MSDS

M A T E RI A L S A F E TY D A T A S H E E T
Phosphoric Acid Cleaner
02-2009
Osha’s Hazard Communication Standard
U.S. Department Of Labor
2
9 CFR 1910.1200 OMB No. 1218-0072
Identity No: Name: Phosphoric Acid Cleaner
S
ection 1
Manufacturers Name: Miracle Sealants Company
Address: 12318 Lower Azusa Road
Emergency Phone: [phone]
City: Arcadia
state: CA
Phone: [phone]
Date Prepared:
02-2009
Section 2 - Hazardous Ingredient/Identity Information
Hazardous Components CAS # OSHA PEL ACGIH TLV
Phosphoric Acid * 7664-38-2 3 mg/m3 3 mg/m3
VOC : 0% by weight
Section 3 - Physical/Chemical Characteristics
Boiling point: Not Available Specific gravity: 1.22
Vapor pressure: Not Tested Melting point: Not tested
Vapor density: Not Tested Evaporation rate: Not tested
Solubility in water: 100%
Appearance and odor: Green, acrid odor.
Section 4 - Fire And Explosion Hazard Data
Flash point: Not Available Flammable limits: Not tested
LEL: Not tested UEL: Not tested
pH: .5 - 2.0
NFPA hazard rating (o = Least, 4 = Extreme)
Health: 2 Fire: 0
Reactivity: 0 Other: 0
HMIS Hazard Rating:
Health: 2 Fire: 0
Reactivity: 0
Extinguishing media: None
Special fire fighting procedures: None
Unusual fire and explosion hazards: None
Section 5 - Reactivity Data
Stability: Stable
Incompatible materials to avoid: Strong oxidizers
Hazardous decomposition products: CO, CO2
Hazardous polymerization: Will not occur.
Conditions to avoid: None
Section 6 - Health Hazard Data
Routes of Entry:
Eyes - Possible
Inhalation - Possible
Skin - Possible
Ingestion - Possible
Health Hazards - Same as signs and symptoms of overexposure.
Carcinogenicity:
OSHA: None NTP: None
IARC Monographs: None
Signs and Symptoms of Overexposure:
Eyes: Burning sensation
Skin: Irritant
Ingestion: Severe burning irritation
Inhalation: Burning irritation
Medical conditions aggravated by exposure: None known
Emergency and First Aid Procedures:
Eyes: Flush with water for 15 minutes. If irritation persists, call a physician.
S
kin: Wash off with soap and water; if irritation persists, call a physician.
Ingestion: Do not induce vomiting. Call a physician or Poison Control Center
immediately.
Inhalation: Get person to fresh air. If unconscious, call a physician
Section 7 - Precautions For Safe Handling And Use
Steps to be taken in case material is released or spilled: Soak up with inert,
absorbent material. Scoop up and place in proper waste disposal container.
Waste disposal method: Dispose of in accordance with federal, state and
local regulations.
Precautions to be taken in handling and storing: Store in a cool, dry place,
out of direct sunlight. Do not freeze equal to or less than 32
0
F or heat
above 110
0
F.
Other precautions: KEEP OUT OF REACH OF CHILDREN. Follow directions on
the container for proper use of this product.
Section 8 - Control Measures
Respiratory protection: Ventilate by opening all doors and windows. If
exposure above the TLV or PELrequire a NIOSH approved respirator
equipped for the exposure or suitable respiratory protection per
29 CFR 1910.134 is required.
Ventilation:
Local exhaust - If available Special - None
Mechanical - If available Other - None
Protective gloves: Plastic or rubber, chemical resistant.
Eye protection: Tight fitting, splash proof safety goggles.
Other protective clothing or equipment: Chemical resistant clothing
Work hygienic practices: Wash hands thoroughly before handling food
stuffs, liquids or tobacco products. Use common sense and care around
chemicals. Never mix this product with other chemicals. Consult your super-
visor for all other hygienic and safety practices. All practices depend on
your specific business. Directions for use normally found on label which will
dictate engineering and control measures.
Section 9 - Shipping & Regulatory Classification
DOT Shipping Name: Please refer to the Bill of Lading receiving/documents
for up-to-date information.
DOT#: NA1760 DOT Hazard Class: Not Available
Toxic Substances Control Act (TSCA): This product and/or all the ingredients
contained in this product have been registered under the Toxic Substances
Control Act.
SARA: No SARA 313 chemicals identified.
NOTE: Miracle Sealants believes the data set forth are accurate. Miracle
Sealants makes no warranty with respects thereto and disclaims all liability
or reliance thereon. Such data are offered solely for consideration, investi-
gation and verification. Also, the data set forth is for the concentrated fin-
ished product. All lab samples are for experimental purposes only and used
at the customers discretion.
www.miraclesealants.com