Manual

ManualsBrandsMilton CAT ManualsGeneratorsD60-6 60 kW Spec Sheet

STANDBY 60 ekW 75 kVA

PRIME 55 ekW 67 kVA

60 Hz 1800 rpm 480 Volts

FACTORY INSTALLED STANDARD & OPTIONAL EQUIPMENT

System Standard Optional

Air Inlet • Dry replaceable paper element type with restriction indica-

tor

Cooling • Radiator and cooling fan complete with protective guards

• Standard ambient temperatures up to 50°C (122°F)

[ ] Radiator stone guard

[ ] Radiator transition ange

Exhaust [ ] Industrial

[ ] Residential

[ ] Critical mufers

[ ] Overhead silencer mounting kit

Fuel • Flexible fuel lines to base with NPT connections [ ] Sub-base dual wall UL listed 24 hr fuel tank

[ ] Sub-base dual wall UL listed 48 hr fuel tank

[ ] Emergency vent 12ft extension

[ ] 5 gallon spill containment

Generator • Class H insulation

• Drip proof generator air intake (NEMA 2,IP23)

• Electrical design in accordance with with BS5000

Part 99, EN61000-6, IEC60034-1, NEMA MG-1.33

• IP23 Protection

[ ] Generator upgrade 1 size

[ ] Permanent magnet excitation

[ ] Internal excitation

[ ] Anti-condensation space heater

Power Termination • Circuit breakers, UL/CSA listed, 3 pole (100% rated)

• Power center houses EMCP controller and control termina-

tions (CB)

• Segregated low voltage wiring termination panel

• NEMA 1 steel enclosure, vibration isolated

• Electrical stub-up area directly below circuit breaker

[ ] Auxiliary contacts

[ ] Shunt trip

[ ] Overload shutdown via breaker

Governor • ADEM™A4

Control Panels • EMCP 4.2 digital control panel

• Vibration isolated NEMA 1 enclosure with lockable hinged

door

• DC and AC Wiring harnesses

[ ] NFPA110 upgrade

[ ] Control panel chassis

Lube [ ] Lube oil heater

Mounting • Heavy-duty fabricated steel base with lifting points

• Anti-vibration pads to ensure vibration isolation

• Complete OSHA guarding

• Stub-up pipe ready for connection to silencer pipework

[ ] IBC Seismic and OSHPD certication per Applicable

Building Codes: IBC2000, IBC2003, IBC2006,

IBC 2009, IBC 2012, CBC 2007, CBC 2010

Starting/Charging • 12 volt starting motor

• Batteries with rack and cables

[ ] Battery charger – UL 10 amp

[ ] Battery disconnect switch

[ ] Battery removal (does not remove rack and cables)

[ ] Coolant Heater

General • High gloss polyurethane paint, Caterpillar Yellow except

rails and radiators gloss black

• Anticorrosive paint protection

• All electroplated hardware

[ ] CSA Certied

[ ] Weather protective enclosure Industrial/Critical

[ ] Sound attenuated protective enclosure

[ ] Caterpillar tool set

[ ] Caterpillar White paint