Owner's Manual

Servicing Your Villager
365
*
[SV44435(ALL)06/95] 1. Start the engine. Drive or idle (in neutral) the vehicle for 4
minutes.
*
[SV44440(ALL)06/95] 2. Idle the vehicle in drive for 40 seconds.
*
[SV44445(ALL)07/95] 3. Accelerate the vehicle to 45 mph (70 km/h) at 1/4 to 1/2
throttle for 10 seconds.
*
[SV44450(ALL)07/95] 4. Drive the vehicle with a steady throttle at 45 mph
(70 km/h) for 30 seconds.
*
[SV44455(ALL)06/95] 5. Idle the vehicle in drive for 40 seconds.
*
[SV44460(ALL)07/95] 6. Continue to drive the vehicle in city traffic at speeds
between 25 and 40 mph (40-60 km/h) for 15 minutes.
During the 15 minute drive cycle the following modes must
be achieved:
*
[SV44465(ALL)07/95]
a. at least 5 stop and idle modes at 10 seconds each
*
[SV44470(ALL)07/95]
b. acceleration from idles at 1/4 to 1/2 throttle position, and
*
[SV44475(ALL)07/95]
c. choose 3 different speeds to do 1.5 minute steady state
throttle drives.
*
[SV44480(ALL)07/95] 7. Accelerate the vehicle up to between 45 and 60 mph
(70-100 km/h). This should take approximately 5 minutes.
*
[SV44485(ALL)07/95] 8. Drive vehicle and hold the throttle steady at the selected
speed between 45 and 60 mph (70-100 km/h) for
approximately 5 minutes.
*
[SV44490(ALL)07/95] 9. Drive the vehicle for 5 minutes at varying speeds between 45
and 60 mph (70-100 km/h).
*
[SV44492(ALL)07/95] 10.Bring the vehicle back to idle. Idle in Drive for 40 seconds.
*
[SV44494(ALL)07/95] 11.OBD II drive cycle has been completed. Vehicle can be
turned off when convenient.
File:15vxsvn.ex
Update:Wed Jun 5 12:25:18 1996