Maintenance and Service Guide

150,000 miles
❑
Change engine oil and replace oil filter
❑
Change Motorcraft Premium Gold Engine Coolant
(see Exceptions on page 47 and Premium Gold
Coolant Change Record on page 48)
❑
Replace cabin air filter (if equipped)
❑
Replace climate-controlled seat filter (if equipped)
❑
Replace engine air filter
❑
Replace fuel filter (except Escape, Mariner,
F-Series [non Super Duty],
Expedition/Navigator [short wheel base only],
E-Series)
❑
Change automatic transmission/transaxle fluid
and filter (filter not required on 6F35).
(Except vehicles equipped with the TorqShift
transmission).
❑
Change manual transmission fluid (Escape)
❑
Change rear axle lubricant on all rear wheel drive
(RWD) vehicles (see pages 42 and 47).
❑
Change transfer case fluid (4x4 only)
❑
Change front differential fluid (4x4 only)
❑
Replace wheel bearings (if non-sealed bearings)
❑
Replace accessory drive belt(s) if not
replaced in the last 100,000 miles (160,000 km)
❑
Inspect steering linkage, ball joints, suspension, tie
rod ends, driveshaft, and U-joints (lubricate if
equipped with Zerk fittings)
❑
Inspect engine cooling system and hoses
❑
Inspect brake pads, shoes, rotors, drums, brake
lines and hoses and parking brake system.
❑
Inspect half shaft boots (if equipped)
❑
Inspect exhaust system and heat shields
❑
Inspect PCV valve for flow (3V engines)
❑
Inspect and lubricate 4x4 front axle U-joints
❑
Rotate tires, inspect tires for wear and measure
tread depth (vehicles with dual rear wheels
should only rotate if unusual wear is noted)
❑
Inspect the wheels and related components for
abnormal noise, wear, looseness, or drag
❑
Perform multi-point inspection (recommended)
DEALER VALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
N ORMAL S CHEDULE T RUCKS ,F ULLSIZE V ANS & SUV S
28 Scheduled Maintenance
2009 Scheduled Maintenance Guide (smg)
Scheduled Maintenance Guide
USA (fus)