failing. The motorhome must be started and driven for at least 20 miles every two weeks. It is important to remember the generator
maintenance interval is based on hours of usage. Consult the OEM Owner’s Manual for the generator service interval.
Component: Action: When: Code
1. Engine Oil Dipstick Keep to Full Mark Before Each Trip + Daily Enroute EO
1 a. Engine Oil Fill Keep to Full Mark Before Each Trip + Daily Enroute
EO
1. b Engine Oil Fill Keep to Full Mark Before Each Trip + Daily Enroute
EO
2. Engine Oil Fillter
Replace Filter At Oil Change
OEM
3. Transmission Dipstick/Fill Keep to Full Mark Refer to OEM Manual TS
3a. Transmission Drain Refer to OEM Manual OEM
3b. Transmission Filter Replace Filter Refer to OEM Manual OEM
4. Engine Coolant Surge Tank Maintain Level Before Each Trip + Daily Enroute AF
5. Hydraulic Fluid Reservoir Maintain Level Before Each Trip + Daily Enroute HF
6. Hydraulic Filter Replace Filter 15,000 or Annually HF
7. Filter Fuel/Water Separator (Primary) Inspect/Replace Before Each Trip/15,000 or 6 Months FF
8. Filter Fuel (Secondary) Replace Refer to OEM Manual OEM
9. Radiator/Charge Air Cooler Inspect Weekly OEM
10. Wheel Bearings Re-Pack 30,000 or Annually HT
11. Rear Differential Change Fluid 250,000 or 3 Years MP
12. Drive Shaft Universal Joints Grease-2 Fittings 5,000 or 6 Months CL
13. Drive Shaft Slip Yoke Grease-1 Fitting 5,000 or 6 Months CL
14. Drag Link Grease-2 Fittings 5,000 or 6 Months CL
15. Center Link Grease-2 Fittings 5,000 or 6 Months CL
16. Spindles/Kingpins Grease-2 Fittings ea. 5,000 or 6 Months CL
17. Steering Intermediate Shaft Grease-3 Fittings 30,000 or Annually CL-4
18. Power Gear Hydraulic Reservoir Keep to Full Mark 6,000 or 3 Months TF
19. Tire Pressure Check Before Each Trip + Daily En route -
20. Generator Refer to OEM Manual Refer to OEM Manual OEM
21. Batteries Inspect Every 2 Weeks DW
Battery Terminals Apply Coating 10,000 or Quarterly
P
22. Air Filter Restriction Indicator Inspect Before Each Trip + Daily En route --
23. Axle Breather Vent Inspect & Clean 250,000 or 3 Years --
Lubrication Code Chart:
*CL-4
U-Joints located inside coach under
steering cover. Use chassis lubricant.
*EO
Engine oil as recommended by engine
manufacturer.
*OEM
Refer to the Original Equipment
Manufacturer’s manual.
*MP
API GL-5 or MT-1 type gear lubricant
- SAE 75W-90, Synthetic.
*HF 15W-40 Motor Oil
*CL
Chassis lubricant should be a high
quality non corrosive multi-purpose
lithium soap base lubricant that is water
resistant and designed to withstand
extremely high operating temperatures.
NLGI #2 Chassis Lubricant.
*TF Dexron 3 Mercon ATF Hydraulic Fluid.
*AF
Antifreeze as recommended by engine
manufacturer.
*BF Dot-3 Brake Fluid
FF Fuel Filter
HT High Temperature Bearing Grease
*TS TranSynd™
DW Distilled Water
P Petroleum Jelly