User`s guide

ManualsBrandsMicrochip Technology ManualsBattery ChargerMCP1630

MCP1630 BOOST MODE LED DRIVER

DEMO BOARD USER’S GUIDE

Appendix B. Bill Of Materials (BOM)

TABLE B-1: BILL OF MATERIALS (BOM)

Qty Reference Description Manufacturer Part Number

1 C1 CAP TANT 4.7UF 16V 20% SMD 1206 Rohm TCA1C475M8R

5 C2, C3, C5,

C10, C11

CAP CERM .10UF 50V 20% 0805 SMD AVX Corporation 08055C104MAT2A

1 C4 CAP 4700PF 50V CERM CHIP 0805 Panasonic

- ECG ECJ-2VB1H472K

1 C6 CAP 1500PF 50V CERM CHIP 0805 Panasonic - ECG ECJ-2VB1H152K

1 C7 CAP 220PF 50V CERM CHIP 0805

SMD

Panasonic - ECG ECJ-2VC1H221J

3 C8, C9, C12 DO NOT POPULATE — —

1 C13 CAP 4.7UF 50V CERAMIC F 1210 Panasonic - ECG ECJ-4YF1H475Z

2 C14,C15 CAP 4.7UF 25V CERAMIC X5R 1206 Panasonic - ECG ECJ-3YB1E475M

1 D1 DIODE ZENER 500MW 12V SOD123 ON Semiconductor

MMSZ5242BT1G

1 D2 DIODE SCHOTTKY 60V 1.5A SMA International Rectifier 10MQ060NTRPBF

1 J1 CONN POWER JACK 2.5MM PCB

CIRC

CUI Inc PJ-102B

1 J3 CONN HEADER RTANG 6POS .156

TIN

Tyco Electronics/Amp 640385-6

1 J4 CONN HEADER 2POS .100 VERT TIN Molex

/Waldom

Electronics Corp

22-28-4020

1 J4 SHUNT CONN JUMPER SHORTING GOLD

FLASH

Sullins Electronics Corp. SPC02SYAN

1 L1 DO5010H-153MLD (MLD - Full Reel

250 MLB partial)

Coilcraft DO5010H-153MLD

1 LED Strip Cree® XLamp® XR-E LED ETG, Corp CR5UP-XRE

1* LED Strip 1 Set of Alligator Test Clips per board. — —

* These come in sets of ten, Ea. Will be cut in half resulting in two pieces. ( 20 pieces per set

of ten )

1 PCB RoHS Compliant Bare PCB, MCP1630

Boost Mode LED Driver Demo Board

— 104-00152

1 Q1 MOSFET Transistor Polarity:N Chan-

nel Power Dissipation:2.1W

Drain-Source Breakdown Voltage:55V

International Rectifier IRLL024NPBF

1 Q2 TRANS NPN SW 600MA 40V SOT23 NXP Semiconductors PMBT4401 T/R

1 R1 RES 200 OHM 1/4W 5% 1206 SMD Rohm MCR18EZHJ201

1 R2 RES 470 OHM 1/8W 5% 0805 SMD Rohm MCR10EZPJ471

1 R3 RES 2.0K OHM 1/8W 5% 0805 SMD Rohm MCR10EZPJ202

2 R4, R6 RES 10K OHM 1/8W 5% 0805 SMD Rohm MCR10EZPJ103

1 R5 RES 430 OHM 1/8W 5% 0805 SMD Rohm MCR10EZPJ431

1 R8 RES 160K OHM 1/8W 5% 0805 SMD Rohm MCR10EZPJ164

Note 1: The components listed in this Bill of Materials are representative of the PCB assembly. The released BOM

used in manufacturing uses all RoHS-compliant components.