Maintenance and Service Guide

60,000 miles
❑
Change engine oil and replace oil filter
❑
Change automatic transmission fluid on all
vehicles equipped with the TorqShift
transmission. Replace the externally-mounted
remote filter element for all TorqShift transmissions
(if equipped). Replace the internal TorqShift
transmission fluid filter located inside
the transmission bottom pan (vehicles without
externally-mounted remote filter only). Inspect
automatic transmission/transaxle fluid level
on all other vehicles if equipped with dipstick.
Consult your dealer for particular requirements.
❑
Replace cabin air filter (if equipped)
❑
Replace climate-controlled seat filter (if equipped)
❑
Replace engine air filter
❑
Replace fuel filter
❑
Replace wheel bearing grease and grease seals
on 4x2 wheel bearings (if non-sealed bearings)
❑
Inspect steering linkage, suspension and, if
equipped, driveshaft, ball joints and U-joints
❑
Inspect engine cooling system and hoses
❑
Inspect brake pads, shoes, rotors, drums, brake
lines and hoses and parking brake system.
❑
Inspect half shaft boots (if equipped)
❑
Inspect exhaust system and heat shields
❑
Lubricate ball joints and U-joints (if equipped
with zerk fittings)
❑
Inspect and lubricate 4x4 front axle U-joints
❑
Perform multi-point inspection (recommended)
❑
Rotate tires, inspect tires for wear and measure
tread depth (vehicles with dual rear wheels
should only rotate if unusual wear is noted)
❑
Inspect wheels for end play and noise
DEALER VALIDATION:
RO#: P&A C
ODE:
D
ATE:MILEAGE:
N ORMAL S CHEDULE T RUCKS ,F ULLSIZE V ANS & SUV S
20 Scheduled Maintenance