OSHA Material Safety Data Sheet

ManualsBrandsMetacaulk ManualsChemicals & Compounds10.15 Oz 835+ Firestop Sealant

SAFETY DATA SHEET

METACAULK

835+

Elastomeric, silicone restop sealant

Page 1

GHS CLASSIFICATION

Physical Hazards:

None

Health Hazards

Eye irritation – Category 2B

Skin irritation – Category 2

Skin sensitization – Category 1B

Carcinogenicity – Category 2

ENVIRONMENTAL HAZARDS

Hazardous to the Aquatic Environment: Not Classied

Acute aquatic toxicity: Not Classied

Chronic aquatic toxicity: Not Classied

Bioaccumulation potential: Not Classied

Rapid degradability: Not Classied

Se c t i o n 2 – Ha z a r d S id en t i fi c at i o n

Se c t i o n 1 – Pr o d u c t a n d co m Pa n y in fo r m at i o n

Product Name

Metacaulk

835+

Product Codes

66012, 66019, 66645

Chemical Family

Organic/Inorganic

Use

Firestopping sealant

Manufacturer's Name

The RectorSeal Corporation

2601 Spenwick Drive

Houston, Texas 77055 USA

ate of Validation

August 21, 2017

Date of Preparation

August 21, 201

HMIS Codes

Health 1

Flammability 2

Reactivity 0

PPI B

Emergency Telephone No.

Chemtrec 24 Hours

(800)-424-9300 USA

(703)-527-3887 International

Technical Service Telephone No.

( 800)-231-3345 or (713)-263-8001

Summary of content (8 pages)

PAGE 1
S A F E T Y D ATA S H E E T METACAULK® 835+ Elastomeric, silicone firestop sealant S ectio n 1 – P ro duct Product Name Metacaulk ® 835+ and C o m pa n y I nfor m atio n HMIS Codes Health Flammability Reactivity PPI Product Codes 66012, 66019, 66645 Chemical Family Organic/Inorganic 1 2 0 B Use Firestopping sealant Manufacturer's Name The RectorSeal Corporation 2601 Spenwick Drive Houston, Texas 77055 USA Emergency Telephone No.
PAGE 2
METACAULK® 835+ GHS Label elements, including precautionary statements GHS08: Health Hazard Signal Word: Warning Hazard Statements: H315 - Causes skin irritation. H317 - May cause an allergic skin reaction. H319 - Causes eye irritation. H351 - Suspected of causing cancer. Precautionary Statements: P201 - Obtain special instructions before use. P202 - Do not handle until all safety precautions have been read and understood. P261 - Avoid breathing dust, fume or vapors.
PAGE 3
METACAULK® 835+ INGESTION Possible irritation to mucous membranes of the mouth, throat, and stomach. SUMMARY OF CHRONIC HAZARDS None known. MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE Persons with pre-existing skin conditions or chemical allergies may be more susceptible to contact effects of the cured elastomer.
PAGE 4
METACAULK® 835+ S ectio n 4 – F irst A id M e asures If inhaled: Not a respiratory irritant. If on skin: Wash with soap and water. If irritation occurs, seek medical attention. If in eyes: Immediately flush with large amounts of water. If irritation occurs, seek medical attention. If swallowed: If swallowed, call a physician immediately. Only induce vomiting at the instruction of a physician. Never give anything by mouth to an unconscious person.
PAGE 5
METACAULK® 835+ Ketoxime Silane ACGIH TLV OSHA PEL N/D ppm N/D ppm Calcium Carbonate ACGIH TLV OSHA PEL 10 mg/m3 15 mg/m3 Carbon Black NIOSH REL OSHA PEL 3.5 mg/m3 3.5 mg/m3 Respiratory Protection (Specify Type): None required. Ventilation − Local Exhaust: Acceptable. Special: N/A Mechanical (General): Preferable. Other: N/A Protective Gloves: Wear rubber gloves. Eye Protection: Safety glasses (ANSI Z-87.1 or equivalent) Other Protective Clothing Or Equipment: Coveralls recommended.
PAGE 6
METACAULK® 835+ S ectio n 10 – S ta bilit y and R e activit y Stability: Stable Conditions To Avoid: None. Incompatibility (Materials To Avoid): None known. Hazardous Decomposition Products: CO, CO2 and fragmented hydrocarbons. Hazardous Polymerization: Will not occur. S ectio n 11 – Toxic o lo gy I nfor m atio n Chronic Health Hazards No ingredient in this product is an IARC, NTP or OSHA listed carcinogen. May cause an allergic skin reaction. Suspected of causing cancer.
PAGE 7
METACAULK® 835+ S ectio n 12 – E c o lo gica l I nfor m atio n Ecological Data Ingredient Name: Toxicity to fish: Toxicity to daphnia and other aquatic invertebrates: Ingredient Name: Toxicity to fish: Toxicity to daphnia and other aquatic invertebrates: Toxicity to algae: Ingredient Name: Toxicity to fish: Toxicity to daphnia and other aquatic invertebrates: Toxicity to algae: Toxicity to bacteria: Ketoxime Silane LC50 (Oncorhynchus mykiss (rainbow trout)): > 120 mg/L, 96 hrs.
PAGE 8
METACAULK® 835+ S ectio n 15 – R egu l atory I nfor m atio n Regulatory Data Ingredient Name: Amorphous Silica SARA 313 N/A TSCA Inventory Yes CERCLA RQ N/A RCRA Code N/A Ingredient Name: Ketoxime Silane SARA 313 N/A TSCA Inventory Yes CERCLA RQ N/A RCRA Code N/A Ingredient Name: Carbon Black SARA 313 N/A TSCA Inventory Yes CERCLA RQ N/A RCRA Code N/A Ingredient Name: Titanium Dioxide SARA 313 N/A TSCA Inventory Yes CERCLA RQ N/A RCRA Code N/A California Proposition