Technical Specifications

M A T E R I A L S A F E T Y D A T A S H E E T
Poultice Plus
02 - 2012
Osha’s Hazard Communication Standard
U.S. Department Of Labor
29 CFR 1910.1200 OMB No. 1218-0072
Identity No: Name: Poultice Plus
Section 1
Manufacturers Name: Miracle Sealants Company
Address: 12318 Lower Azusa Road
Emergency Phone: [phone]
City: Arcadia
State: CA
Phone: [phone]
Date Prepared:
02 - 2012
Section 2 - Hazardous Ingredient/Identity Information
Hazardous Components: None
VOC: Less than or equal to 10 g/L
Section 3 - Physical/Chemical Characteristics
Boiling point: Not Available Specific gravity(H20=I): 2.35
Vapor pressure: Not Available Melting point: Not Available
Vapor density: Not Available Evaporation rate: Not Available
pH: 7.2
Solubility in water: Negligible
Appearance and odor: Off White powder, no odor
Section 4 - Fire And Explosion Hazard Data
Flash point: Not Available Flammable limits: Not Available
LEL: Not Available UEL: Not Available
NFPA hazard rating (o = Least, 4 = Extreme)
Health: 2 Fire: 0
Reactivity: 0 Other: 0
HMIS Hazard Rating:
Health: 2 Fire: 0
Reactivity: 0
Extinguishing media: None
Special fire fighting procedures: None
Unusual fire and explosion hazards: None known
Section 5 - Reactivity Data
Stability: Stable
Conditions to avoid: No special precautions.
Incompatible materials to avoid: No special precautions . (Reacts with
hydrofluoric acid: soluble in HF).
Hazardous decomposition byproducts: May react with hydrofluoric acid
(HDAC) to form toxic silicon tetra-fluoride gas.
Hazardous polymerization: Will not occur.
Section 6 - Health Hazard Data
Routes of Entry:
Inhalation - Nuisance dust
Skin - No
Ingestion - Non-hazardous
Health Hazards - In extreme exposures, some congestion may occur..
Carcinogenicity: NTP - None; IARC Monographs - Vol. 68 (1997)
Silica-Group 3 (Not classifiable as to carcinogenicity to humans);
OSHA Regulated: No
Acute health effects: Transitory upper respiratory irritant.
Chronic health effects: Inhalation of high levels of any nuisance dust over
long periods of time may cause lungs to be more vulnerable to pncumoco-
niosis (lung disease).
Signs and Symptoms of Over Exposure:
Eyes: Temporary irritation & inflammation
Skin: Not Available
Ingestion: Non-hazardous
Inhalation: Respiratory irritation. In extreme exposures some congestion
may occur.
Medical conditions which may be aggravated: Pre-existing upper
respiratory & lung disease such as, but not limited to bronchitis,
emphysema & asthma.
Emergency and First Aid Procedures:
Eyes: Flush with copious amounts of clean water for 15 minutes. If irritation
persists, consult a physician.
Skin: Wash off with soap and water. If irritation persists, call physician.
Ingestion: Do not induce vomiting. Call physician or Poison Control Center
immediately.
Inhalation: Blow nose, rinse mouth, drink water to clear throat. Remove to
fresh air.
Section 7 - Precautions For Safe Handling And Use
Steps to be taken in case material is released or spilled: Vacuum clean
spillage. If sweeping is necessary, use a dust suppressant.
Waste disposal method: Dispose of it in accordance with all federal, state
and local regulations.
Precautions to be taken in handling and storing: Use techniques that
minimize generating dust.
Other precautions: KEEP OUT OF REACH OF CHILDREN. Follow directions on
the container for proper use of this product. Material when wet, may be
slippery on a smooth surface, use caution.
Section 8 - Control Measures
Use an approved dust mask, such as particulate filter respirator.
Ventilation:
Local exhaust - Recommended
Mechanical - Sweep or vacuum all spills
Special Other - Use filter equipped vacuum to remove dust; Do not blow off
with compressed air.
Protective gloves: Not required.
Eye protection: Tight fitting, splash proof safety goggles.
Other protective clothing or equipment: Not required.
Work hygienic practices: Avoid vigorous shaking of bags. Clean clothes with
vacuum hose, not by blowing off. Wash hands thoroughly before handling
food stuffs, liquids or tobacco products. Use common sense and care
around chemicals. Never mix this product with other chemicals. Consult
your supervisor for all other hygienic and safety practices. All practices
depend on your specific business. Directions for use normally found on
label which will dictate engineering and control measures.
Section 9 - Shipping & Regulatory Classification
DOT Shipping Name: Please refer to the Bill of Lading receiving/documents
for up-to-date information.
DOT#: Not Available DOT Hazard Class: Not Available
Toxic Substances Control Act (TSCA): This product and/or all the ingredients
contained in this product have been registered under the Toxic Substances
Control Act.
SARA: No SARA 313 chemicals identified.
NOTE: Miracle Sealants believes the data set forth are accurate. Miracle
Sealants makes no warranty with respects thereto and disclaims all liability
or reliance thereon. Such data are offered solely for consideration, investi-
gation and verification. Also, the data set forth is for the concentrated fin-
ished product. All lab samples are for experimental purposes only and used
at the customers discretion.
www.miraclesealants.com