Datasheet

ManualsBrandsMaxell ManualsAAPrimary Battery, Lithium, AA, 3.6V,

1/4

Product Name: Sizes: Date of preparation:

Lithium Thionyl Chloride Battery (ER) All Jan. 1, 2013

Company: Telephone Numbers:

Hitachi Maxell, Ltd., Energy Division, MD Dept. 81-(0)794-63-8054

Address (Number, Street, City, State, and ZIP Code): Fax Numbers:

5, Takumidai, Ono-shi, Hyogo 675-1322, Japan 81-(0)794-63-8445

The batteries are exempt articles and are not subject to the OSHA Hazard Communication Standard

Requirement. This sheet is provided as technical information only. The information and recommendations

set forth are made in good faith and are believed to be accurate as of the date of preparation. However,

Maxell makes no warranty expressed or implied.

ER Battery

Product Safety Data Sheet

Section 1 - Product and Company Identification

Section 2 - Composition/Information on Ingredients

Model Li content (g)

ER3S 0.25

ER3 0.3

ER17/33 0.5

ER6C 0.6

Model Li content (g)

ER6 0.6

ER17/50 0.8

ER18/50 0.99

Section 3 - Hazards Identification

This is a high energy density sealed battery containing dangerous (Lithium) and deleterious (Thionyl Chloride) materials. For this reason,

improper handling of the battery could lead to distortion, leakage*, overheating, explosion, fire, or generation of irritating/corrosive gases

and cause human injury or equipment trouble. Please strictly observe safety instructions.

(* Leakage is defined as an unintended escape of liquid from a battery.)

Ingredient CAS# Content (wt%)

Thionyl Chloride (SOCl

) 7719-09-7 20 to 45

Aluminum Chloride (AlCl

) 7446-70-0 2 to 6

Lithium Chloride (LiCl) 7447-41-8 0.1 to 2

Lithium (Li) 7439-93-2 2 to 6

Carbon (C) 1333-86-4 2 to 8

Lithium content for each cell

Summary of content (4 pages)

PAGE 1
ER Battery Product Safety Data Sheet The batteries are exempt articles and are not subject to the OSHA Hazard Communication Standard Requirement. This sheet is provided as technical information only. The information and recommendations set forth are made in good faith and are believed to be accurate as of the date of preparation. However, Maxell makes no warranty expressed or implied.
PAGE 2
Product Safety Data Sheet ER Battery Section 4 - First Aid Measures None unless internal materials exposure. If contents are leaked out, observe following instructions. Inhalation Fumes can cause nausea or difficulty in breathing. Remove to fresh air and consult a physician. Skin Immediately flush skin with plenty of water. If itch or irritation by chemical burn persists, consult a physician. Eyes Immediately flush eye with plenty of water for at least 15 minutes. Consult a physician immediately.
PAGE 3
Product Safety Data Sheet ER Battery Section 10 - Stability and Reactivity Stability Stable Incompatibility Water Hazardous polymerization Will not occur. Condition to avoid See section 7. Hazardous Decomposition or Byproducts Sulfur Dioxide, Hydrogen Chloride, Hydrogen Section 11 - Toxicological Information NA Section 12 - Ecological Information NA Section 13 - Disposal Condition The battery may be regulated by national or local regulation. Please follow the instructions of proper regulation.
PAGE 4
Product Safety Data Sheet ER Battery Section 15 - Regulatory Information Major applicable regulations for the transportation of lithium metal cells and batteries are as follows: • UN Model Regulations: United Nations UN/ ST/SG/AC.10/1/Rev.