Installation Manual

MISHIMOTO | 18 BOULDEN CIRCLE, NEW CASTLE, DE 19720 | P 1.877.GOMISHI | WWW.MISHIMOTO.COM
®
04
25. Reinstall the hood latch, and secure it with the two original
bolts. Tip: To maintain original fi tment, line up the washers
on the bolts with the impressions they made on the hood latch.
(2x 8mm bolts)
26. Connect the electrical harness to the headlights, and install
the headlights to the vehicle. Then secure the headlights with
the eight original screws. (8x 5.5mm screws)
27. Lower the grille into place. Align the tabs on the bottom of
the grille with the clips on the grille support, and press the
grille support into them to engage the clips. Then secure the
top of the grille with the original hardware. (4x 5.5mm screws)
28. Reinstall the air diverter, and secure it with the nine tree-clips.
(9x tree-clips)
29. Start the vehicle and allow it to idle while in park. Inspect the
transmission-line connections at the cooler for leaks. Ensure
that the vehicle is parked on level ground to get an accurate
reading. Pull out the transmission fl uid dipstick and wipe it
off with a clean rag. Insert the dipstick to its full depth, and
then immediately remove it. Check the fl uid level and top it
off with Ford-approved transmission fl uid until it reaches the
cold mark on the dipstick. Step on the brake and move the
gear selector through each of the transmission ranges,
stopping in each range for a few seconds, and then return
it to the park position. Note that after adding fl uid, there
will be residual fl uid in the fi ller tube that can result in a
false reading. Allow the fl uid to drain into the pan before
attempting another reading. Let the vehicle run until it
reaches operating temperature, and check the fl uid level
again. Top off the fl uid level until it reaches the hot mark,
but do not overfi ll.
MISHIMOTO | 18 BOULDEN CIRCLE, NEW CASTLE, DE 19720 | P 877.466.4744 | WWW.MISHIMOTO.COM
Congrats! You just fi nished installing
the 2003 –2007 Ford 6.0L Powerstroke
Transmission Cooler.
'03–'07 FORD 6.0L POWERSTROKE
TRANSMISSION COOLER
INSTALLATION GUIDE
ENJOY!