Datasheet

ManualsBrandsMICROCHIP TECHNOLOGY ManualsPMICsPMIC - gate drivers Inverting Low side TO 220 5

 2002-2013 Microchip Technology Inc. DS20001420F-page 1

TC4421/TC4422

Features:

• High Peak Output Current: 9A

• Wide Input Supply Voltage Operating Range:

- 4.5V to 18V

• High Continuous Output Current: 2A Maximum

• Fast Rise and Fall Times:

- 30 ns with 4,700 pF Load

- 180 ns with 47,000 pF Load

• Short Propagation Delays: 30 ns (Typical)

• Low Supply Current:

- With Logic ‘1’ Input – 200 µA (Typical)

- With Logic ‘0’ Input – 55 µA (Typical)

• Low Output Impedance: 1.4 (Typical)

• Latch-Up Protected: Will Withstand 1.5A Output

Reverse Current

• Input Will Withstand Negative Inputs up to 5V

• Pin-Compatible with the TC4420/TC4429

6A MOSFET Driver

• Space-saving 8-Pin 6x5 DFN-S Package

Applications:

• Line Drivers for Extra Heavily-Loaded Lines

• Pulse Generators

• Driving the Largest MOSFETs and IGBTs

• Local Power ON/OFF Switch

• Motor and Solenoid Driver

General Description:

TC4421/TC4422 are high-current buffers/drivers

capable of driving large MOSFETs and IGBTs.

These devices are essentially immune to any form of

upset, except direct overvoltage or over-dissipation.

They cannot be latched under any conditions within

their power and voltage ratings. These parts are not

subject to damage or improper operation when up to

5V of ground bounce is present on their ground

terminals. They can accept, without damage or logic

upset, more than 1A inductive current of either polarity

being forced back into their outputs. In addition, all

terminals are fully protected against up to 4 kV of

electrostatic discharge.

The TC4421/TC4422 inputs may be driven directly

from either TTL or CMOS (3V to 18V). In addition,

300 mV of hysteresis is built into the input, providing

noise immunity and allowing the device to be driven

from slowly rising or falling waveforms.

With both surface-mount and pin-through-hole

packages and four operating temperature range

offerings, the TC4421/TC4422 family of 9A MOSFET

drivers fits into any application where high gate/line

capacitance drive is required.

Package Types

(1)

OUTPUT

GND

OUTPUT

TC44218-Pin PDIP/

INPUT

GND

5-Pin TO-220

GND

INPUT

GND

OUTPUT

TC4421

TC4422

Tab is

Common

to V

Note 1: Duplicate pins must both be connected for proper operation.

2: Includes electrically isolated Exposed Thermal Pad (EP), see Table 3-1.

TC4422

OUTPUT

GND

OUTPUT

SOIJ

8-Pin 6x5 DFN-S

(2)

INPUT

GND

OUTPUT

GND

OUTPUT

TC4421 TC4422

OUTPUT

GND

OUTPUT

9A High-Speed MOSFET Drivers

Summary of content (24 pages)

