Specifications

MCS‐BMS‐GATEWAYStartupGuide Revision4.0
MicroControlSystems5580EnterprisePkwy,FortMyers,FL33905USAWeb:www.mcscontrols.com
Tel:(239)6940089Fax:(239)6940031
3

TABLEOF CONTENTS
1 Introduction...............................................................................................................................................5
1.1 BTLMark–BACnetTestingLaboratory.........................................................................................................5
1.2 LonMarkCertification....................................................................................................................................5
2 Bacnet/LONWorksSetupthroughProtocessorMCS‐BMS‐GATEWAY...........................................................7
2.1 Installationstepsforthecustomer................................................................................................................7
2.2 ConfiguretheDIPSwitches...........................................................................................................................7
2.2.1 SettingtheNode/IDDeviceInstance(DIPSwitchA0–A7)forBACnetMS/TP,&MetasysN2...............7
2.2.2 SettingtheSerialBaudRate(DIPSwitchB0–B3)forBACnetMS/TP&MetasysN2..............................8
2.2.2.1 BaudRateDIPSwitchSelection......................................................................................................8
2.2.3 UsingS0–S3bankofDIPSwitchestoselectandloadConfigurationFiles.............................................9
A. LonWorks,BACnetMS/TPandN2................................................................................................9
3 InterfacingtheMCS‐BMS‐GATEWAY..........................................................................................................10
3.1 MCS‐BMS‐GATEWAYshowingconnectionports.........................................................................................10
3.2 WiringtheMCS‐BMS‐GATEWAYtoRS‐485FieldProtocol.............................Error!Bookmarknotdefined.
3.2.1 WiringdiagramforconnectingtheMCS‐Magnum................................................................................11
3.3 WiringtheMCS‐BMS‐GATEWAYFieldPorttoaLonWorksnetwork...........................................................12
3.4 Power‐UptheMCS‐BMS‐GATEWAY............................................................................................................12
3.5 MCS‐MAGNUMAddressSettings................................................................................................................13
3.6 CommissioningtheMCS‐BMS‐GATEWAYonaLonWorksnetwork............................................................15
4 CREATINGCSVFILESUSINGMCS‐CONFIG...................................................................................................20
5 InstallandRuntheUtilitySoftwaretoSetupipAddressforBACnet/IP.......................................................16
5.1 ConnectthePCtotheMCS‐BMS‐GATEWAYviatheEthernetport............................................................17
5.2 ConnecttotheMCS‐BMS‐GATEWAYusingRUI(RUInet)...........................................................................18
5.3 SetIPAddressforBACnet/IP.......................................................................................................................19
AppendixA.TroubleshootingTips.....................................................................................................................37
AppendixA.1.ConnectingAPCtotheMCS‐BMS‐GATEWAY..................................................................................37
AppendixA.2.NocommunicationbetweentheMCS‐MagnumandtheMCS‐BMS‐GATEWAY..............................37
Appendix A.3.LEDDiagnosticsforLonworksCommunicationsbetweentheMCS‐BMS‐GATEWAYanddevice.38
A.2.1LonWorksProtoCessorLED’s.....................................................................................................................38
Appendix A.4.LEDDiagnosticsforBacnetCommunicationsbetweentheMCS‐BMS‐GATEWAYanddevice.....40
A.3.1BacnetProtoCessorLED’s..........................................................................................................................40
A.2.3MainBoardLEDs.......................................................................................................................................41
AppendixB.Reference......................................................................................................................................42
AppendixB.1.Specifications....................................................................................................................................42
AppendixB.1.1. CompliancewithULRegulations............................................................................................42
AppendixB.2.AddressDIPSwitchSettings.............................................................................................................43





