Specifications

Parts and Instruction Manual
Page 12
This button is located in the middle of
the electrical panel that is directly
underneath the operator’s seat. When
the red emergency button is pressed,
power will be turned off. Use this button
in case of a machine emergency. The
red knob needs to be raised in order to
run the machine. To reactivate, turn the
knob as shown by the arrows on the
switch and the button will pop up. All
operational settings are retained even
when the power is turned off and on.
The circuit breakers are located next to
the emergency disconnect button. The
6-amp breaker (indicated by black
arrow) protects all auxiliary circuits on
the machine. The 100-amp breaker
(indicated by white arrow) protects the
main system circuit (TRIO controller).
Each main component is individually
protected with an internal breaker built-
in the controller. (See fault code table)
and can be reset by turning the key
switch off a few seconds and then on
again. The 100 amp circuit breaker can
also be used as a main power
disconnect, this should be used only in
case of emergency. When tripped the
breaker removes power from the main
controller and all auxiliary power circuits.
The battery compartment is located on the rear of the machine under the recovery tank.
Unlatching the two safety latches on the side of the machine enables the operator to tilt
the recovery tank and access the batteries for servicing and maintenance (make sure
recovery tank has been drained before tilting). The battery compartment contains six, 6-
volt batteries connected in series. Connect the batteries according to the battery
connection diagram (see diagram). The recommended batteries are 275Ah (Minuteman
P.N. 956740). The two batteries positioned in the center are offset and held in position by
two steel spacers. These spacers keep the batteries from sliding inside the battery
compartment during machine use and prevent undesired stresses in the battery cables.
Be sure to replace these spacers whenever reinstalling batteries.
Emergency Disconnect Button
Circuit Breakers
Battery Compartment