PAGE 1
TC4421/TC4422 9A High-Speed MOSFET Drivers Features: General Description: • High Peak Output Current: 9A • Wide Input Supply Voltage Operating Range: - 4.5V to 18V • High Continuous Output Current: 2A Maximum • Fast Rise and Fall Times: - 30 ns with 4,700 pF Load - 180 ns with 47,000 pF Load • Short Propagation Delays: 30 ns (Typical) • Low Supply Current: - With Logic ‘1’ Input – 200 µA (Typical) - With Logic ‘0’ Input – 55 µA (Typical) • Low Output Impedance: 1.
PAGE 2
TC4421/TC4422 Functional Block Diagram VDD TC4421 Inverting 200 µA 300 mV Output TC4422 Non-Inverting Input 4.7V GND Effective Input C = 25 pF DS20001420F-page 2  2002-2013 Microchip Technology Inc.
PAGE 3
TC4421/TC4422 1.0 ELECTRICAL CHARACTERISTICS † Notice: Stresses above those listed under “Absolute Maximum Ratings” may cause permanent damage to the device. These are stress ratings only and functional operation of the device at these or any other conditions above those indicated in the operation sections of the specifications is not implied. Exposure to Absolute Maximum Rating conditions for extended periods may affect device reliability. Absolute Maximum Ratings† Supply Voltage .......................
PAGE 4
TC4421/TC4422 DC CHARACTERISTICS (OVER OPERATING TEMPERATURE RANGE) Electrical Specifications: Unless otherwise noted, over the operating temperature range with 4.5V  VDD  18V. Parameters Sym Min Typ Max Units Conditions Logic ‘1’, High-Input Voltage VIH 2.4 — — V Logic ‘0’, Low-Input Voltage VIL — — 0.8 V Input Current IIN –10 — +10 µA 0V  VIN  VDD High-Output Voltage VOH VDD – 0.025 — — V DC TEST Low-Output Voltage VOL — — 0.
PAGE 5
TC4421/TC4422 2.0 TYPICAL PERFORMANCE CURVES Note: The graphs and tables provided following this note are a statistical summary based on a limited number of samples and are provided for informational purposes only. The performance characteristics listed herein are not tested or guaranteed. In some graphs or tables, the data presented may be outside the specified operating range (e.g., outside specified power supply range) and therefore outside the warranted range.
PAGE 6
TC4421/TC4422 Note: Unless otherwise indicated, TA = +25°C with 4.5V  VDD  18V. 220 180 VDD = 18V 200 160 140 140 120 63.2 kHz 1.125 MHz 100 80 ISUPPLY (mA) ISUPPLY (mA) 160 632 kHz 60 40 0 100 1000 10,000 CLOAD (pF) 100,000 140 140 120 120 2 MHz 63.2 kHz 80 1.125 MHz 40 632 kHz 20 200 kHz 100 Frequency (kHz) 1000 22,000 pF 10,000 pF 47,000 pF 100 80 60 4700 pF 0.1 µF 40 20 kHz 20 470 pF 0 0 100 1000 10,000 CLOAD (pF) 10 100,000 FIGURE 2-8: Supply Current vs.
PAGE 7
TC4421/TC4422 Note: Unless otherwise indicated, TA = +25°C with 4.5V  VDD  18V. 50 120 VDD = 10V CLOAD = 10,000 pF 110 100 VDD = 18V CLOAD = 10,000 pF VIN = 5V 45 90 Time (nsec) Time (nsec) 80 70 60 tD2 50 40 35 tD2 tD1 30 40 tD1 30 25 20 10 20 –60 –40 –20 0 1 2 3 4 5 6 7 8 Input Amplitude (V) FIGURE 2-13: Amplitude. 9 10 Propagation Delay vs. Input 0 FIGURE 2-16: Temperature. 10-6 20 40 TA (°C) 60 80 100 120 Propagation Delay vs.
PAGE 8
TC4421/TC4422 3.0 PIN DESCRIPTIONS The descriptions of the pins are listed in Table 3-1. TABLE 3-1: PIN FUNCTION TABLE Pin No. PDIP, SOIJ Pin No. 6x5 DFN-S Pin No. TO-220 Symbol 1 1 — VDD 3.1 Description Supply input, 4.5V to 18V 2 2 1 INPUT 3 3 — NC Control input, TTL/CMOS compatible input 4 4 2 GND Ground 5 5 4 GND Ground 6 6 5 OUTPUT/OUTPUT CMOS push-pull output 7 7 — OUTPUT/OUTPUT CMOS push-pull output No connection 8 8 3 VDD Supply input, 4.
PAGE 9
TC4421/TC4422 4.0 APPLICATIONS INFORMATION +5V 90% Input VDD = 18V 0V 4.7 µF 1 tD2 tF +18V tR 90% 90% 6 10% 0V 0.1 µF 2 tD1 Output 8 0.1 µF Input 10% 10% Inverting Driver Output TC4421 7 CL = 10,000 pF +5V 90% Input 4 5 10% 0V +18V Input: 100 kHz, square wave, tRISE = tFALL  10 nsec tD1 90% tR Output 0V 90% tD2 10% tF 10% Non-Inverting Driver Note: Pinout shown is for the DFN-S, PDIP and SOIJ packages. FIGURE 4-1: TC4422 Switching Time Test Circuits.
PAGE 10
