Service manual

Page 29 Mealstream Ovens 32Z3387 Issue 3
For the oven to operate at peak efficiency, the cavity, door and the air filters must be
kept clean.
• ALWAYS switch off at the electrical supply and allow
oven to cool for at least 20 minutes before cleaning.
• As required, wipe out spillage's with disposable paper
wipes
• NEVER use steel wool, knives or harsh abrasives on
any part of the oven
As with all electrical appliances, it is wise to have the
electrical connections inspected periodically.
Cleaning the Air Filters
A daily cleaning routine will ensure that you comply with the required hygiene standards
and will help to maintain and prolong the efficiency of your oven.
Follow the SAFETY INSTRUCTIONS at the beginning of this manual.
1 Switch on oven with microwave power only (without heat).
2 Place a container of water (1.5 litres) into the centre of the
oven cavity.
3 Set microwave power to 100%.
4 Set timer to 30 minutes and press start button at end of
steam cycle wipe out cavity with a clean cloth.
Hints and Tips for stubborn stains in the oven cavity
Wipe down regularly with a damp cloth.
Cleaning the control panel and exterior surfaces
1 Remove the air filters from each side of the oven by
sliding the filter out from the front.
2 Wash in clean, warm soapy water, rinse and pat dry. Slide
back into position through slots.
Cleaning the oven cavity and door
1 Remove food particles from the gap between the rear
baffle plate and the floor of the oven with a clean, dry
brush. ( Location A )
Remove food particles from between the inside edge of
the door and the front of the oven floor using a clean, dry
brush. ( Location B )
2 Apply non-caustic oven cleaner to interior surfaces
except door seals. Leave for the recommended time.
Wash off using a clean cloth and plenty of clean, warm
water. Dry using a fresh, clean cloth.
3 Wipe hinges with a clean, damp cloth.
DO NOT apply lubricating oil.
4 Wipe door seals carefully with a clean damp cloth.
Examine for signs of wear or damage.
Faults arising from neglect
or misuse including use
without clean filters in place
are not covered by the
guarantee. Service visits as
a result of such faults will be
chargeable.
DO NOT USE THE OVEN
WITHOUT CLEAN AIR
FILTERS IN POSITION
A
B
Door Seal
If the door seals are damaged,
the oven must be repaired by an
approved Servicer.
APPENDIX 2: Cleaning procedure Mealstream 501