Operating instructions

30 33D4051

OPERATING INSTRUCTIONS

MANUAL CONTROL LIGHTING INSTRUCTIONS

WARNING

Wait 30 seconds before readjusting the

heater when the control knob has been

turned down to a lower setting.

Push

Rotate

Push

Rotate

Figure 45 - IGN Position Figure 46 - HIGH Position Figure 47 - LOW Position

TO TURN OFF GAS TO HEATER

1. Turn control knob clockwise to OFF position to completely shut off the heater.

2. If applicable: Turn off all electric power to the heater.

1. STOP! Read the safety information.

2. Make sure the manual shutoff valve is fully open.

3. Thisheaterisequippedwithanignitiondevice(piezo)whichautomaticallylightsthepilot.

4. See Figure 43, page 29 forthelocationofthepiezoignitorandcontrolknob.Pushingascontrolknobslightly

and turn control knob clockwise to the OFF position.

NOTE: KnobcannotbeturnedtoOFFunlessknobispushedinslightly.Donotforce.

5. Wait5minutestoclearoutanygas.Thensmellforgas,includingneartheoor.IfyousmellgasSTOP!

Follow the instructions under What To do if You Smell Gas, page 29.Ifyoudonotsmellgas,gotothenext

step.

6. FromOFFposition,pushingascontrolknobslightlyandturncounterclockwise to the IGN posi-

tion. See Figure 45. Push in and hold control knob for 5 seconds.

NOTE: Ifyouarerunningtheheaterforthersttime,itwillbenecessarytopressinthecontrolknobfor

30secondstoallowairtobleedoutofthegaspiping.

7. Withthecontrolknobpushedin,pushandreleasethepiezoignitorbuttontolighttheODSpilot.Thepilot

islocatedbehindtheleftfrontlogandtheleftsideoftheburner.Ifpiezoignitordoesnotlightthepilot,see

Match Lighting Instructions, page 33.

8. Holdthecontrolknobinforanadditional10secondstopreventtheODSpilotfromshuttingoffthegas

whilethethermocoupleiswarmingup.

9. Release the control knob.

 • Iftheknobdoesnotpopoutwhenreleased,stopandimmediatelycallyourservicetechnicianorgassup-

plier.

 • IftheODSpilotwillnotstaylitafterseveraltries,pushandturnthegascontrolknobclockwise

toOFFandwait15seconds.Repeatsteps6through9.

10. Push in control knob and turn counterclockwise totheHIGHsetting.Atthislocationthecontrol

knobwillpopoutwhenpositionedcorrectly.TheknobcannowbepositionedatanypositionbetweenHIGH

andLOW.Referto Figures 46 and 47.