TC4421/TC4422 5.0 5.1 PACKAGING INFORMATION Package Marking Information 5-Lead TO-220 Example OR XXXXXXXXX XXXXXXXXX YYWWNNN TC4421 3 CAT e^^ 1318256 TC4421CAT 1318256 Example 8-Lead DFN-S (6x5x0.9 mm) TC4421 EMF 1318 256 NNN PIN 1 TC4421 3 EMF e^^ 1318 256 OR PIN 1 Example 8-Lead SOIJ (5.28 mm) TC4421 ESM 1318256 8-Lead PDIP (300 mil) XXXXXXXX XXXXXNNN YYWW Legend: XX...
PAGE 11
TC4421/TC4422 /HDG 3ODVWLF 7UDQVLVWRU 2XWOLQH $7 >72 @ 1RWH )RU WKH PRVW FXUUHQW SDFNDJH GUDZLQJV SOHDVH VHH WKH 0LFURFKLS 3DFNDJLQJ 6SHFLILFDWLRQ ORFDWHG DW KWWS ZZZ PLFURFKLS FRP SDFNDJLQJ A E φP CHAMFER OPTIONAL A1 Q H1 D D1 L 1 N 2 3 e b e1 c A2 8QLWV 'LPHQVLRQ /LPLWV 1XPEHU RI 3LQV ,1&+(6 0,1 1 120 0$; 3LWFK H %6& 2YHUDOO 3LQ 3LWFK H %6& 2YHUDOO +HLJKW $ ± 2YHUDOO :LGWK ( ± 2YHUDOO /HQJWK ' ± 0ROGHG 3DFNDJH /H
PAGE 12
TC4421/TC4422 /HDG 3ODVWLF 'XDO )ODW 1R /HDG 3DFNDJH 0) ± [ PP %RG\ >')1 6@ 1RWH )RU WKH PRVW FXUUHQW SDFNDJH GUDZLQJV SOHDVH VHH WKH 0LFURFKLS 3DFNDJLQJ 6SHFLILFDWLRQ ORFDWHG DW KWWS ZZZ PLFURFKLS FRP SDFNDJLQJ e D L b N N K E2 E EXPOSED PAD NOTE 1 1 2 2 NOTE 1 1 D2 BOTTOM VIEW TOP VIEW A A3 A1 NOTE 2 8QLWV 'LPHQVLRQ /LPLWV 1XPEHU RI 3LQV 0,//,0(7(56 0,1 1 120 0$; 3LWFK H 2YHUDOO +HLJKW $ %6& 6WDQGRII $ &RQWDFW 7KLFNQ
PAGE 13
TC4421/TC4422 1RWH )RU WKH PRVW FXUUHQW SDFNDJH GUDZLQJV SOHDVH VHH WKH 0LFURFKLS 3DFNDJLQJ 6SHFLILFDWLRQ ORFDWHG DW KWWS ZZZ PLFURFKLS FRP SDFNDJLQJ  2002-2013 Microchip Technology Inc.
PAGE 14
TC4421/TC4422 /HDG 3ODVWLF 'XDO ,Q /LQH 3 ± PLO %RG\ >3',3@ 1RWH )RU WKH PRVW FXUUHQW SDFNDJH GUDZLQJV SOHDVH VHH WKH 0LFURFKLS 3DFNDJLQJ 6SHFLILFDWLRQ ORFDWHG DW KWWS ZZZ PLFURFKLS FRP SDFNDJLQJ N NOTE 1 E1 1 3 2 D E A2 A L A1 c e eB b1 b 8QLWV 'LPHQVLRQ /LPLWV 1XPEHU RI 3LQV ,1&+(6 0,1 1 120 0$; 3LWFK H 7RS WR 6HDWLQJ 3ODQH $ ± ± 0ROGHG 3DFNDJH 7KLFNQHVV $ %DVH WR 6HDWLQJ 3ODQH $ ± ± 6KRXOGHU WR 6KRXOGHU :LGWK (
PAGE 15
TC4421/TC4422 Note: For the most current package drawings, please see the Microchip Packaging Specification located at http://www.microchip.com/packaging  2002-2013 Microchip Technology Inc.
PAGE 16
TC4421/TC4422 Note: For the most current package drawings, please see the Microchip Packaging Specification located at http://www.microchip.com/packaging DS20001420F-page 16  2002-2013 Microchip Technology Inc.
PAGE 17
TC4421/TC4422 Note: For the most current package drawings, please see the Microchip Packaging Specification located at http://www.microchip.com/packaging  2002-2013 Microchip Technology Inc.
PAGE 18
TC4421/TC4422 NOTES: DS20001420F-page 18  2002-2013 Microchip Technology Inc.
PAGE 19
TC4421/TC4422 APPENDIX A: REVISION HISTORY Revision F (August 2013) The following is the list of modifications: 1. 2. 3. 4. Updated package type for 8-Pin 6x5 DFN-S in Package Types(1). Updated the values in Temperature Characteristics. Updated the markings in Section 5.0, Packaging Information. Replaced all references to DFN and SOIC with DFN-S and SOIJ, respectively. Revision E (December 2012) • Added a note to each package outline drawing.  2002-2013 Microchip Technology Inc.
PAGE 20
TC4421/TC4422 NOTES: DS20001420F-page 20  2002-2013 Microchip Technology Inc.
PAGE 21
TC4421/TC4422 PRODUCT IDENTIFICATION SYSTEM To order or obtain information, e.g., on pricing or delivery, refer to the factory or the listed sales office. PART NO.
PAGE 22
TC4421/TC4422 NOTES: DS20001420F-page 22  2002-2013 Microchip Technology Inc.
PAGE 23
Note the following details of the code protection feature on Microchip devices: • Microchip products meet the specification contained in their particular Microchip Data Sheet. • Microchip believes that its family of products is one of the most secure families of its kind on the market today, when used in the intended manner and under normal conditions. • There are dishonest and possibly illegal methods used to breach the code protection feature.
PAGE 24
Worldwide Sales and Service AMERICAS ASIA/PACIFIC ASIA/PACIFIC EUROPE Corporate Office 2355 West Chandler Blvd. Chandler, AZ 85224-6199 Tel: 480-792-7200 Fax: 480-792-7277 Technical Support: http://www.microchip.com/ support Web Address: www.microchip.